Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2 Pages
PASSED AS/NZS 4858:2004
Membrane
Fast curing
UL 790 CLASS A FIRE RATING
Compatible with Metz and RLA tile adhesives CAN/ULC – S102.2 – M88 CLASS A RATING
High strength and puncture resistant
Wet Material Properties
Vertical and horizontal applications
VOC 205g/L
Easy to apply Viscosity, cps Brookfield HBT 8-10,000
Resistant to range of chemicals and pollutants Cure Time ASTM D-1640 48 hours max
@25°C-50% RH
Flash point Setaflash 45°C
TECHNICAL SERVICE
METHOD OF APPLICATION
TREMCO has a team of qualified Technical Sales
Mix the Vulkem Non-Exposed Membrane to ensure no
Representatives who provide assistance in the
settlement of the material is in the bottom of the pail
selection and specification of products. For more
and the colour of the material is consistent with no
detailed information or service and advice, call
streaks or striations
Customer Service on (02) 9638 2755 or fax (02) 9638
All internal wet areas should be waterproofed to meet
2955.
AS 3740-2004 requirements
Apply one coat of Vulkem Non-exposed Membrane at
specified coverage rates using either brush, roller or
squeegee GUARANTEE/WARRANTY
Ensure the membrane is turned down into the floor TREMCO products are manufactured to rigid
waste or well sealed around the leak control flange and standards of quality. Any product which has been
other penetrations. Ensure flashing angles are properly applied (a) in accordance with TREMCO written
sealed across doorways. Check for pin holes in the instructions and (b) in any application recommended
membrane when dry and rectify. by TREMCO, but which is proved to be defective,
A light broadcast of sand into the Vulkem Non-Exposed will be replaced free of charge.
Membrane, while still wet will ensure good bond with tile
adhesive
Any information provided by TREMCO in this
document in relation to TREMCO’s goods or their
COVERAGE use is given in good faith and is believed by
Approximately 1.2L/m2 at a dry film thickness of 1mm TREMCO to be appropriate and reliable. However,
(approximately 16m2 per 18.9L pail to achieve the the information is provided as a guide only, as the
waterproof requirements as stated in AS 3740-2004. actual use and application will vary with application
Approximately 0.6L/m2 at a dry film thickness of 0.5mm conditions which are beyond our control. TREMCO
(approximately 32m2 per 18.9L pail) to achieve water makes no representation, guarantee or warranty
resistant requirements as stated in AS 3740-2004 relating to the accuracy or reliability of the
(vertical applications) information and assumes no obligation or liability in
connection with the information. To the extent
permitted by law, all warranties, expressed or
CLEAN UP
implied are excluded.
Thoroughly clean tools with Tremco IPA Cleaner before
handling. Clean hands with Tremco Tub O’ Towels or
soapy water.