Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
ASF-60AN
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
IMPORTANT SAFETY INFORMATION........................................................1 persons in order to avoid a hazard.
inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
INDOOR UNIT TEMPORARY OPERATIONS.....................................................................2 When the fan is rotating at high speed, it will cause injury.
Do not operate your air conditioner in a wet room such
DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
Original instructions It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
CONTENTS PAGE persons in order to avoid a hazard.
INDOOR UNIT inlet or outlet. These fins are sharp and could result in cutting injuries.
DEF./FAN ALARM
TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. indoor unit. Once you push this button, the air conditioner will
Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
IMPORTANT SAFETY INFORMATION........................................................1 Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
or paint near the unit. Condensation may form if the humidity is above 80%, the
1 TEMPORARY OPERATIONS........................................................................2 1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
AIR CONDITIONER OPERATIONS AND PERFORMANCE....................3 under FORCED AUTO mode. The remote controller operation is flashing when power is restored.
Infrared signal receiver Manual Swing
Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal.
HINTS FOR ECONOMICAL OPERATION...................................................4 Adjust the louver to achieve better cooling/heating effects
2 ADJUSTING AIR FLOW DIRECTION..........................................................4
the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
If damaged, the unit may fall and result in injury. remote controller.
4 MAINTENANCE...............................................................................................4
Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
TROUBLES........................................................................................................5 NOTE:DEF indicator(cooling and heating type) Infrared signal receiver disabled.
with the air conditioner.
SW AIR
DIRE
ING CTIO
N
RESE CLO
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
TROUBLESHOOTING....................................................................................6 with the power again. Push the ON/OFF button on the remote
Ask a qualified service person to perform this work. Arrange the drain hose to ensure smooth drainage. 3 OFF
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak.
18°C ~ 43°C
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation
8 If the refrigerant leaks in the room, contact with a fire of a
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating 17°C ~ 32°C
-7°C ~ 43°C
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type)
(for the models with low 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) temperature cooling system) 5.2 Adjust the Vertical louver
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C 0°C ~ 30°C (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. Adjust the air flow direction properly to avoid winding toward automatically.
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating Drying operation 18°C ~ 43°C 17°C ~ 32°C
Ask your dealer for installation of the air conditioner. type) your body.
fire may break out. or fan only indicator(cooling only type)
Incomplete installation performed by yourself may result in a Infrared signal receiver
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator
NOTE
situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 1 If air conditioner is used outside the above conditions, it may In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
cause the unit to function abnormally.
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 2 The phenomenon is normal that the surface of air To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
conditioning may condense water when the relative larger
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating
In order to avoid electric shock, fire or injury, or if you humidity in room, please close the door and window.
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL
3 Optimum performance will be achieved within these Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
operating temperature range.
Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. CAUTION
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons If you don't plan to use the unit for a long time, please discon-
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7 ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
grounded and that the earth wire is not connected to gas or responsible for their safety. switch the power on 12 hours before you restart the unit to
Never replace a fuse with that of wrong rated current or Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3
Use of wire or copper wire may cause the unit to break down play with the appliance. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit
replace the filter with a new one(replaceable air filter is an
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency.
7. FOLLOWING SYMPTOMS ARE NOT AIR
1 3.2-10.5KW CONDITIONER TROUBLES Symptom 5: Dust comes out of the unit
Open the air intake with the screwdriver or something like
When the unit is used for the first time in a long time.
that .(Refer to Fig.6-1) Symptom 1: The system does not operate This is because dust has gotten into the unit.
Take out the air filter.(Refer to Fig.6-2)
Clean the air cleaning filter with water or vacuum cleaer,then The air conditioner does not start immediately after the ON/OFF
dry it in cool place. button on the romote controller is pressed. Symptom 6: The units can give off odours
Re-install the air filter in the reverse order of Fig.6-2. If the operation lamp lights, the system is in normal condition.To
prevent overloading of the compressor motor, the air The unit can absorb the smell of rooms, furniture, cigarettes,
2 14-16KW conditioner starts 3 minutes after it is turned ON. etc., and then emit it again.
Directly pull out the air filter from air inlet as indicated in
If the operation lamp and the "PRE-DEF indicator(cooling and Symptom 7: The outdoor unit fan does not
Fig.6-3.
heating type) or fan only indicator(cooling only type)" light, it spin.
Clean the air cleaning filter with water or vacuum cleaner,
means you choose the heating model, When just starting, if the
then dry it in cool place.
compressor has not started, the indoor unit appears "anti cold
202000192523
Re-install the air filter in the reverse order of Fig.6-3.
wind" protection because of its overlow outlet temperature.
During operation. The speed of the fan is controlled in order to 20130925
optimize product operation.
