Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
LAB 1
DEPLOYING AND
MANAGING SERVER
IMAGES
17. On the Remote Installation Folder Location page, take a screen shot by pressing
Alt+Prt Scr and then paste it into your Lab1_worksheet file in the page provided
by pressing Ctrl+V.
Question
1
Question
2
22. Take a screen shot of the Windows Deployment Services Configuration Wizard
by pressing Alt+Prt Scr and then paste it into your Lab1_worksheet file in the
page provided by pressing Ctrl+V.
70-411 Administering Windows Server 2012
Question
3
Question
4
Mindset Question: So far, you have installed and configured WDS. However, right now,
the WDS server will only allow you to install Windows remotely just
as if you booted from the Windows Server 2012 installation disk.
What do you need to do to automate the installation?
Question
5
4. Take a screen shot of the Windows System Image Manager interface by pressing
Alt+Prt Scr and then paste it into your Lab01_worksheet file in the page provided
by pressing Ctrl+V.
Mindset Question: You need to update a Windows Image with a critical patch. What
are the general steps to add the patch to the Windows image?
7. Take a screen shot of the Package folder by pressing Alt+Prt Scr and then paste it
into your Lab01_worksheet file in the page provided by pressing Ctrl+V.
18. Take a screen shot of the Command Prompt by pressing Alt+Prt Scr and then
paste it into your Lab01_worksheet file in the page provided by pressing Ctrl+V.
2. In Exercise 1.2, what two images did you have to add to the WDS server to
handle the Windows installation?
70-411 Administering Windows Server 2012
3. In Exercise 1.3, what program did you use to create the unattend file?
4. In Exercise 1.3, what program should you use to verify a unattend file?
5. In Exercise 1.3, how was the Windows System Image Manager installed?
6. In Exercise 1.4, what two places did you have to define an unattend file?
7. In Exercise 1.5, what program did you use to modify a Windows image?
70-411 Administering Windows Server 2012
Lab
Challenge Adding Drivers to a Windows Image
Overview To complete this challenge, you must demonstrate how to add
drivers to a Windows image by writing the steps to complete the
tasks described in the scenerio. Since the class servers do not have
drivers to add, just write the steps as if the drivers actually existed.
Completion time 10 minutes
Over the last couple of months, you have been using WDS to deploy Windows Server
2012. Recently, you started to purchase new servers that require additional drivers that
are not included with Windows installation. You need to ensure that WDS will deploy
these drivers. What should you do?