Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. Connect the circuit required in the trainer kit. Keep all toggle
switches in SSB mode.
2. Set modulating frequency above 2 KHz in audio range and
amplitude. Observe and measure the modulating signal on CRO.
3. Observe output of balanced modulator stage 2 ( It shld be a SSB
signal ). Measure Vp-p.
4. Connect output of ST 2201 to input of ST2202.
5. Tune the circuit such that you get the modulated signal at the output
of the RF amplifier.
6. Observe the IF amplifiers output at stage 1 and 2.
7. Switch on the BFO and Observe the demodulated output after the
product detector.
Observation Observations of DSB Tx and Rx.
table Vm= fm=
Vc= fc=
Output at diff. Vmax Vmin
stages
Transmitter
output
RF amplifier
output
IFA 1 output
IFA 2 output
Demodulated
output
Receiver side
RFA output Vp-p
Observations
1. What was the range of the tuner dial at which the group got
satisfactory output of RF amplifier?
a. For DSB reception
b. For SSB reception
2. Did the grp get the DSBSC signal from the Balanced modulator stage
1 directly? Or did ull have to make changes in the circuit?
4. How many faults did your group introduce? What were the findings?
Fault Number Faulty circuit and explain what was the
observation
5. How many points did your group get in the fault finding?
Conclusion