Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
IC--2410A
IC-2410E
IC-2410H
lcom Inc.
INTRODUCTION DANGER
This service manual describes the latest service informa- NEVER connect the transceiver to an AC outlet or
tion for the IC-2410A/E/H DUAL BAND FM TRANSCEIVER to a DC power supply that uses more than 16 V. This
at the time of publicat ion. will ruin the transceiver.
Be sure to include the following four points when 1. Make su re a problem is internal before disassembling
ordering replacement parts: the transceiver.
2. DO NOT open the transceiver until the transceiver
1. 10-digit order numbers is disconnected from the power source.
2. Component part number and name 3. DO NOT force any of the variable components. Turn
3. Equipment model name and unit name them slowly and smooth ly.
4. Quantity required 4. DO NOT short any circuits or elec tronic pa rts.
An insulated tu ning tool MUST be used for all
< SAMPLE ORDER > adjustments.
5. DO NOT keep power ON for a long time when the
1110002200 IC MC3372MA IC-2410NE/H MAIN-AUNIT Spieces transceiver is defect ive.
8810006230 Screw FH M2.6x 4 ZK IC-2410AJE/H Topoover 10_pieces
6. DO NOT transmit power into a signal generator
or a sweep generator .
Addresses are provided on the inside back cover for your
7 ALWAYS connect a 40 dB-50 dB attenuator between
convenience.
• the transceiver and a deviation meter or spectru m
analyzer when using such test equipment.
8. READ the instructions of test equipment thoroughly
before connecting equipment to the transceiver.
TABLE OF CONTENTS
SECTION 1 SPECIFICATIONS . . . . . . . . . . . . . . . . . .. . . . . . . . . . . .. . . . . . . . .. . . . . . . . . . . . . . . . . 1- 1
a GENERAL
• Frequency coverage VERSION VHF UHF
140.000-150.000* 1 (Tx)
U.S.A. 440.000-450.000
136.000-174.000*1 (Rx)
Italy 136.000-174.000*1 400.000-479.000*2
Europe 144.000-146.000 430.000-440.000
Australia 144.000-148.000 430.000-440.000
140.000-150.000*' (Tx)
Asia 430.000-440.000
136.000-174.000*1 (Rx)
Unit: MHz
*1 Specifications guaranteed for 144.000-148.000 MHz.
*2 Specifications guaranteed for 430.000-440.000 MHz.
• Tuning step increments 5, 10, 12.5, 15, 20, 25 kHz, 1 MHz or 10 MHz
• Number of memory channels VHF UHF
Memory channels 15 15
Call channels 1 1
Scan edge channels 2 2
•Mode FM (F3)
• Antenna impedance 50 0 nominal
• Power supply requirement 13.8 V DC±15 % (negative ground)
• Usable temperature range -10·c-+60°c (+14°F-+140°F)
• Dimensions 140 (W) x 40 (H) x 174.5 (D) mm
5.5 (W) x 1.6 (H) x 6.9 (D) in
(projections not included)
• Weight 1.35 kg (3.0 lb)
a TRANSMITTER
• Modulation system Variable reactance frequency modulation
• Max. frequency deviation ±5 kHz
• Spurious emissions Less than - 60 dB
• Microphone impedance 6000
• Output power and current drain IC-2410A/E IC-2410H
(at 13.8 V DC)
POWER CURRENT POWER CURRENT
High 25W 7.0A 45W 10.5 A
VHF Low2 10W 4.5 A 10W 5.5 A
Low 1 1W 2.5A 5W 4.0A
High 25W 8.0A 35W 10.5 A
UHF Low2 10W 5.0A 10W 6.0A
Low 1 1W 3.0A 5W 4.5A
a RECEIVER
• Receive system Double-conversion superheterodyne
• Intermediate frequencies 1st 17 .2 MHz (VHF)
30.875 MHz (UHF)
2nd 455 kHz
• Sensitivity Less than 0.16 µV for 12 dB SINAD
• Squelch threshold sensitivity Less than 0.13 µV
• Selectivity More,than 15 kHz/-6 dB
Less than 30 kHz/-60 dB
• Spurious rejection ratio More than 60 dB
• Audio output power More than 2.4 W at 1o % distortion with an 8 0 load
• Current drain Max. audio output 1.8 A Squelched 1.2 A
• Audio output impedance 4-80
1-1
SECTION 2 INSIDE VIEWS
• MAIN-A UNIT
Discriminator - -- - - - --'-
(X1 : C0BM455C16)
• MAIN-B UNIT
2-1
SECTION 3 CIRCUIT DESCRIPTION
Received VHF signals enter the antenna connector on the D14-D17 employ varactor diodes that track the band-
MAIN-B UNIT and pass through a low-pass filter (C60, C64, pass filters and resonator circuits and are controlled by
C65, L11-L13) on the MAIN-A UNIT. When receiving, the VHF PLL lock voltage. The voltage is current-amplified
the antenna switching circuit (D9, D21, D22) turns OFF. at the DC amplifier circuit (04, 05) and is then applied
The signals pass through a rt-type low-pass filter (C117, to the varactor diodes. These varactor diodes tune the
C118, C120, L21, L22). The filtered signals are applied center frequency of an RF passband for wide bandwidth
to the VHF RF circuit. The low-pass filter suppresses receiving and good image response rejection.
high harmonic components.
On the other hand, entered signals from J1 on the MAIN-B
UNIT amplified at RF amplifier (037) and then applied
3·1·2 VHF RF CIRCUIT to the VHF 1st mixer (036).
(MAIN-A AND MAIN·B UNITS)
The RF circuit amplifies signals within the range of
3·1·3 VHF 1st MIXER CIRCUIT
frequency coverage and filters out-of-band signals.
(MAIN·A UNIT)
The signals from the VHF antenna switching circuit pass The 1st mixer circuit converts the received signal to a
through a RF switching diode (D19). When receiving one fixed frequency of the 1st IF signal with a PLL output
VHF frequency, 8 V from 033 turn ON one side of D19. frequency. By changing a PLL frequency, only the
The VHF signals pass through a tuned bandpass filter desired frequency will be passed through a pair of crystal
(L20, C109, C110, C112, D17) and are applied to the RF filters at the next stage of the 1st mixer.
amplifier (021).
The signals from the VHF RF circuit are mixed at 019
with a 1st LO signal coming from the VHF VCO circuit to
produce a 17.2 MHz 1st IF signal.
