Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Wood Planter
by LaurentP21
Hi all, Hammer
Nails
Cut one pallet in two piece, keaping only 2 planks attached (base of the planter).
Cut two of the planks in 3 pieces, of the size of the planter's base.
1 4
3
From one big beam, cut the 4 legs, the size you want (mine are about 50cm long).
Try to have a nice cut, this will be on the ground and attached to the base so if it is not perpendicular and at
different size, the planter will not be stable.
1
2
1. Long beam
2. Cuted beam for legs
3. Eve
Step 3: Assembly
Begin by fixing the plank between the two other on the base and fix the legs wih screws at the corners.
Then, start mounting the sides. Attach plank to the small wood on the corner with nails, then the side beside etc for
the complete turn.
Place the border on the base and nail the board to the base and the border on each side.
1. Short side
2. Long side
3. Legs
4. Base
20170331_132119_resized.jpg
Step 4: Tadaaaam
Fill your planter with mold (about 50l) and plant herbs!
Thank you!