Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
)
(TIP: Red LED blinking indicates that the device is working with CANBUS communication correctly, but NOT Green LED. Please be informed!)
a. Take out of Climate (Air condition) controller, find corresponding CANBUS connector at rear of it as per Picture.a
b. Disconnect this connector and connect it to Interface CANBUS connector
c. Connect the other end of Interface CANBUS connector to position in Picture.a (Plug&Play)
d. Plug all cables and test the system before routing the wires.
a.
Camera part:
5. Remove the trunk liner
6. Replace the trunk handle to our camera handle (have to remove license plate frame)
7. At the trunk: Connect RCA trunk handle camera cable and DC red wires together.
8. Run Extension Camera Video/Power cable to the glove box.
--
9. Connect Input Wires Connector into our Interface Unit .
10. Connect Purple power wire with red wire from Camera Extension Video/Power cord .
11. Connect RCA video connectors.
12. This step is for Manual transmission only: Connect WHITE Trigger wire(on camera inputs cable) to the reverse signal light (black/white
strip) in the trunk on right side (or left for Australian cars).
--
13. Test it, Enjoy and Drive Safe!
DIP switches set-up instruction:
( Interface support 2 Video inputs, one for Rear view camera as a standard setup, another for front view input optionally. )
SW4 Resolution
OFF 400*240
ON 800*480
Tips:
1. support Front-view input.
2. Front view will be triggered when shift out of Reverse gear, and keep about 10 seconds. Display return to original car menu after that.
3. On Camera Inputs Harness, you will only use Purple wire with ‘POWER to CAM 12V’ .
3’. White wire with ‘Reverse TRIG in’ is for Manual Transmission, and need connect it to Reverse light.
3’’. Other wires with ‘ACC +12V//POWER GND//Constant 12V’ is Power output for External video source, like DVR input. DON’T connect Power 12V to ‘ACC
+12V//Constant 12V’ in case of damaging interface unit.