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
CONTENTS PAGE It is not good for your health to expose your body to the Do not operate the air conditioner with a wet hand. For fixed-frequency type,this function is used to operate the unit
3 air flow for a long time. An electric shock may happen. temporarily in case you misplace the remote controller or its
Three-minute protection feature
If the supply cord is damaged, it must be replaced by the MANUAL OPERATION TIMER
batteries are exhausted. Two modes including FORCED
5. ADJUSTING AIR FLOW DIRECTION
manufacturer, its service agent or similarly qualified A protection feature prevents the air conditioner from being
Do not insert fingers, rods or other objects into the air Do not touch the heat exchanger fins. AUTO and FORCED COOL can be selected through the activated for approximately 3 minutes when it restarts immedi-
persons in order to avoid a hazard.
INDOOR UNIT
IMPORTANT SAFETY INFORMATION........................................................1 inlet or outlet. These fins are sharp and could result in cutting injuries. TEMPORARY BUTTON on the air-in grill control box of the ately after operation. 5.1 Adjust the horizontal louver
When the fan is rotating at high speed, it will cause injury. DEF./FAN ALARM indoor unit. Once you push this button, the air conditioner will
TEMPORARY OPERATIONS.....................................................................2 Do not operate your air conditioner in a wet room such
Do not place items which might be damaged by moisture as a bathroom or laundry room.
run in such order: FORCED AUTO, FORCED COOL, OFF, Power failure Auto-swing
AIR CONDITIONER OPERATIONS AND PERFORMANCE............................3
Never use a flammable spray such as hair spray, lacquer under the indoor unit. and back to FORCED AUTO.
Power failure during operation will stop the unit completely. Press SWING V button, the louver will swing up and down
HINTS FOR ECONOMICAL OPERATION.....................................................4 or paint near the unit. Condensation may form if the humidity is above 80%, the
1
1 FORCED AUTO automatically.
It may cause a fire. drain outlet is blocked or the filter is polluted. Temperature indecator The OPERATION lamp is lit, and the air conditioner will run The OPERATION lamp on the indoor unit will start
ADJUSTING AIR FLOW DIRECTION..........................................................4
under FORCED AUTO mode. The remote controller operation is flashing when power is restored. Manual Swing
Infrared signal receiver
MAINTENANCE.........................................................................................4 Never touch the air outlet or the horizontal blades while After a long use, check the unit stand and fitting for enabled to operate according to the received signal. Adjust the louver to achieve better cooling/heating effects
2 FOLLOWING SYMPTOMS ARE NOT AIR CONDITIONER the swing flap is in operation.
Fingers may become caught or the unit may break down.
damage. NOTE:DEF indicator(cooling and heating type)
or FAN indicator(cooling only type) 2 FORCED COOL
To restart operation, push the ON/OFF button on the when cooling /heating.
TROUBLES..........5 If damaged, the unit may fall and result in injury. remote controller.
4 TROUBLESHOOTING.................................................................................6 Display panel Fig. 2-4
The OPERATION lamp flashes, the air conditioner will turn to
FORCED AUTO after it is enforced to cool with a wind speed of
Never put any objects into the air inlet or outlet. To avoid oxygen deficiency, ventilate the room Lighting or a car wireless telephone operating nearby
AU
TO
6
CO
OL
DR TEM
Y
SE P
HE T
AT CLOC
FAN K
SET
Objects touching the fan at high speed can be dangerous. HIGH for 30 minutes. The remote controller operation is
HOU
FAN R
SW
ING
2. TEMPORARY OPERATIONS
T LOCK OK CK
C/H
Disconnect the unit with the power and then connect the unit
TIM
E OFF
5
Never inspect or service the unit by yourself.
OWNER'S MANUAL
Ask a qualified service person to perform this work. 3 OFF with the power again. Push the ON/OFF button on the remote
Arrange the drain hose to ensure smooth drainage.
The air conditioner consists of the indoor unit, the outdoor unit, The OPERATION lamp goes off. The air conditioner is OFF controller to restart operation.
Incomplete drainage may cause wetting of the building, Fig. 5-1
8 8 Do not dispose this product as unsorted municipal furniture etc.
the connecting pipe and the remote controller. (See Fig.1)
while the remote controller operation is enabled.
Refrigerant Leakage Detection(optional): When cooling
waste. Collection of such waste separately for special MANUAL
Function indicators on indoor unit display panel
, , Adjust the louver horizontally.
7 treatment is necessary. Never touch the internal parts of the controller.
