Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Your colleague has built a Layer 2 network in your client locations. You must verify the
configuration and fix any issues identified as per customer requirements.
Customer requirements:
+ Verify if switch ports are assigned correct VLANs as shown in topology. Identify and
fix any misconfiguration found in three switches
+ Verify if trunk links are operational between switches and the IEEE 802.1Q trunk
encapsulation method is used. Identify and fix any misconfiguration found in trunk
configuration
+ Make sure ports connected between switches are set as trunk ports
Step-1
Verify the pre-configuration in all switches with “Show run” and “Show vlan”.
Step-2
On switch 3,
Switch-3#show vlan
Switch 3’s interface E0/0 is not a trunk port and it is now under the Vlan 600 access port.
Switch-3#configure terminal
Step-3
On switch-2,
And also Switch-2’s interface E0/3 must be in vlan 600, not in vlan 500.
Step-4
On switch-1,
Both Switch-1’s interface E0/2 and E0/3 are under the vlan 500, it should be in the correct vlan
Step-5