Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
? 2
3
4
1
7 6
5
13
14 10 9
15 11
16
12
14
17
18
19
20
21
30 22
31 23
32 24
33
25
26
34
35 27
36
28
37
38
42 29
39
40
43 41
44
45
46
V07102.01.00
? 47 48
49
51
52
53 59
54
50
60
55
56
14 57
58
61
71
63 62
72
64
65
66
67
68
69
70
V07318
73
14
74
75
V04832
?
2
3
4
1
6
5 7
9
14 10
11
15
16
14
12
17 13
18
19
25
26
27 20
28
21
22
29 23
30
31
24
32
33
37
34
35
38 36
39
40
41
V06319.03.00
? 42 43
44
54
46
47
48
49 45
56
14
50
51
52
53
57
55
69
59 58
71
60
61
62
63
65
67
68
64 70
66
V07318.01.00
72
14
73
75
74
V04832.01.00
? GROUP 14-1042
Planetary Gears, Figure 14A
With PTO Drive Gear
RECOMMENDED
SERVICE REF PART SPARES FOR UNITS
LEVEL NO. NOMENCLATURE NO. REQ 1–25 26–50 51–200
OH 1 Clutch And Shaft Assembly, Rotating . . . . . . . . . . . . . . . . . 29539507 1 1 2 4
M 2 Sealring Kit, Butt Joint. Kit Contains Three
29538158 Sealrings. Two Sealrings Are Used
At This Location. Also See Section 10. . . . . . . . . . 29536405 1 1 2 4
OH 3 Shaft Assembly, Turbine. 29536214 Turbine
Shaft Assembly, 29531089 T1 Bearing,
And 29531295 C1 Hub Must Be Used Together,
And May Only Be Used Prior To MY06.
29538525 Selective Backplate May Be Required
To Meet Stack Requirements.
See SIL 23-1K2K-04. . . . . . . . . . . . . . . . . . . . . . . . 29536214 1 1 2 4
OH 3 Shaft Assembly, Turbine. 29539506 Turbine
Shaft Assembly, 29539501 T1 Bearing, And 14
29539505 C1 Hub Must Be Used Together.
29542420 Selective Backplate May Be Required
To Meet Stack Requirements.
See SIL 23-1K2K-04. . . . . . . . . . . . . . . . . . . . . . . . 29539506 1 1 2 4
4 Shaft, Turbine . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539504 * 1
OH 5 Bushing, 20 mm ID . . . . . . . . . . . . . . . . . . . . . . . . 29531005 1 2 4 8
OH 6 Housing And Gear Assembly, Rotating Clutch . . . . . . . 29540518 1 1 2 4
7 Gear, PTO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29540517 * 1
8 Not Used In This Group.
9 Housing And Bushing Assembly . . . . . . . . . . . . . . 29543232 1 2 4 8
OH 10 Bushing, Rotating Clutch . . . . . . . . . . . . . . . . 29531072 1 2 4 8
11 Housing, Rotating Clutch . . . . . . . . . . . . . . . . 29543233 * 1
OH 12 Ring, Retaining, External . . . . . . . . . . . . . . . . . . . . . . . 29536289 1 1 2 4
OH 13 Sealring, C2 Piston ID . . . . . . . . . . . . . . . . . . . . . . . . . 29536103 1 2 4 8
OH 14 Seal, C2 Balance Piston OD . . . . . . . . . . . . . . . . . . . . . 29536102 1 2 4 8
OH 15 Sealring, C2 Piston OD . . . . . . . . . . . . . . . . . . . . . . . . . 29536101 1 2 4 8
OH 16 Piston, C2 Clutch. If 29538342 C2 Piston Is Required
For Service, Use Service Rework Procedure To
Add 1.00 mm Hole To 29539653 C2 Piston.
