Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
In case the film is lifted off and the silicone underneath is not damaged, please check with us about repairing
the vat.
Also please note that the build platform needs to be parallel to the PSP and touches the vat slightly– or else the
platform can press onto a corner of the PSP.
Using a small build platform will decrease the chance of lifting off the film, as a smaller platform won’t press on
the corners of the film.
2. If possible, avoid printing repeated patterns in the same area. Bubbles may appear after Teflon is severely
warped. When a bubble finds its way out, the resin will enter and Teflon film will be lifted off the silicone.
3. Lowering your lifting speed help extend the lifetime of the Teflon film. We recommend start with a
conservative 15mm/m for your first model. You can tune up later if necessary.
4. Using the front and back Acrylic to hold the container. Sidewalls may be detached from the vat or Silicone if
stressed.
5. Wipe out the residual at the corners right away after recycling the resin.
6. Do not leave your resin in the container for more than two days. If you do not recycle the resin, it is OK not
to clean up the resin but the container must be stored in a dark area. We recommend store it in its original
box.