• VHF RECEIVER BLOCK DIAGRAM
ANT SW LPF
9 DETV line
D
X2
16.745MHz
Fig.1
3-1
3-1-4 VHF 1st IF CIRCUIT (MAIN-A UNIT) The filtered signal is adjusted with the [V VOL] control
(R23) on the LOGIC UNIT and is then amplified in the
The VHF 1st IF signal is applied to a matching circuit
AF amplifier (IC7) on the MAIN-A UNIT to obtain the
(L 16, C93, C94). When receiving two UHF frequencies
speaker driving level.
simultaneously, the UHF RF signals mixed at 034 with a
1st LO signal coming from the VHF VCO circuit. The
An AF mute transistor (01 5) cuts the input signals of
resulting 1st IF signal is applied to a pair of crystal filters
the AF amplifier when the transceiver is transmitting or
(Fl2) in order to obtain wide selection capability and to
the squelch is closed.
pass only the desired signals. The 1st IF signal passes
through a matching circuit (L 15, C88) and is then ampli-
fied at an IF amplifier (014). The amplified signal is 3-1-7 VHF SQUELCH CIRCUIT
applied to a demodulator circuit. (MAIN-A, AF AND LOGIC UNITS)
The limiter diode (D11) protects the following circuits A squelch circuit cuts out AF signals when no RF signal
from strong signals. is received. By detecting noise components in the AF
signals, the squelch circuit switches the AF mute
switches.
3-1-5 VHF 2nd IF AND DEMODULATOR
CIRCUITS (MAIN-A UNIT) Some noise components in the AF signal from IC4 (pin 9)
are applied to an active filter section (IC4, pin 10) via
The 2nd mixer circuit converts the 1st IF signal to a
a de-emphasis circuit (R68, C73-C75). This circuit is
2nd IF signal. A double superheterodyne system (which an integrated circuit with frequency characteristics of
converts receive signals twice) improves the image
-6 dB/octave. The binary output from the CPU (IC3,
rejection ratio and obtains stable receiver gain.
pins 27 and 28) on the LOGIC UNIT supplies the squelch
level volume control signal. This control signal is con-
The 1st IF signal from 014 is applied to a 2nd mixer
trolled by 020 and 021 on the AF UNIT. The squelch
section of IC4 and is mixed with a 2nd LO signal for level setting volume control (R130) on the MAIN-A UNIT
conversion to a 455 kHz 2nd IF signal.
adjusts the IC4 (pin 10) input level.
IC4 contains the 2nd mixer, local oscillator circuit, limiter The active filter section amplifies noise components of
amplifier, quadrature detector circuit and active filter frequencies of 20 kHz and above, and outputs the result-
circuit. The local oscillator section and X2 generate ing signals from pin 11. Output signals are rectified by
16.745 MHz for the 2nd LO signal. D12 and are then converted to DC voltage.
The 2nd IF signal from the 2nd mixer (IC4, pin 3) passes The rectified noise voltage triggers the squelch switch
through a high-quality ceramic filter (Fl1) to suppress (015). The collector of 015 outputs the squelch signal.
unwanted heterodyned frequency signals. It is then The signal is applied to IC3 (pin 18) on the LOGIC UNIT
amplified at the limiter amplifier section (IC4, pin 5) and through the "SOLSV" signal line.
applied to the quadrature detector section (IC4, pin 5 and
ceramic discriminator X1) to demodulate the 2nd IF
signal into an AF signal.
• VHF SQUELCH CIRCUIT
IC3 µPC358G2
The signal is output from IC4 (pin 9) as a "DETV" signal
and then is applied to the AF UNIT.
~....161----1st IF
signal
3-2
3-1-8 UHF ANTENNA SWITCHING CIRCUIT 3-1-10 UHF 1st MIXER CIRCUIT
(MAIN-B UNln (MAIN-B UNln
Received UHF signals enter the antenna connector and The signals from the UHF RF circuit are mixed at 019
pass through a high-pass filter (C86-C88, L14, L15). with a 1st LO signal coming from the UHF VCO circuit
When receiving, the antenna switching circuit (09, 018, to produce a 30.850 MHz 1st IF signal.
019) turns OFF. The signals pass through a n-type low-
pass filter (C82-85, C147, C148, C150, L12, L13, L25,
L26). The filtered signals are applied to the UHF RF 3-1-11 UHF 1st IF CIRCUIT (MAIN-B UNln
circuit. The UHF 1st IF signal is applied to a matching circuit
(L 18, C124). When receiving two VHF frequencies
simultaneously, the VHF RF signals are mixed at 036
3·1·9 UHF RF CIRCUIT
with a 1st LO signal coming from the UHF VCO circuit.
(MAIN-A AND MAIN·B UNITS)
The resulting 1st IF signal is applied to a pair of crystal
The signals from the UHF antenna switching circuit pass filters (Fl2) in order to obtain wide selection capability
through an RF switching diode (016). When receiving and to pass only the desired signals. The 1st IF signal
one UHF frequency, 8 V from 034 turns ON one side of passes through a matching circuit (L 17, C120) and is
016. The UHF signals pass through a tuned bandpass then amplified at an IF amplifier (016). The amplified
filter (L24, C139, C140) and are then applied to the RF signal is applied to a demodulator circuit.
amplifier (021). When receiving two UHF frequencies
simultaneously, 8 V from 033 turns ON the other side of The limiter diode (012) protects the following circuits
016. The UHF signals are amplified at 022, and then from strong signals.
to the RF amplifier (021) and MAIN-A UNIT through
J1 respectively. Amplified signals are applied to the
bandpass filter (L22) and are then amplified at 020. The 3-1-12 UHF 2nd IF AND DEMODULATOR
amplified signals pass through the bandpass filter (L21) CIRCUITS (MAIN-B UNIT)
and are then applied to the UHF 1st mixer (019). The 1st IF signal from 016 is applied to a 2nd mixer section
of IC4 and is mixed with a 2nd LO signal for conversion
The coils in the bandpass filters (L21, L22) employ a to a 455 kHz 2nd IF signal.
double tuned helical coil. They have good bandpass
characteristics and eliminate signals outside of the IC4 contains the 2nd mixer, local oscillator circuit, limiter
range. amplifier, quadrature detector circuit and active filter
circuit. The local oscillator section and X3 generate
On the other hand, entered signals from J1 on the MAIN-A 30.395 MHz for the 2nd LO signal.
UNIT amplified at RF amplifier (IC6) and are applied to
the UHF 1st mixer (034).