See SIL 24-1K2K-02. . . . . . . . . . . . . . . . . . . . . . . . 29539653 1 1 2 4
OH 17 Spring Assembly, C2 Return . . . . . . . . . . . . . . . . . . . . 29536104 1 1 2 4
OH 18 O-ring, 75.92 mm ID . . . . . . . . . . . . . . . . . . . . . . . . . . . 29507437 1 2 4 8
OH 19 Housing Assembly, C1 Piston . . . . . . . . . . . . . . . . . . . 29537993 1 1 2 4
20 Ball . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115527 * 1
21 Housing, C1 Piston . . . . . . . . . . . . . . . . . . . . . . . . 29537992 * 1
OH 22 Ring, Retaining, External . . . . . . . . . . . . . . . . . . . . . . . 29536107 1 1 2 4
OH 23 Piston, C2 Balance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536105 1 1 2 4
OH 24 Ring, Retaining, Internal . . . . . . . . . . . . . . . . . . . . . . . . 29531079 1 1 2 4
OH 25 Sealring, C1 Piston ID . . . . . . . . . . . . . . . . . . . . . . . . . 29531293 1 2 4 8
OH 26 Sealring, C1 Piston OD . . . . . . . . . . . . . . . . . . . . . . . . . 29536111 1 2 4 8
OH 27 Piston, C1 Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536109 1 1 2 4
? GROUP 14-1042
Planetary Gears, Figure 14A
(cont’d)
? GROUP 14-1042
Planetary Gears, Figure 14A
(cont’d)
? GROUP 14-1042
Planetary Gears, Figure 14A
(cont’d)
GROUP 14-1044
Planetary Gears, Figure 14A
Without PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
OH 1 Clutch And Turbine Shaft Assembly, Rotating . . . . . . . . . . . 29539508 1 1 2 4
OH 6 Housing And Tone Wheel Assembly, Rotating
Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536097 1 1 2 4
7 Not Used In This Group.
OH 8 Tone Wheel, Turbine . . . . . . . . . . . . . . . . . . . . . . . 29531188 1 1 2 4
? GROUP 14-1054
Planetary Gears, Figure 14A
With PTO Drive Gear
Same As Group 14-1042
RECOMMENDED
SERVICE REF PART SPARES FOR UNITS
LEVEL NO. NOMENCLATURE NO. REQ 1–25 26–50 51–200
GROUP 14-1055
Planetary Gears, Figure 14A
Without PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
OH 1 Clutch And Turbine Shaft Assembly, Rotating . . . . . . . . . . . 29541024 1 1 2 4
OH 6 Housing And Tone Wheel Assembly, Rotating
Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536097 1 1 2 4
7 Not Used In This Group. 14
OH 8 Tone Wheel, Turbine . . . . . . . . . . . . . . . . . . . . . . . 29531188 1 1 2 4
GROUP 14-1073
Planetary Gears, Figure 14A
With PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
OH 1 Clutch And Turbine Shaft Assembly, Rotating . . . . . . . . . . . 29541023 1 1 2 4
OH 16 Piston, C2 Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539653 1 1 2 4
GROUP 14-1074
Planetary Gears, Figure 14A
Without PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
OH 1 Clutch And Turbine Shaft Assembly, Rotating . . . . . . . . . . . 29541024 1 1 2 4
OH 6 Housing And Tone Wheel Assembly, Rotating
Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536097 1 1 2 4
7 Not Used In This Group.
OH 8 Tone Wheel, Turbine . . . . . . . . . . . . . . . . . . . . . . . 29531188 1 1 2 4
OH 16 Piston, C2 Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539653 1 1 2 4
? GROUP 14-1082
Planetary Gears, Figure 14A
With PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
RECOMMENDED
SERVICE REF PART SPARES FOR UNITS
LEVEL NO. NOMENCLATURE NO. REQ 1–25 26–50 51–200
OH 3 Shaft Assembly, Turbine . . . . . . . . . . . . . . . . . . . . . . . . 29539506 1 1 2 4
OH 34 Backplate, C1 Clutch, Selective 5.94 mm . . . . . . . . . . . 29538521 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.38 mm . . . . . . . . . . . 29538522 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.83 mm . . . . . . . . . . . 29538523 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 7.28 mm . . . . . . . . . . . 29538524 AR 1 2 4
OH 37 Bearing Assembly, Thrust, T1 . . . . . . . . . . . . . . . . . . . . 29539501 1 1 2 4
OH 38 Hub, C1 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539505 1 1 2 4
GROUP 14-1083
Planetary Gears, Figure 14A
Without PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
OH 1 Clutch And Shaft Assembly, Rotating . . . . . . . . . . . . . . . . . 29539508 1 1 2 4
OH 3 Shaft Assembly, Turbine . . . . . . . . . . . . . . . . . . . . . . . . 29539506 1 1 2 4
