Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
JOINTS DETAILS
Joints Design Rebuilding / Surfacing
Backing (Yes) (No) X
Backing Material N/A
(Type) Refer to both backing and retainers
Metal Nonfusing Metal
Nonmetal Other
Sketches, Production Drawings, Weld Symbols or Written Description
should show the general arrangement of the parts to be welded. Where
applicable, the root spacing and the details of weld groove may be
specified.
(At the option of the Mfgr. sketches may be attached to illustrate joint
design, weld layers and bead sequence, e.g., for notch toughness produces
for multiple process producers, etc.)
BASE METAL
P-No. N/A Group No. To P-No. - Group No. -
OR
Specification Type and Grade Stainless steels or alloys steels
To Specification Type and Grade N/A
FILLER METALS
Specification No.(SFA) ERNiCrFe-3
ASW No.(Class) 5.11
F-No. N/A
A-No. N/A
Size of Filler Metals Φ 4 mm
Weld Metal
Thickness Range
Groove >3 mm
Fillet N/A
Electrode-Flux (class) N/A
Consumable insert N/A
Trade Name KNCF3
BCCORP. WPS No.: BC-TN01 Sheet 2/3
POSITIONS POSTWELD HEAT TREATMENT
Position(s) of Groove 1G Temp. Range N/A
Welding Progression Up - Down - Time Range N/A
Position(s) of Fillet N/A
Other N/A Heating/Cooling Rate N/A
PREHEAT GAS
Preheat Temp. 100º C- 120º C For SAW Flux Mixture Flow Rate
Interpass Temp. Max 150º C Shielding N/A N/A N/A
Preheat Maintenace N/A Trailing N/A N/A N/A
Backing N/A N/A N/A
(Continuous or special heating where applicable should be record)
ELECTRICAL CHARATERISTICS
Current AC or DC DC Polarity DCEP
Amps (Range) See Table Volts (Range) See Table
(Amps and Volts range should be recorded for each electrode size, position and thickness ect. This
information may be listed in a tabular from to that shown below)
N/A
Tungsten Electrode Size and Type
(Pure Tungsten, 2%Thoriated, etc.)
N/A
Mode of Metal Transfer of GMAW
(Spray Arc, Short Circuiting Arc, etc.)
Electrode Wire Feed Speed Range N/A
TECHNIQUE
String of Weave Bead String
Orifice or Gas cup size N/A
Initical and Interpass Cleaning Brushing, Chipping and Grinding
Method of Backing Gouging NA
Contact Tube to Work Distance NA
Multipte of Single Pass (Per side) Multipte Passes
Multipte or Single electrodes Single
Travel speed range See Table Below
Peening Peening
Other N/A
Notice:
1: Welding consumables must dried according to recommend of manufacturer.
2: During welding interpass temperature not exceed 150oC
3: Redry the electrode at 300~350℃ for 1~2 hours prior to use
`
WELDING PROCEDURE
SPECIFICATION (WPS)
WPS No.BC-TN01