Do not remove the front panel. Some parts inside are
OPERATION TIMER DEF./FAN ALARM NOTE With this new technology, the dipsplay area will appear EC (if
applicable) and the LED indication lamps continue flashing
1. IMPORTANT SAFETY INFORMATION Do not dispose of electrical appliances as unsorted dangerous to touch, and a machine trouble may happen. This manual does not include Remote Controller when the outdoor unit detects refrigerant leakage.
municipal waste, use separate collection facilities. MANUAL OPERATION TIMER Operations, see the<<Remote Controller Owner's
To prevent injury to the user or other people and property Contact you local government for information regarding the Never expose little children, plants or animals directly to manual>> packed with the unit for details. Louver Angle Memory Function(optional):
damage, the following instructions must be followed. Incorrect connection systems available. the air flow. Display panel Fig. 2-5 For some models, the machine is special designed with louver
operation due to ignoring of instructions may cause harm or
Adverse influence to little children, animals and plants may angle memory function.Power failure during operation or
damage. 3. AIR CONDITIONER OPERATIONS AND
9
DEF./FAN ALARM
If electrical appliances are disposed of in landfills or result. pressing the ON/OFF button on the remote controller will stop
9
Display panel Fig. 2-1
those who are hypersensitive to chemicals. Fig. 5-3
18°C ~ 43°C / 64 °F~109°F
7 CAUTION
The refrigerant in the air conditioner is safe and normally
does not leak. -7°C ~ 43°C / 20 °F~109°F
8 7 Do not place appliances which produce open fire in Display panel Fig. 2-6 Cooling operation (for the models with low
8 If the refrigerant leaks in the room, contact with a fire of a 17°C ~ 32°C
Failure to observe a caution may result in injury or damage places exposed to the air flow from the unit or under the PRE-DEF indicator(cooling and heating temperature cooling system)
to the equipment. burner, a heater or a cooker may result in a harmful gas. indoor unit.
Infrared signal receiver type) ( 62 °F ~ 90°F) 4. HINTS FOR ECONOMICAL OPERATION
It may cause incomplete combustion or deformation of the Timer indicator
or fan only indicator(cooling only type) 18°C ~ 52°C / 64 °F~126°F 5.2 Adjust the Vertical louver
(for special tropical models)
Turn off any combustible heating devices, ventilate the unit due to the heat. The following should be noticed to ensure an economical operation.
9 room, and contact the dealer where you purchased the
Heating operation
(cooling only type without) -7°C ~ 24°C / 20 °F ~ 76°F 0°C ~ 30°C / 32 °F~86°F (Refer to corresponding chapterfor details) Auto-swing
WARNING unit. Do not install the air conditioner at any place where
MANUAL
Press SWING H button, the louver will swing left and right
Do not use the air conditioner until a service person confirms flammable gas may leak out. 18°C ~ 43°C / 64 °F~109°F automatically.
Drying operation 17°C ~ 32°C Adjust the air flow direction properly to avoid winding toward
that the portion where the refrigerant leaks is repaired. If the gas leaks out and stays around the air conditioner, a PRE-DEF indicator(cooling and heating 18°C ~ 52°C / 64 °F~126°F
Ask your dealer for installation of the air conditioner. type) ( 62 °F ~ 90°F) your body.
fire may break out. (for special tropical models)
Incomplete installation performed by yourself may result in a Infrared signal receiver or fan only indicator(cooling only type)
water leakage, electric shock, and fire. Operation lamp Alarm indicator Temporary button Operation lamp Table 3-2(for inverter type air conditioner) Adjust the room temperature properly to get a comfortable
The appliance is not intended for use by young children Temporary button
CAUTION or infirm persons without supervision.
Temperature indecator situation and to avoid supercooling and superheat.
8 Ask your dealer for improvement, repair, and Temperature Outdoor Room
8 8 maintenance.
Do not use the air conditioner for other purposes. This appliance can be used by children aged from 8 Display panel Fig. 2-2 Mode temperature temperature
In cooling, close the curtains to avoid direct sunlight.
Fig. 5-4
Fig.1 Incomplete improvement, repair, and maintenance may result years and above and persons with reduced physical,
in a water leakage, electric shock, and fire. In order to avoid any quality deterioration, do not use the unit 0°C ~ 50°C / 32 °F~122°F To keep cool or warm air in the room, never open doors or
INDOOR UNIT OUTDOOR UNIT for cooling precision instruments, food, plants, animals or sensory or mental capabilities or lack of experience and windows more often than necessary.
Cooling operation -15°C ~ 50°C / 5 °F~122°F 17°C ~ 32°C
works of art. knowledge if they have been given supervision or PRE-DEF indicator(cooling and heating ( 62 °F ~ 90°F)
In order to avoid electric shock, fire or injury, or if you (for the models with low
1 Air flow louver (at air outlet) 7 Connecting pipe detect any abnormality such as smell of fire, turn off the
instruction concerning use of the appliance in a safe way
Operation lamp
type)
or fan only indicator(cooling only type)
MANUAL temperature cooling system) Set the timer for the desired operating time.