RF SW RF SW RF SW ANT SW
1st MIX
019 1st MIX
UHF RF signal
from
IC4 MAIN-A UNIT
16
113.150 -115.150MHz !EUR)
105.150-143.150MHz ITA,USA,SEA)
9 DETU signal 113.150"" 117.150MHz AUS)
,-.----- -----
MAIN·A UNIT
0
X3
30.395MHz
LOGIC
I UNIT
Fig. 3
3-3
The 2nd IF signal from the 2nd mixer (IC4, pin 3) passes The binary output from the CPU (IC3, pins 29 and 30)
through a high-quality ceramic filter (Fl 1) to suppress on the LOGIC UNIT supplies the squelch level volume
unwanted heterodyned frequency signals. It is then control signal. This control signal is controlled by 022
amplified at the limiter amplifier section (IC4, pin 5) and and 023 on the AF UNIT. The squelch level setting
applied to the quadrature detector section (IC4, pin 5 and volume control (R132) on the MAIN-B UNIT adjusts the
ceramic discriminator X2) to demodulate the 2nd IF IC4 (pin 10) input level.
signal into an AF signal.
The active filter section amplifies noise components of
The signal is output from IC4 (pin 9) as a "DETU" signal frequencies of 20 kHz and above, and outputs the result·
and then is applied to the AF UNIT. ing signals from pin 11. Output signals are rectified by
011 and are then converted to DC voltage.
3·1-13 UHF AF CIRCUIT (MAIN·B, AF, LOGIC The rectified noise voltage triggers the squelch switch
AND MAIN-A UNITS) (017). The collector of 017 outputs the squelch signal.
The "DETU" signal from IC4 (pin 9) is applied to the IC The signal is applied to IC3 (pin 19) on the LOGIC UNIT
switch (IC2) on the AF UNIT. IC3 controls the input through the "SOLSU" signal line.
level of IC2.
"LOOA" I BUFFER
signal I AMP
02,03
MIC
A·V MOO signal
LPF AFSEL from
vco MUTE I LOGIC
I ; IC1 I IC1b IC1a 06 UNIT
I A·U I I LOOP FIL
I
I to I vco '
signal
from
AF UNIT
PT6'/ VCO·A UNIT I I PLL·A UNIT L. - - - - - - - -MA1N-AuN1T
- - - - - - - - ..... - -
I PLL·AUNIT L--------' MOOU line
L------------J to
MAIN·B UNIT
SUFFER
AMP IC2
BUFFER
AMP
to
~--UHF APC
1st CIRCUIT
MIX
07
Flg.4
3-4
3·2·2 VHF MODULATION CIRCUIT When the antenna impedance is mismatched, the voltage
of IC3b (pin 6) exceeds the reference voltage of IC3b
(VCO·A UNln
(pin 5). The output level from IC3b (pin 7) decreases.
The modulation circuit modulates the VCO oscillating 012 amplifies the current from the APC amplifier (IC3b)
signal (RF signal} using the microphone audio signals. which controls 011. 011 changes the supply voltage
to QB and IC2.
The audio signals from the AF UNIT (MODV signal)
pass through the IC switch (IC1} and are then applied to This decreases the output power from the drive amplifier
the varactor diodes (D1 -D4) to modulate the oscillated (08) and power amplifier (IC2) until the input voltage of
signals in the VHF VCO circuit. The VHF VCO circuit IC3b (pin 6) reaches the same level as pin 5 of IC3b.
contains both the V-UHF VCO oscillator (01} and the
V-VHF VCO oscillator (04}. The oscillated signals are
mixed together and then buffer-amplified at 03. The 3-2·6 VHF OUTPUT POWER CONTROL
amplified signals are applied to 05 on the PLL-A UNIT CIRCUIT (MAIN-A UNln
through the "VCOOA" signal line. The resulting signals
are output from the "LOOA" signal line and are then The output power control circuit (09, 010, R30-R32, R37,
applied to the drive amplifier circuit. R39) selects 1 of 3 output power levels (HIGH, LOW-2 or
LOW-1) and controls the output voltage from the APC
circuit by the APC reference voltage.
3·2·3 VHF DRIVE AMPLIFIER CIRCUIT
(MAIN-A UNln When "HIGH" output power is selected, 09 and 010 are
turned OFF. The APC reference voltage is determined
The VCO output is buffer-amplified at 06 and is then by R30-R32 and is adjusted with R31.
applied to a low-pass filter (C21, C22, C25, C28, L2, L5}.
When "LOW-2" output power is selected, 010 is turned
After passing through the transmit/receive switching ON. The reference voltage is decreased by R39 con-
circuit (D4), the VCO output is amplified at the drive nected to 010.
amplifier (08} to obtain 200 mW (IC-2410H: 400 mW).
When "LOW-1" output power is selected, 09 is turned
The control voltage from the APC circuit is applied to the ON. The reference voltage is decreased by R37 con-
collector of 08 for stable RF output power from a power nected to 09.
amplifier (IC2}.
011
The RF signal from the drive amplifier (08} is applied to ....<Da:
IC2 (pin 4). The amplified signal is output from IC2 (pin 1} "'
.... +
and is then applied to the antenna connector through u
the antenna switching diode (D9) and low-pass filter
circuit (C60, C64, C65, L11-L 13).
00
('")
a:
3·2·5 VHF APC CIRCUIT (MAIN-A UNln
This circuit controls current in the power module's first
stage and current in the driver amplifier to obtain stable <D
Fig. 5
3-5
3-2·7 VHF ANTENNA SWITCHING CIRCUIT 3-2·9 UHF DRIVE AMPLIFIER CIRCUIT
(MAIN-A UNln (MAIN-B UNln
When transmitting, D9, D21 and D22 are turned ON. The The VCO output is buffer-amplified at 08 and is then
RF output signal from IC2 is not permitted to enter the applied to a low-pass filter (C37-C39, L2).
receiver circuit. The signal passes through L9, C55, D9
and a low-pass filter (C60, C64, C65, L11-L 13) and is After passing through the transmit/receive switching
then output from an antenna connector. The low-pass circuit (D4), the VCO output is amplified at the pre-drive
filter suppresses high harmonic components. amplifier (010). The amplified signal is re-amplified at
the drive amplifier (011) to obtain 320 mW (IC-2410H:
500 mW).
3-2·8 UHF MODULATION CIRCUIT
(VCO-B UNln The control voltage from the APC circuit is applied to
The audio signals from the AF UNIT (MODU signal) the collector of 011 for stable RF output power from a
pass through the IC switch (IC1) and are then applied to power amplifier (IC2).
the varactor diodes (D1-D4) to modulate the oscillated
signals in the UHF VCO circuit. The UHF VCO circuit
3-2-10 UHF POWER AMPLIFIER CIRCUIT
contains both the U-UHF VCO oscillator (01) and the
U-VHF VCO oscillator (04). The oscillated signals are
(MAIN-B UNln
mixed together and then buffer-amplified at 03. The IC2 is a power module which provides a stable 25 W
amplified signals are applied to 05 on the PLL-8 UNIT (IC-2410H: 35 W) of output power.
through the "VCOOB" signal line. The resulting signals
are output from the "LOOB" signal line and are then The RF signal from the drive amplifier (011) is applied to
applied to the drive amplifier circuit. IC2 (pin 1). The amplified signal is output from IC2 (pin 5)
and is then applied to the antenna connector through
the antenna switching diode (D9) and bandpass filter
circuit (C83-C88, L12-L 15).
