Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
COLUMNS
R E I N FORCED CON CR E TE D E S I GN
CE 5 1 2
INTRODUCTION
• When a column bends or deflects laterally an amount ∆, its axial load will
cause an increased column moment equal to P∆.
• If the value of the so-called stability index, Q (which follows) is ≤ 0.05, the
commentary states that the frame may be classified as a nonsway one.
(Should 𝑉𝑢 = 0, this method will not apply.)
𝑃𝑢 ∆𝑜
𝑄=
𝑉𝑢 𝑙𝑐
SLENDERNESS EFFECTS
• The slenderness of columns is based on their geometry and on their lateral
bracing. As their slenderness increases, their bending stresses increase, and
thus buckling may occur.
• if the column is “slender,” the moment for which the column must be
designed is increased or magnified.
SLENDERNESS EFFECTS
• UNSUPPORTED LENGTHS, 𝑙𝑢
- This length is considered to be equal to the clear distance between
slabs, beams, or other members that provide lateral support to the
column. If haunches or capitals are present, the clear distance is
measured from the bottoms of the capitals or haunches.
SLENDERNESS EFFECTS
𝑘 = 2.0 + 0.3ψ
• The ACI Code states that 𝑘 should be taken to be 1.0 for compression
members in frames braced against sidesway unless a theoretical analysis
shows that a lesser value can be used. In the last paragraph of the
commentary, use of the alignment charts or the equations just presented is
said to be satisfactory for justifying 𝑘 values less than 1.0 for braced frames.
𝑘𝑙𝑢
< 22
𝑟
CHRISTOPHER S. PALADIO ASCOT
DESIGN OF SLENDER
COLUMNS
𝐶𝑚
𝛿= ≥ 1.0
𝑃𝑢
1−
0.75𝑃𝑐
𝑀1
𝐶𝑚 = 0.6 + 0.4
𝑀2
CHRISTOPHER S. PALADIO ASCOT
DESIGN OF SLENDER
COLUMNS
𝑀1 = 𝑀1𝑛𝑠 + 𝛿𝑠 𝑀1𝑠
𝑀2 = 𝑀2𝑛𝑠 + 𝛿𝑠 𝑀2𝑠