Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
5i-M-R
Model: ATD4516R8
Antenna Specifications
General Electrical Properties
Frequency range (MHz) 3300 - 3800
Polarization +45° , -45°
Electrical downtilt (°) 2 - 12,continuously adjustable
General
Electrical downtilt tolerance (°) ±1
parameters
Max. power per input (W) 25 (at 50℃ ambient temperature)*
Impedance (Ω) 50
Grounding DC Ground
Coupling factor between calibration port and each
-26 ±2
antenna port (dB)
Max. amplitude tolerance from calibration port to
0.9
input ports (dB)
Calibration and
electrical Max. phase tolerance from calibration port to input
7
parameters ports (°)
Ports VSWR 1.5
Co-polarization isolation between ports (dB) ≥ 20
Cross-polarization isolation between ports (dB) ≥ 25
Notes:
65° broadcast beams and multi-beams are applicable in different scenarios. Select one of them for network coverage based on
site requirements and auxiliary equipment conditions.
1
DX-3300-3800-75-15.5i-M-R
Model: ATD4516R8
5G NR Electrical Properties
Frequency range (MHz) 3300 - 3800
Gain (dBi) 15.5
Horizontal 3dB beam width (°) 78
Front to back ratio (dB) ≥ 23
Single column beam
Cross polar ratio (0°) (dB) ≥ 18
Vertical 3dB beam width (°) 5.5
Side lobe suppression for first side lobe above main beam (dB) ≥ 15
Gain (dBi) 20.7
Radiation
parameters NR Broadcast beam Horizontal 3dB beam width (°) 65
(PBCH/PSCH/SSCH with Front to back ratio (dB) ≥ 25
HUAWEI gNodeB) Vertical 3dB beam width (°) 5.5
Side lobe suppression for first side lobe above main
≥ 15
beam (dB)
0°direct beam gain (dBi) 21
0°direction beam horizontal 3dB beam width (°) 26
NR Service beam
0°direction beam front to back ratio (dB) ≥ 28
0°direction beam cross polar ratio (0°) (dB) ≥ 22
Notes:
1. The 5G NR broadcast beam is the envelope of SSB(synchronization signal block) sweeping beams and the gain is the
maximum gain of SSB sweeping beams.
2. Downlink broadcast beam gain values and pattern files can only be used for broadcast channel coverage prediction.
3. Downlink and uplink budgets need to be calculated based on the gain of single column beam and the correct Tx/Rx number.
(281)
Packing dimensions (H x W x D) (mm) 1290 x 340 x 205
Antenna weight (kg) 13.0
Clamps weight (kg) 2.9 (2 units)
Antenna packing weight (kg) 20.0 (Included clamps)
Mast diameter supported (mm) 50 - 115 1100
770
Accessories
2
DX-3300-3800-75-15.5i-M-R
Model: ATD4516R8
Service 0° 5G NR Broadcast
3
DX-3300-3800-75-15.5i-M-R
Model: ATD4516R8
RAE Properties
RAE type Integrated RAE, manages antenna information
RAE protocols AISG-ES-RAE V2.1.0
EasyBeam Properties
Frequency range (MHz) 3300 - 3800
Electrical downtilt (°) 2 - 12
Horizontal 3dB beam width (°) 30 65 90
Broadcast
Electrical azimuth (°) -15..+15 0
beam
Electrical azimuth step(°) 1 /
Standards: EN/IEC 60950-1(Safety), EN/IEC 60950-22(Safety – Equipment installed outdoor),EN 55032 (Emission),
EN/IEC 62368-1(Safety),ETSI EN 301 489, FCC Part15, ICES-003
Certification: CE, FCC, IC, RCM, RoHS, REACH, WEEE
y - Yellow
NOTE
1. Facilities, such as towers and poles, must bear the weight and wind load of antennas.
2. HUAWEI ‘s standard brackets and accessories must be used for any installation.
3. The antenna working environment must meet the requirements specified in the datasheet.
4. Only qualified personnel are allowed to perform installation. Installation tools and procedures must conform to
requirements described in the antenna installation guide.
Huawei Technologies Co., Ltd. Bantian, Longgang District, Shenzhen 518129, P.R.China www.huawei.com/antenna
Any previous datasheet issues become invalid. 4 Issue: 2019-12-31