IC2
APC
CIRCUIT
to
LPF VHF 1st MIX
Fig. 6
3-6
3·2·11 UHF APC CIRCUIT (MAIN·B UNIT) 3·2·13 UHF ANTENNA SWITCHING CIRCUIT
The APC mismatch detector circuit consists of C72, C75, (MAIN·B UNIT)
D7, D8, L10, R53, R54, R60 and R61. When the antenna When transmitting, D9, D18 and 019 are turned ON. The
impedance is matched at 50 n, the detected voltage by RF output signal from IC2 is not permitted to enter the
D7 and D8 is at its minimum. The detected voltage is receiver circuit. The signal passes through L10, C78, 09
applied to an APC amplifier (IC3b, pin 6) and an RF meter and a bandpass filter (C83- C88, L12-L15) and is then
amplifier (IC3a, pin 3). The RF meter amplifier outputs output from an antenna connector.
RF meter voltage. The APC reference voltage is applied
to pin 5 of IC3b.
----
HIGH
LOW2 {LP0·2)
LOW1 ( LP0·1)
012
OFF
OFF
ON
Q13
OFF
ON
OFF
Fig. 7
3-7
3.3.4 VHF PROGRAMMABLE DIVIDER AND 3.3.5 VHF LOOP FILTER AND
PHASE DETECTOR CIRCUITS DC-DC-CONVERTER CIRCUITS
(PLL-A UNln (PLL·A AND MAIN-A UNITS)
The programmable divider shifts the dividing ratio with a Phase-detected signal (pulse signal) from IC1 (pin 12) is
prescaler depending on the operating frequency and converted to DC voltage (PLL lock voltage) by a loop filter
determines the VCO oscillating frequency. consisting of an active filter (01, 02).
The phase detector circuit detects the off-phase com- The VHF VCO oscillation on the VCO-A UNIT is controlled
ponents of the VCO frequency using a stable reference by varactor diodes (D1-D4). DC voltage (PLL lock
frequency. voltage) is provided through the integrator circuit (C4,
R5) and is then applied to a DC amplifier circuit (04, 05).
The output signal from the VCO-A UNIT enters either PLL The voltage is used as the tuning voltage for the receiver
IC (IC1, pin 5) or a buffer amplifier (05) on the PLL-A UNIT. bandpass filters.
IC1 is a one-chip PLL IC that contains a two-modulus 30 V DC from the DC-DC converter circuit (IC8, 040, 041)
prescaler, a pulse counter, a programmable divider and a on the MAIN-B UNIT is applied to the loop filter. The
phase detector. voltage is used to obtain a wide range of lock voltage
for the PLL circuit.
The input signal from the PLL IC (IC1, pin 5) passes through
the two-modulus prescaler and the programmable divider
sections of IC1. A 12.8 MHz reference frequency from 3·3·6 VHF UNLOCK SENSOR CIRCUIT
X1 on the MAIN-B UNIT is applied to IC1 (pin 15) and (PLL·A AND LOGIC UNITS)
passes through a reference programmable divider section When the PLL circuit is unlocked, IC1 (pin 13) becomes
of IC1. Both of the divided signals are compared at a "HIGH". The "HIGH" signal is applied to the CPU (IC3,
phase detector section of IC1. The phase-detected pin 20) as an unlock signal on the LOGIC UNIT.
signal (pulse signal) is output from IC1 (pin 12).
"LODA"
line
5
STBPLV 1-3
DATA CK 6,12
from LOOP FIL
LOGIC
UNIT IC2
IC1
15 7 Q1,Q2,
PLL
Q3,Q6
r·---- --,
I BUFFER Q3
VCO CTRL I AMP
Q4
~~ ...
I RVCOA
r-·------.J line
LVA
I line
r----''-----,
I A·V VCO
---------- ------,
PLL·A UNIT I
I
TVCOA
line
Q4, Q5
MODVA
line
BUFFER ------+-------from
AMP I MAIN-A
UNIT
to
> - - + - - PLL·B UNIT I (IC1)
(IC1)
I A·UVCO
Q1,Q2
X1
I
12.8MHz I VCO·A UNIT
MAIN·B UNIT
I
Fig. 8
3-8
3.3.7 UHF VCO CIRCUIT (VCO·B UNln 3.3.9 UHF LOOP FILTER AND
The UHF VCO circuit contains both U-UHF and U-VHF DC-DC-CONVERTER CIRCUITS
VCO circuits to obtain a 120 MHz-420 MHz oscillation (PLL·B AND MAIN·B UNITS)
for the UHF PLL circuit. This circuit is newly designed Phase-detected signals (pulse signals} from IC1 (pin 12)
to receive two frequencies in the same band. are converted to DC voltage (PLL lock voltage) by a loop
filter consisting of an active filter (01, 02).
The U-UHF VCO circuit employs a Colpitts oscillator circuit
(01). The output signal from the U-UHF VCO circuit is The UHF VCO oscillation on the VCO-B UNIT is controlled
mixed with the U-VHF VCO oscillation via C10 and R9. by varactor diodes (D1-D4). DC voltage (PLL lock
voltage) is provided through the integrator circuit (C4, RS)
The U-VHF VCO circuit employs a Hartley oscillator circuit and is then applied to a DC amplifier circuit (06, 07). The
(04). The output signal from the U-VHF VCO circuit is voltage is used as the tuning voltage for the receiver
mixed with the U-UHF VCO oscillation via C22 and R19. bandpass filters.
Varactor diodes (D1-D4) provide frequency control. The 30 V DC from the DC-DC converter circuit (IC8, 040, 041)
buffer amplifier (03) amplifies VCO oscillation and does is applied to a 24 V regulator (D 1) to obtain a stable
not permit the latter circuit to affect the VCO oscillation. 24 V DC. The voltage is used at the loop filter to obtain
a wide range of lock voltage for the PLL circuit.
Pin 7 of IC1 on the PLL-B UNIT controls 04 to activate
either the U-VHF or the U-UHF VCO circuit.
