Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. GENERAL
This chapter describes those units and components which furnish a means of manually controlling the
flight attitude characteristics of the airplane. The flight controls for the airplane consist of ailerons, roll trim
cartridges, rudder, elevator, pitch trim cartridges, and flap system.
12137-001
15 Sep 2003 27-00 Page 1
2. TROUBLESHOOTING
Roll trim oscillation. Aileron trim tab misadjusted. Perform Adjustment/Test - Aileron
Trim Tab. (Refer to 27-10)
Stiff system pulleys restrict aileron Inspect aileron system pulleys for
movement. freedom of movement and replace
if necessary.
Stiff hinge bearings restrict aile- Inspect hinge bearings for free-
ron and elevator movement. dom of movement and replace if
necessary.
Pitch trim oscillation. Elevator cable misaligned on sys- Inspect elevator pulleys for abnor-
tem pulley. mal wear on pulley flange. Verify
correct cable installation and per-
form Adjustment/Test - Elevator
System Rigging. (Refer to 27-30)
Stiff system pulleys restrict eleva- Inspect elevator system pulleys for
tor movement. freedom of movement and replace
if necessary.
Stiff hinge bearings restrict eleva- Inspect hinge bearings for free-
tor movement. dom of movement and replace if
necessary.
Excessive freeplay at elevator Loose actuation arm on pitch trim Remove pitch trim motor assem-
trailing edge. motor assembly. bly. Disassemble actuation arm.
Correctly position actuation arm to
shaft of motor and reassemble.
Install pitch trim motor assembly.
(Refer to 27-30)
9
1 10
11
3
12
14 13
15
LEGEND
1. Stall Warning System (27-31)
2. Roll Trim System (27-10)
3. Elevator System Cables (27-30)
4. Rudder/Aileron Interconnect System (27-20)
5. Flap System (27-50)
6. Elevator System Cables (27-30)
7. Empennage Flight Controls (27-20)
8. Pitch Trim System (27-30)
9. Rudder System Cables (27-20)
10. Rudder/Elevator Pulley Gang (27-20)
11. Aileron System Pulleys (27-10)
12. Aileron System Cables (27-10)
13. Yoke Grip Assembly (27-10)
14. Yoke Assembly (27-10)
15. Rudder Pedal Assembly (27-20)
SR20_MM27_1679
Figure 27-001
Flight Controls
12137-001
15 Sep 2003 27-00 Page 3