OH 6 Housing And Tone Wheel Assembly, Rotating
Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536097 1 1 2 4
7 Not Used In This Group.
OH 8 Tone Wheel, Turbine . . . . . . . . . . . . . . . . . . . . . . . 29531188 1 1 2 4
OH 34 Backplate, C1 Clutch, Selective 5.94 mm . . . . . . . . . . . 29538521 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.38 mm . . . . . . . . . . . 29538522 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.83 mm . . . . . . . . . . . 29538523 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 7.28 mm . . . . . . . . . . . 29538524 AR 1 2 4
OH 37 Bearing Assembly, Thrust, T1 . . . . . . . . . . . . . . . . . . . . 29539501 1 1 2 4
OH 38 Hub, C1 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539505 1 1 2 4
GROUP 14-1084
Planetary Gears, Figure 14B
With PTO Drive Gear
Allison 4th Generation Controls
NOTE: See SIL 13-1K2K-05 For Important Service Information
OH 1 Clutch And Shaft Assembly, Rotating . . . . . . . . . . . . . . . . . 29542801 1 1 2 4
M 2 Sealring Kit, Butt Joint. Kit Contains Three
29538158 Sealrings. Two Sealrings Are Used
At This Location. Also See Section 10. . . . . . . . . . 29536405 1 1 2 4
OH 3 Shaft Assembly, Turbine . . . . . . . . . . . . . . . . . . . . . . . . 29549506 1 1 2 4
4 Shaft, Turbine . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539504 * 1
OH 5 Bushing, 20 mm ID . . . . . . . . . . . . . . . . . . . . . . . . 29531005 1 2 4 8
OH 6 Housing And Gear Assembly, Rotating Clutch . . . . . . . 29542802 1 1 2 4
? GROUP 14-1084
Planetary Gears, Figure 14B
(cont’d)
? GROUP 14-1084
Planetary Gears, Figure 14B
(cont’d)
? GROUP 14-1085
Planetary Gears, Figure 14B
Without PTO Drive Gear
Allison 4th Generation Controls
NOTE: See SIL 13-1K2K-05 For Important Service Information
Same As Group 14-1084, Except For Parts Listed Below.
RECOMMENDED
SERVICE REF PART SPARES FOR UNITS
LEVEL NO. NOMENCLATURE NO. REQ 1–25 26–50 51–200
OH 1 Clutch And Shaft Assembly, Rotating . . . . . . . . . . . . . . . . . 29542803 1 1 2 4
OH 6 Housing And Gear Assembly, Rotating Clutch . . . . . . . 29542804 1 1 2 4
7 Not Used In This Group.
8 Tone Wheel, Turbine . . . . . . . . . . . . . . . . . . . . . . . 29531188 * 1
GROUP 14-1086
Planetary Gears, Figure 14B
With PTO Drive Gear 14
Allison 4th Generation Controls—Hi Helix
NOTE: See SIL 13-1K2K-05 For Important Service Information
Same As Group 14-1084, Except For Parts Listed Below
OH 45 Carrier Assembly, P1 Planetary . . . . . . . . . . . . . . . . . . . . . . 29541704 1 1 2 4
OH 46 Carrier And Bushing Assembly, P1 . . . . . . . . . . . . . . . 29541705 * 1