3·3·10 UHF UNLOCK SENSOR CIRCUIT
3·3·8 UHF PROGRAMMABLE DIVIDER AND (PLL·B AND LOGIC UNITS)
PHASE DETECTOR CIRCUITS When the PLL circuit is unlocked, IC1 (pin 13) becomes
(PLL·B UNln "HIGH". The "HIGH" signal is applied to the CPU (IC3,
pin 21} as an unlock signal on the LOGIC UNIT.
The programmable divider shifts the dividing ratio with a
prescaler depending on the operating frequency and
determines the VCO oscillating frequency. • UHF PLL·B UNIT BLOCK DIAGRAM
The output signal from the VCO-B UNIT enters either PLL 15 9,16 IC1
+8VB
DATA 5 line
PRESCALER VCOOB
line
CK
2
3
STBPLU RVCOB line
LOOP
FIL TVCOB line
CIRCUIT
Fig. 9
3-9
3.4 OTHER CIRCUITS When the [POWER] switch is turned ON, the RESET port of
the CPU (IC3, pin 43) becomes "HIGH". When the port
receives "HIGH", the CPU restarts operation. The time
3-4-1 VHF S/RF INDICATOR CIRCUIT
constant (C14, R27, R28) provides sufficient reset time.
(MAIN-A AND LOGIC UNITS)
The RF meter voltage from IC3a (pin 1) is rectified at an When the 5 V line becomes lower than the threshold
S/RF meter detector (D24). The detected voltage is voltage of IC2, the INT1 port of the CPU (IC3, pin 17)
output as the "SRFV" signal. The signal is applied to an becomes "LOW", and the CPU enters the backup
S/RF comparator (IC4b, pin 5) on the LOGIC UNIT. condition.
Fig.11
3-10
3.4.5 REGULATOR CIRCUIT (MAIN·B UNIT) PORT PIN TERMINAL
DESCRIPTION
No. No. NAME
IC9 is a 3-terminal voltage regulator IC chip. + 13.8 V is
R01 1 LCK Outputs clock signals for LCD.
applied to the input terminal. The output terminal out-
R02- 2-4 INI SO- Output strobe signals for the
puts a regulated + 9 V ( + 8 V line) to each unit. R03, INI 82 initial matrix.
R10
038, 039 and D29 produce a regulated 8 V ( +8 V R11- 5-7 SRF 01- Output counting signals for the
line) for the MAIN-A UNIT. This regulator is composed R13 SRF 03 S/RF INDICATOR.
of a complementary connection to ensure high current R20- a- KEY 10- Input ports for the key and initial
amplification and supplies stable output voltage con- R23 11 KEY13 matrix.
tinuously with good temperature characteristics. R30 14 DIAL UP Input port for the up signal of the
TUNING CONTROL.
R31 15 DIAL DN Input port for the down signal of
IC7 is a 3-terminal voltage regulator IC chip. + 13.8 V is
the TUNING CONTROL.
applied to the input terminal. The output terminal out-
R32 16 INTO/ Input port for the up/down clock
puts a regulated +5.5 V (5 V line) using D28. signal of the TUNING CONTROL.
DIAL CK
R33 17 INT1/ Input port for the signal of
01 produces a regulated 24 V for the UHF loop filter BACKUP memory backup.
circuit. This voltage is converted from 30 V DC which is R40- 27- V SQL1- Output control signals for VHF
produced by the DC-DC converter (IC8, 040, 041). R41 28 VSQL2 squelch level setting.
R42- 29- U SQL1- Output control signals for UHF
R43 30 U SQL2 squelch level setting.
3.5 CPU PORT ALLOCATIONS R50 18 SOLS V Detects a VHF squelch signal.
When the signal is "HIGH", the
(LOGIC UNIT) VHF squelch opens.
R51 19 SOLS U Detects a UHF squelch signal.
• IC3 CPU When the signal is "HIGH", the
UHF squelch opens.
PORT PIN TERMINAL
DESCRIPTION R52 20 UNLKV Detects a VHF PLL unlock
No. No. NAME
signal. When the signal is
DO 48 T SQLV Detects a VHF tone squelch
"HIGH", the VHF PLL is
signal. When the signal is
unlocked. Normally, this port is
"HIGH", an optional tone
"LOW"
squelch opens.
R53 21 UNLK U Detects a UHF PLL unlock
01 49 T SQLU Detects a UHF tone squelch
signal. When the signal is
signal. When the signal is
"HIGH", the UHF PLL is
"HIGH", an optional tone
unlocked. Normally, this port is
squelch opens.
"LOW".
D2 50 UNIT.T Becomes "LOW" when an
R60 22 CK Outputs a clock signal for the
optional UT-67 TONE SQUELCH
serial data (DATA).
UNIT is connected.
R61 23 DATA Outputs serial data.
D3 51 STBVC Outputs a strobe signal for VHF
R62- 24- DIMO- For setting the LCD dimmer.
control.
R63 25 DIM1 Level 3 is the brightest.
D4 52 8TB UC Outputs a strobe signal for UHF
control. Level 0 1 I2 3
D5 53 STBAC Outputs a strobe signal for DIMO L H j L H
common control.
06 54 8TB PLV Outputs a strobe signal for VHF
DIM1 L L I H H
PLL data on the MAIN-A UNIT. R70 31 STBTV Outputs a strobe signal for an
D7 55 8TB PLU Outputs a strobe signal for UHF optional UT-67 TONE SQUELCH
PLL data on the MAIN-B UNIT. UNIT control on the VHF band.
DB 56 MICCK Input port for the microphone R71 32 8TB TU Outputs a strobe signal for an
clock. optional UT-67 TONE SQUELCH
UNIT control on the UHF band.
09 57 MIC U/D Input port for the microphone
up/down signal. R72 33 8TB OT Outputs a strobe signal for an
optional UT-55 DTMF
010 58 PTT Inputs a signal on the PTT line.
ENCODER/ DECODER UNIT
This port becomes "HIGH"
control.
when the PTT switch is pushed.
R73 34 STBSP Outputs a strobe signal for an
011 59 BEEP Outputs a signal for beep tone.
optional UT-66 VOICE
D12 60 STONE Outputs a signal for 88.5 Hz
SYNTHESIZER UNIT control.
tone.
R81 36 UNIT. S Becomes "LOW" when an
D13 61 LINH Outputs a control signal for LCD optional UT-66 VOICE
on the DISPLAY UNIT.
SYNTHESIZER UNIT is
D14 62 LCE1 Outputs a signal for LCD driver connected.