Before cleaning, be sure to stop the operation, turn the and understand the hazards involved. Children shall not
2 Air inlet (with air filter in it) 8 Air inlet power supply and call your dealer for instructions.
breaker off or pull out the supply cord. play with the appliance.Cleaning and user maintenance
Heating operation
(cooling only type without)
-15°C ~ 24°C / 5 °F~76°F 0°C ~ 30°C / 32 °F~86°F Never put obstructions near the air outlet or the air inlet. Or it 6. MAINTENANCE
shall not be made by children without supervision.
3 Installation part 9 Air outlet Never let the indoor unit or the remote controller get wet. Otherwise, an electric shock and injury may result.
Timer indicator Alarm indicator Temperature indecator 17°C ~ 32°C
will cause lower efficiency, even a sudden stop.
It may cause an electric shock or a fire. Drying operation 0°C ~ 50°C / 32 °F~122°F
4 Display panel In order to avoid electric shock or fire, make sure that an This appliance is not intended for use by persons ( 62 °F ~ 90°F)
If you don't plan to use the unit for a long time, please discon-
CAUTION
earth leak detector is installed. (including children) with reduced physical, sensory or nect power and remove the batteries from the remote control-
5 Remote controller Never press the button of the remote controller with a
hard, pointed object.
mental capabilities,or lack of experience and knowledge,
Display panel Fig. 2-7
NOTE ler. When the power switch is connected, some energy will be Before you clean the air conditioner, be sure the power
Be sure the air conditioner is grounded. unless they have been given supervision or instruction
6 Drain pipe The remote controller may be damaged.
In order to avoid electric shock, make sure that the unit is concerning use of the appliance by a person 1 If air conditioner is used outside the above conditions, it may
consumed, even if the air conditioner isn't in operation. So supply is off.
Timer indicator Alarm indicator Infrared signal receiver please disconnect the power to save energy. And please
responsible for their safety. cause the unit to function abnormally.
Never replace a fuse with that of wrong rated current or grounded and that the earth wire is not connected to gas or switch the power on 12 hours before you restart the unit to
2 The phenomenon is normal that the surface of air Check if the wiring is not broken off or disconnected.
water pipe, lightning conductor or telephone earth wire. ensure a smooth operation.
NOTE other wires when a fuse blows out. Children should be supervised to ensure that they do not
Display panel Fig. 2-3 conditioning may condense water when the relative larger
Use of wire or copper wire may cause the unit to break down play with the appliance. humidity in room, please close the door and window. Use a dry cloth to wipe the indoor unit and remote
Thank you very much for purchasing our air conditioner, All the pictures in this manual are for explanation purpose only. They may be slightly different from the air or cause a fire. In order to avoid injury, do not remove the fan guard of A clogged air filter will reduce cooling or heating efficiency,
For inverter type,this switch is used for after-sales service 3 Optimum performance will be achieved within these controller.
Before using your air conditioner, please read this manual carefully and keep it for future reference. the outdoor unit. please clean it once two weeks.
conditioner you purchased(depend on model). The actual shape shall prevail. purpose only,the user should not push it. operating temperature range.
1 2 3 4
If the accumulated dust is too heavy to be cleaned, please Symptom 4.3: Outdoor unit Outdoor TEMP. sensor checking channel is
replace the filter with a new one(replaceable air filter is an
• E4
abnormal
optional fitting). When the tone of operating noise changes.
This noise is caused by the change of frequency. • Outdoor malfunction E6
5 6 7 8
NOTE CONCERNING PROTECTION OF ENVIRONMENT
This product must not be disposed of via normal household waste after its service life, but
must be taken to a collection station for the recycling of electrical and electronic devices. The
symbol on the product, the operating instructions or the packaging indicate such disposal
procedures. The materials are recyclable in accordance with their respective symbols. By
means of re-use, material recycling or any other form of recycling old appliances you are
making an important contribution to the protection of our environment. Please ask your local council where
your nearest disposal station is located.
This unit is containing fluorinated gases included in the Kyoto protocol. The maintanance and the liquidation
must be carried out by qualified personel.
Type of refrigerant: R410A
The composition of the cooling medium R410A: (50% HFC-32, 50% HFC-125)
The quantity of the refrigerant: please see the unit label.
The value GWP: 2088
GWP = Global Warming Potential
In case of quality problem or other please contact your local supplier or authorized service center.
Emergency number: 112
PRODUCER
Producer: SINCLAIR CORPORATION Ltd., 1-4 Argyll St., London W1F 7LD, UK, www.sinclair-eu.com
This product was manufactured in China (Made in China).
www.nepa.cz