48 Carrier, P1 Planetary . . . . . . . . . . . . . . . . . . . . . . . 29541708 * 1
54 Not Used In This Group.
OH 55 Gear, P2 Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541707 1 1 2 4
OH 58 Carrier Assembly, P2 Planetary . . . . . . . . . . . . . . . . . . . . . . 29539510 1 1 2 4
OH 59 Carrier And Bushing Assembly, P2 . . . . . . . . . . . . . . . 29539509 * 1
60 Carrier, P2 Planetary . . . . . . . . . . . . . . . . . . . . . . . 29539502 * 1
63 Not Used In This Group.
OH 64 Bearing Assembly, Roller P2 . . . . . . . . . . . . . . . . . . . . 29541706 * 8
OH 66 Gear Set, P2 Pinion. Set Contains Four
29541700 Gears. . . . . . . . . . . . . . . . . . . . . . . . . . . 29543079 1 1 2 4
OH 68 Spindle, P2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541703 4 4 8 16
69 Not Used In This Group.
OH 70 Gear, Ring, P3 Planetary . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539499 1 1 2 4
OH 71 Bearing Assembly, Thrust, T5 . . . . . . . . . . . . . . . . . . . . . . . 29541702 1 1 2 4
73 Not Used In This Group.
OH 74 Gear, P2 Sun . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541701 1 1 2 4
? GROUP 14-1087
Planetary Gears, Figure 14B
Without PTO Drive Gear
Allison 4th Generation Controls—Hi Helix
NOTE: See SIL 13-1K2K-05 For Important Service Information
Same As Group 14-1084, Except For Parts Listed Below.
RECOMMENDED
SERVICE REF PART SPARES FOR UNITS
LEVEL NO. NOMENCLATURE NO. REQ 1–25 26–50 51–200
OH 1 Clutch And Shaft Assembly, Rotating . . . . . . . . . . . . . . . . . 29542803 1 1 2 4
OH 6 Housing And Gear Assembly, Rotating Clutch . . . . . . . 29542804 1 1 2 4
7 Not Used In This Group.
8 Tone Wheel, Turbine . . . . . . . . . . . . . . . . . . . . . . . 29531188 * 1
OH 45 Carrier Assembly, P1 Planetary . . . . . . . . . . . . . . . . . . . . . . 29541704 1 1 2 4
OH 46 Carrier And Bushing Assembly, P1 . . . . . . . . . . . . . . . . 29541705 * 1
48 Carrier, P1 Planetary . . . . . . . . . . . . . . . . . . . . . . . 29541708 * 1
54 Not Used In This Group.
OH 55 Gear, P2 Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541707 1 1 2 4
OH 58 Carrier Assembly, P2 Planetary . . . . . . . . . . . . . . . . . . . . . . 29539510 1 1 2 4
OH 59 Carrier And Bushing Assembly, P2 . . . . . . . . . . . . . . . . 29539509 * 1
60 Carrier, P2 Planetary . . . . . . . . . . . . . . . . . . . . . . . 29539502 * 1
63 Not Used In This Group.
OH 64 Bearing Assembly, Roller P2 . . . . . . . . . . . . . . . . . . . . 29541706 * 8
OH 66 Gear Set, P2 Pinion. Set Contains Four
29541700 Gears. . . . . . . . . . . . . . . . . . . . . . . . . . . 29543079 1 1 2 4
OH 68 Spindle, P2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541703 4 4 8 16
69 Not Used In This Group.
OH 70 Gear, Ring, P3 Planetary . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539499 1 1 2 4
OH 71 Bearing Assembly, Thrust, T5 . . . . . . . . . . . . . . . . . . . . . . . 29541702 1 1 2 4