(IC1) on the DISPLAY UNIT. Becomes "LOW" when an
R82 37 UNIT. T
D15 63 LCE2 Outputs a signal for LCD driver optional UT-55 DTMF
(IC2) on the DISPLAY UNIT. ENCODER/ DECODER UNIT is
ROO 64 LDATA Outputs serial data for LCD. connected.
3-11
PORT PIN TERMINAL • IC6 SHIFT REGISTER (MAIN-B UNIT)
DESCRIPTION
No. No. NAME PORT PIN TERMINAL
A83 38 STD Becomes "HIGH" while DTMF is DESCRIPTION
No. No. NAME
decoding.
01 4 UTX Becomes "HIGH" while
R90- 39- DO- DTMF decode data (4 bits). transmitting on the UHF band.
A93 42 D3
02 5 U1RX Becomes "HIGH" while
RAO 12 V SAFI Inputs a resulting signal from the receiving on the VHF band.
S/RF meter comparator on the
03 6 U3RX Becomes "HIGH" while
VHF band.
receiving on the UHF band.
RA1 13 U SAFI Inputs a resulting signal from the
06- 13, ULP1- For setting UHF RF output
S/RF meter comparator on the
07 12 ULP2 power.
UHF band.
RESET 43 RESET When a "HIGH" signal is applied Power High Low 1 Low2
INPUT to this port, either the CPU is ULP1 L H. L
initialized or changes to stand-by
ULP2 L L H
mode.
OSC1 45 Input port for the oscillator of the
CPU clock.
OSC2 46 Output port for the oscillator of
the CPU clock.
GND 47 Ground
vcc 26 Input port for the power source • IC3 SHIFT REGISTER (AF UNIT)
of the CPU.
PORT PIN TERMINAL
DESCRIPTION
No. No. NAME
01 4 VA MUTE Becomes "HIGH" when the AF
amplifier input is muted on the
VHF band.
02 5 UA MUTE Becomes "HIGH" when the AF
• ICS SHIFT REGISTER (MAIN-A UNIT) amplifier input is muted on the
PORT PIN TERMINAL UHF band.
DESCRIPTION
No. No. NAME 03 6 VD MUTE Becomes "HIGH" when the
01 4 VTX Becomes "HIGH" while "DETV" signal is completely
transmitting on the VHF band. muted.
03 6 V1RX Becomes "HIGH" while 04 7 UD MUTE Becomes "HIGH" when the
receiving on the VHF band. "DETU" signal is completely
muted.
Q4 7 V3RX Becomes "HIGH" while
receiving on the UHF band. 06 13 MMUTE Becomes "HIGH" when the
microphone amplifier input is
05- 14, VLP1- For setting VHF RF output
VLP2 muted.
06 13 power.
08 11 V MAIN Becomes "HIGH" when the VHF
Power High Low 1 Low2 is main band.
VLP1 L H L
VLP2 L L H
3-12
SECTION 4 MECHANICAL PARTS AND DISASSEMBLY
8210006380 Front panel (C} IC-2410H ® 2230000800 Switch SW-112 (SPPH24) [POWER] 1
® 8810000980 Screw PH BO M2 x 4 5
@ 6450000140
Connector HSJ0807·01-010
1
<i} 8830000550 VA nut (E) 2 [430 (440) MHz SP]
@
@
@
6510000290
8930020690
8930021060
Connector 8S-S-E [MICROPHONE]
969 LCD holder
Mask seal (black}
1
1
1
@)
~
@
2710000340
8930021020
8820000650
Fan motor MMF-04A12DM·ROA
Finger guard FG·40A
970 screw
tt
4
Screw abbreviations BO : Self-tapping screw PH: Pan head FH: Flat head BS: Brass NI: Nickel
ZK: Black OH: Oval countersunk head
4-1
I i
I
\
® ®
./ ® LOGIC UNIT
AF UNIT
4-2
4·2 MAIN-8 UNIT
LABEL QTY.
ORDER NO. DESCRIPTION
NUMBER
CD 8810003160 Setscrew A M3 x 6 12
® 8810001910 Screw PH M3 x 6 NI BS 4
@) 6950000040 M type cap (ZK) 1
(j]) 8900002450 Cable OPC-223 [ANTENNA CONNECTOR] 1
@ 8900002700 Cable OPC-249 [DC 13.8 VJ 1
@) 8810001910 Screw PH M3 x 6 NI BS 4
Screw abbreviations PH: Pan head FH: Flat head BS: Brass NI: Nickel ZK: Black
4.3 ACCESSORIES
0 LABEL ORDER
DESCRIPTION QTY.
0 NUMBER NO.
0
0
©g
0
CD Optional product DC power cable OPC-044B 1
0 Microphone HM-56
0
0 IC-2410A/H (USA, SEA)
0
0 Microphone HM-58
0
0
0
® Optional product
IC-241 OA/H (AUS)
1
0
Microphone HM-59
0 IC-2410E/H (EUR, ITA)
@ 8010005180 Mounting bracket (B) ZK 1
® 8810000950 Screw PH A MS x 16 4
(j) 8810000470 Screw PH MS x 12 (+ -) 4
® 8830000120 Nut MS 4
4-3
~G)
I ®
r®
@)
4-4
SECTION 5 PARTS LIST
5-1
[LOGIC UNIT] [DISPLAY UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
R83 7030003840 Resistor ERJ3GEYJ 473 V (47 kQ) IC1 1130004190 IC LC7582A
R84 7030003840 Resistor ERJ3GEYJ 473 V (47 k Q) IC2 1130004190 IC LC7582A
R85 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ)
R86 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ}
R87 7030003520 Resistor ERJ3GEYJ 472 V {4.7kQ) R1 7030003850 Resistor ERJ3GEYJ 583 V (58 k Q)
R88 7030003510 Resistor ERJ3GEYJ 392 V (3.9 k Q) R2 7030003850 Resistor ERJ3GEYJ 583 V (58 kQ)
R89 7030003760 Resistor ERJ3GEYJ 474 V (470 kQ) R3 7030003580 Resistor ERJ3GEYJ 103 V (10 k Q)
R90 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q ) R4 7030003580 Resistor ERJ3GEYJ 103 V (10 k Q)
R91 7030003550 Resistor ERJ3GEYJ -S22 V (8.2 k Q ) R5 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q)
R6 7030003580 Resistor ERJ3GEYJ 103 V (10 k Q)
R7 7030003580 Resistor ERJ3GEYJ 103 V (10 k Q)
C1 4030006860 Ceramic C1808 JB 1H 102K-T-A
C2 4030008860 Ceramic C1608 JB 1H 102K-T-A
C3 4030006860 Ceramic C1608 JB 1H 102K-T-A C1 4030008830 Ceramic C1808 SL 1H 331J-T-A
C4 4030006860 Ceramic C1608 JB 1H 102K-T-A C2 4030006830 Ceramic C1808 SL 1H 331J-T-A
C5 4030006860 Ceramic C1608 JB 1H 102K-T-A
C8 4030006860 Ceramic C1608 JB 1H 102K-T-A
C7 4030006860 Ceramic C1608 JB 1H 102K-T-A OS1 5030000760 LCD FTD-10038AGH
cs 4030008630 Ceramic C1608 JF 1C 1042-T-A [FUNCTION DISPLAY] (black)
