Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
80
70
60
T /°C
50
40
MEYCO MP 367 Foam
30
20
10
0
0
0
20
40
60
80
0
10
12
14
16
18
20
22
24
36
48
60
time /s
Application procedure
Components A and B are delivered ready-to-use.
They are injected in the proportion of 1:1 by
Packaging volume using a two component injection pump
equipped with a static in-line mixer nozzle, as
MEYCO® MP XP367 Foam is available in the shown below.
following packaging:
Storage
If stored in dry conditions, in unopened, tightly
closed original containers and within a
temperature range of +5ºC and +35ºC, the
components of MEYCO® MP 367 Foam have a
To achieve the best mixing of the components shelf life of 12 months.
during injection, the inclusion of a static in-line Caution: Component A is frost sensitive!
mixer in connection with the mixing head is
essential. The length of the static mixer should be Safety precautions
approximately 100cm for correct mixing.
Refer to the Material Safety Data Sheet for safety
measures.
Cleaning of injection equipment Avoid contact with skin and eyes by using the
For short breaks in injection, pump only required personal protective equipment, such as
Component A through the in-line static mixer overalls, gloves and eye goggles. If contact with
nozzle. After injection and prior to storage of the skin occurs, wash thoroughly using soap and
equipment, pump clean engine or hydraulic oil water. If contact with eyes occurs, rinse
through the pump and both injection lines (Comp thoroughly with an eyebath filled with clean water
A and comp B). and seek medical advice.
If you leave the equipment for less than a week,
you can leave the injection lines with the product: The cured products are harmless.
Be sure to close the end of the lines with the Uncured products should be prevented from
secure caps. entering local drainage system and water courses.
Spillage must be collected using absorbent
materials such as sawdust and sand, and dispose
of in accordance with local regulations.
The information given here is true, represents our best knowledge and is based not only on laboratory work but also on field experience.
However, because of numerous factors affecting results, we offer this information without guarantee and no patent liability is assumed.
For additional information or questions, please contact your local UGC representative.