73 Not Used In This Group.
OH 74 Gear, P2 Sun. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541701 1 1 2 4
GROUP 14-1088
Planetary Gears, Figure 14A
With PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
OH 3 Shaft Assembly, Turbine . . . . . . . . . . . . . . . . . . . . . . . . 29539506 1 1 2 4
OH 16 Piston, C2 Clutch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539653 1 1 2 4
OH 34 Backplate, C1 Clutch, Selective 5.94 mm . . . . . . . . . . . 29538521 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.38 mm . . . . . . . . . . . 29538522 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.83 mm . . . . . . . . . . . 29538523 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 7.28 mm . . . . . . . . . . . 29538524 AR 1 2 4
OH 37 Bearing Assembly, Thrust, T1 . . . . . . . . . . . . . . . . . . . . 29539501 1 1 2 4
OH 38 Hub, C1 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539505 1 1 2 4
OH 42 Hub, C2 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536962 1 1 2 4
OH 43 Washer, Thrust, W2 . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537515 1 1 2 4
OH 44 Gear, P1 Sun . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537433 1 1 2 4
? GROUP 14-1088
Planetary Gears, Figure 14A
(cont’d)
GROUP 14-1089
Planetary Gears, Figure 14A
Without PTO Drive Gear 14
Same As Group 14-1042, Except For Parts Listed Below.
? GROUP 14-1090
Planetary Gears, Figure 14A
With PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
RECOMMENDED
SERVICE REF PART SPARES FOR UNITS
LEVEL NO. NOMENCLATURE NO. REQ 1–25 26–50 51–200
OH 3 Shaft Assembly, Turbine . . . . . . . . . . . . . . . . . . . . . . . . 29539506 1 1 2 4
OH 16 Piston, C2 Clutch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539653 1 1 2 4
OH 34 Backplate, C1 Clutch, Selective 5.94 mm . . . . . . . . . . . 29538521 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.38 mm . . . . . . . . . . . 29538522 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.83 mm . . . . . . . . . . . 29538523 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 7.28 mm . . . . . . . . . . . 29538524 AR 1 2 4
OH 37 Bearing Assembly, Thrust, T1 . . . . . . . . . . . . . . . . . . . . 29539501 1 1 2 4
OH 38 Hub, C1 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539505 1 1 2 4
OH 42 Hub, C2 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536962 1 1 2 4
OH 43 Washer, Thrust, W2 . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537515 1 1 2 4
OH 44 Gear, P1 Sun . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537433 1 1 2 4
OH 71 Gear, Ring, P3 Planetary . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537311 1 1 2 4
OH 74 Gear, P2 Sun . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29543208 1 1 2 4
OH 75 Spacer, Sun Gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541728 1 1 2 4
GROUP 14-1091
Planetary Gears, Figure 14A
Without PTO Drive Gear
Same As Group 14-1042, Except For Parts Listed Below.
OH 1 Clutch And Shaft Assembly, Rotating . . . . . . . . . . . . . . . . . 29539508 1 1 2 4
OH 3 Shaft Assembly, Turbine . . . . . . . . . . . . . . . . . . . . . . . . 29539506 1 1 2 4
OH 6 Housing And Tone Wheel Assembly, Rotating
Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536097 1 1 2 4
7 Not Used In This Group.
OH 8 Tone Wheel, Turbine . . . . . . . . . . . . . . . . . . . . . . . 29531188 1 1 2 4
OH 16 Piston, C2 Clutch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539653 1 1 2 4
OH 34 Backplate, C1 Clutch, Selective 5.94 mm . . . . . . . . . . . 29538521 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.38 mm . . . . . . . . . . . 29538522 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 6.83 mm . . . . . . . . . . . 29538523 AR 1 2 4
OH 34 Backplate, C1 Clutch, Selective 7.28 mm . . . . . . . . . . . 29538524 AR 1 2 4
OH 37 Bearing Assembly, Thrust, T1 . . . . . . . . . . . . . . . . . . . . 29539501 1 1 2 4
OH 38 Hub, C1 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29539505 1 1 2 4
OH 42 Hub, C2 Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29536962 1 1 2 4
OH 43 Washer, Thrust, W2 . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537515 1 1 2 4
OH 44 Gear, P1 Sun . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537433 1 1 2 4
OH 71 Gear, Ring, P3 Planetary . . . . . . . . . . . . . . . . . . . . . . . . . . . 29537311 1 1 2 4
OH 74 Gear, P2 Sun . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29543208 1 1 2 4
OH 75 Spacer, Sun Gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29541728 1 1 2 4