C9 4030008630 Ceramic C1608 JF 1C 1042-T-A 5030000770 LCD FTD-10789AAH
C10 4030008630 Ceramic C1808 JF 1C 1042-T-A (FUNCTION DISPLAY] (orange)
C11 4030008830 Ceramic C1608 JF tC 1042-T-A
C12 4030008830 Ceramic C1808 JF 1C 1042-T-A
C13 4030008830 Ceramic C1808 JF 1C 104Z-T-A EP2 8930021100 LCD contact strip SRCN-989-W
C14 4030008630 Ceramic C1808 JF 1C 1042-T-A EP1 0910029981 P.C. Board B 3028A (DISPLAY)
C15 4030008630 Ceramic C1808 JF 1C 104Z-T-A
C18 4030008630 Ceramic C1608 JF 1C 1042-T-A
C17 4030008630 Ceramic C1808 JF 1C 1042-T-A
C18 4030008630 Ceramic C1608 JF 1C 104Z-T-A
C19 4510004540 Electrolytic ECEVOJA470P
5-2
[AF UNIT] [AF UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
R7 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) R79 7030003800 Resistor ERJ3GEYJ 223 V (22 k Q )
(USA,USA-H) R80 7030003830 Resistor ERJ3GEYJ 393 V (39 k Q )
7030003470 Resistor ERJ3GEYJ 182 V (1.8 k Q) R81 7030003760 Resistor ERJ3GEYJ 474 V (470 kQ)
(EUR,ITA,AUS,SEA,EUR-H, R82 7030003480 Resistor ERJ3GEYJ 222 V (2.2 kQ)
ITA·H,AUS-H,SEA·H) R83 7030003380 Resistor ERJ3GEYJ 331 V (330 Q)
RB 7030003450 Resistor ERJ3GEYJ 122 V (1.2 k Q) R84 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q )
(USA,USA·H) R85 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q)
7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) R88 7030003640 Resistor ERJ3GEYJ 473 V (47kQ)
(EUR,ITA,AUS,SEA,EUR-H, R87 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q )
ITA-H,AUS·H,SEA-H) R88 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q)
R9 7030003570 Resistor ERJ3GEYJ 123 V (12 k Q) R89 7030003500 Resistor ERJ3GEYJ 332 V (3.3 k Q)
RlO 7030003880 Resistor ERJ3GEYJ 104 V (100 k Q) R90 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q)
All 7030003840 Resistor ERJ3GEYJ 225 V (2.2 M Q) R91 7030003440 Resistor ERJ3GEYJ 102 V (1 kQ)
R12 7030003840 Resistor ERJ3GEYJ 225 V (2.2 M Q ) R92 7030003500 Resistor ERJ3GEYJ 332 V (3.3 kQ)
R13 7030003880 Resistor ERJ3GEYJ 104 V (100 k Q) R93 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q )
R14 7030003880 Resistor ERJ3GEYJ 104 V (100 k Q) R94 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q )
R15 4810001370 Trimmer EVML1GAOOB24 20KB R95 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q)
R18 7030003880 Resistor ERJ3GEYJ 104 V (100 k Q) R98 7030003640 Resistor ERJ3GEYJ 473 V (47 k Q )
R17 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) R97 7030003640 Resistor ERJ3GEYJ 473 V (47 k Q )
R18 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) R98 7030003640 Resistor ERJ3GEYJ 473 V (47kQ)
R19 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) R99 7030003640 Resistor ERJ3GEYJ 473 V (47 k Q )
R20 7030003650 Resistor ERJ3GEYJ 563 V (58 k Q ) R100 7030003620 Resistor ERJ3GEYJ 333 V (33 k Q )
R21 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) R101 7030003560 Resistor ERJ3GEYJ 103 V (10 kQ)
R22 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q ) R102 7030003550 Resistor ERJ3GEYJ 822 V {8.2 k Q)
R23 7030003420 Resistor ERJ3GEYJ 681 V (680 Q ) R103 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q )
R24 7030003280 Resistor ERJ3GEYJ 470 V (47 Q) R104 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q)
R25 7030003390 Resistor ERJ3GEYJ 391 V (390 Q) R105 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q )
R26 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) R106 7030003760 Resistor ERJ3GEYJ 474 V (470 kQ)
R27 7030003740 Resistor ERJ3GEYJ 334 V (330 k Q ) R107 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q)
R28 7030003750 Resistor ERJ3GEYJ 394 V (390 k Q ) R108 7030003760 Resistor ERJ3GEYJ 474 V (470 kQ)
R29 7030003790 Resistor ERJ3GEYJ 824 V (820 k Q) R109 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q)
R30 7030003710 Resistor ERJ3GEYJ 184 V (180 k Q) R110 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q)
R31 7030003550 Resistor ERJ3GEYJ 822 V (8.2 k Q)
R32 7030003570 Resistor ERJ3GEYJ 123 V (12 kQ)
R33 7030003720 Resistor ERJ3GEYJ 224 V (220 k Q ) Cl 4510001370 Electrolytic 18 MS5 47 µF
R34 7030003670 Resistor ERJ3GEYJ 823 V (82 k Q ) C2 4030008630 Ceramic C1606 JF 1C 104Z-T-A
R35 7030003670 Resistor ERJ3GEYJ 823 V (82 k Q) C3 4030008630 Ceramic C1608 JF lC 104Z-T-A
R36 7030003870 Resistor ERJ3GEYJ 823 V (82 k Q ) C4 4030008630 Ceramic C1608 JF lC 104Z-T-A
R39 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q) C5 4030008680 Ceramic C2012 JF 1C 1052-T-A
R40 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q ) C6 4030008680 Ceramic C2012 JF lC 1052-T-A
R41 7030003840 Resistor ERJ3GEYJ 225 V (2.2 M Q ) C7 4030008630 Ceramic C1808 JF lC 104Z-T-A
R42 7030003660 Resistor ERJ3GEYJ 683 V (68 k Q ) CB 4030005090 Ceramic C2012 JB 1H 223K-T-A
R43 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C9 4030005110 Ceramic C2012 JB 1E 473K-T-A
R44 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C10 4030005110 Ceramic C2012 JB 1E 473K-T-A
R45 7030003880 Resistor ERJ3GEYJ 104 V (100 k Q) C11 4030006870 Ceramic C1608 JB 1H 222K-T-A
