Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
• Sustain pedal fix: Releasing the sustain pedal now stops all notes, including those that still
have a key held
• Note priority has been restored for paraphonic mode, and it also separates note priority
settings for mono & paraphonic (they are now recalled correctly when swapping between
mono & paraphonic)
• MIDI note-on messages with a velocity of zero now stop the appropriate playing note,
no longer resulting in stuck notes
Note : The newly implemented features are detailed in the latest version of the Neutron User
Manual. This can be found HERE.
Update Procedure
This release note describes the public release which includes the following files:
Upgrade Tool
• Computers using Windows OS : Neutron Firmware Updater 2.0.2.exe
• Computers using MAC-OS : Neutron Firmware Updater 2.0.2.app.zip
Update Process
1. Connect the Neutron synth to a power source, but ensure that the unit is switched off.
2. Connect the USB socket on the Neutron synth to a USB 2.0 connection on the computer.
NB: please ensure that there is no MIDI cable connected to the MIDI IN port of the Neutron.
The unit may fail to update is this cable is in place.
3. Run the Update program at which point you should be presented with this screen:
4. With a paperclip (or similar) press & hold the recessed BOOT button on the back panel of the
Neutron (the BOOT button is accessed through a small hole adjacent to the Input jack on the rear
of the unit).
6. Wait for the DFU Updater to detect the Neutron, at which point you should see this message
7. When the DFU Updater has detected the Neutron, click the Update button to start the
update process.
If you instead see a communications error at this point, please refer to point 2 in the
Troubleshooting section at the end of this document on how to install the correct USB
driver before proceeding.
NOTE - PLEASE DO NOT POWER OFF THE UNIT UNTIL THE UPDATE IS COMPLETE.
Troubleshooting
1 – The Neutron is not seen by the updater when I hold down the Boot button and power up
the Neutron.
• Check the USB connection from the computer to the Neutron, and ensure you are plugged
into a USB 2.0 connection on the PC
• Ensure that the Neutron is not connected to the computer via a USB hub
• Ensure the ‘BOOT’ button is correctly held down when powering the unit up and the unit is in
Boot mode
These instructions describe installing (or updating) updating the USB driver on your computer,
and only needs doing once:
• Click “Upgrade Driver” (if the driver is not already installed) or “Reinstall Driver” (if a previous
version of the driver is already installed on the PC) and this will install the version of the
WinUSB driver that the Neutron requires so it is seen as the correct device