R46 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C12 4030008630 Ceramic C1608 JF 1C 1042-T-A
R47 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C13 4030008630 Ceramic C1608 JF 1C 104Z-T-A
R48 7030003450 Resistor ERJ3GEYJ 122 V (1.2 k Q ) C14 4030008630 Ceramic C1608 JF lC 104Z-T-A
R49 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q) C15 4510001350 Electrolytic 16 MS5 10 µF
R50 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q) C16 4030008630 Ceramic C1608 JF lC 104Z-T-A
R51 7030003600 Resistor ERJ3GEYJ 223 V {22 k Q ) C17 4030008660 Ceramic C2012 JB 1H 333K-T-A
R52 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C18 4510001470 Electrolytic 50 MS5 1 µF
R53 7030003630 Resistor ERJ3GEYJ 393 V (39 k Q ) C19 4030007020 Ceramic C1808 CH 1H 120J-T-A
R54 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) C20 4030008680 Ceramic C2012 JF 1C 105Z-T-A
R55 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C21 4030008690 Ceramic C2012 SL 1H 821J-T-A
R56 7030003740 Resistor ERJ3GEYJ 334 V (330 k Q ) C22 4030008830 Ceramic C1608 JF 1C 104Z-T-A
R57 7030003280 Resistor ERJ3GEYJ 470 V (47 Q) C23 4030008650 Ceramic C1608 JB 1H 332K-T-A
R58 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q) C24 4030006740 Ceramic C1608 SL 1H 820J-T-A
R59 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q) C25 4030006750 Ceramic C1608 SL 1H 101J-T-A
R60 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q ) C28 4510001370 Electrolytic 18MS547µF
R61 7030003380 Resistor ERJ3GEYJ 331 V (330 Q ) C27 4030008630 Ceramic C1608 JF 1C 104Z-T-A
R82 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q) C28 4550000320 Tantalum DN 1V OR1M
R63 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q ) C29 4030008630 Ceramic C1608 JF 1C 1042-T-A
R64 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q) C30 4030008630 Ceramic C1608 JF 1C 104Z-T-A
R65 7030003640 Resistor ERJ3GEYJ 473 V {47 k Q) C31 4030008680 Ceramic C2012 JF 1C 1052-T-A
R66 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q ) C32 4030006900 Ceramic C1608 JB IE 103K-T-A
R67 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q) C33 4030006900 Ceramic C1608 JB 1E 103K-T-A
R68 7030003620 Resistor ERJ3GEYJ 333 V (33 k Q) C34 4030006470 Ceramic C2012 JB 1H 153K-T-A
R69 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q) C35 4030008630 Ceramic C1608 JF 1C 1042-T-A
R70 7030003620 Resistor ERJ3GEYJ 333 V (33 k Q ) C36 4030008660 Ceramic C2012 JB 1H 333K-T-A
R71 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q) C37 4030008630 Ceramic C1608 JF 1C 1042-T-A
R72 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C38 4030006470 Ceramic C2012 JB 1H 153K-T-A
R73 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) C39 4030008630 Ceramic C1608 JF 1C 104Z-T-A
R74 7030003740 Resistor ERJ3GEYJ 334 V (330 k Q ) C40 4030008670 Ceramic C2012 JB 1H 562K-T-A
R75 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q ) C41 4030008670 Ceramic C2012 JB 1H 562K-T-A
R76 7030003280 Resistor ERJ3GEYJ 470 V {47 Q) C42 4030008630 Ceramic C1608 JF 1C 104Z-T-A
R77 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q) C43 4030008680 Ceramic C2012 JF lC 1052-T-A
R78 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q) C44 4550000270 Tantalum TESVA lE 474M1-8L
5-3
[AF UNIT] [MAIN-A UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
C45 4550000270 Tantalum TESVA 1E 474M1-8L 012 1530000160 Transistor 2SC2712-Y (TE85RTEM)
C46 4030008630 Ceramic C1608 JF 1C 104Z-T-A 013 1590000380 FET 2SJ106- Y (TE85R)
C47 4030008630 Ceramic C1608 JF 1C 104Z-T-A 014 1530002030 Transistor 2SC3772-3-TA
C48 4030006900 Ceramic C1608 JB 1E 103K-T-A 015 1530000160 Transistor 2SC2712-Y (TE85RTEM)
C49 4030006900 Ceramic C1608 JB 1E 103K-T-A 016 1530001950 Transistor 2SC2712-GR (TE85R)
cso 4030006470 Ceramic C2012 JB 1H 153K-T-A 017 1530001950 Transistor 2SC2712-GR (TE85R)
C51 4030008660 Ceramic C2012 JB 1H 333K-T-A 018 1590000830 Transistor FMG2 T149
C52 4030006470 Ceramic C2012 JB 1H 153K-T-A 019 1580000350 FET 3SK140-Y (TE85R)
C53 4030008630 Ceramic C1608 JF 1C 104Z-T-A 020 1590000420 Transistor RN1404 (TE85R)
C54 4030008670 Ceramic C2012 JB 1H 562K-T-A 021 1580000360 FET 3SK177-T2B U73
C55 4030008670 Ceramic C2012 JB 1H 562K-T-A 022 1530002030 Transistor 2SC3772-3-TA
C56 4030008630 Ceramic C1608 JF 1C 104Z-T-A 023 1580000380 FET 3SK177 - T2B U73
C57 4030008680 Ceramic C2012 JF 1C 105Z-T-A 024 1590000690 Transistor IMD6 T108
C58 4030006850 Ceramic C1608 JB 1H 471K-T-A 025 1590000460 Transistor RN1402 (TE85R)
C59 4030006850 Ceramic C1608 JB 1H 471K-T-A 026 1590000460 Transistor RN1402 (TE85R)
C60 4030006850 Ceramic C1608 JB 1H 471K-T-A 027 1590000460 Transistor RN1402 (TE85R)
C61 4030006850 Ceramic C1608 JS 1H 471K-T-A 028 1590000460 Transistor RN1402 (TE85R)
C62 4550000270 Tantalum TESVA 1E 474M1-8L 029 1590001000 Transistor RN2427 (TE85R}
C63 4030008630 Ceramic C1608 JF 1C 104Z-T-A Q30 1590001000 Transistor RN2427 (TE85R)
C64 4030008630 Ceramic C1608 JF 1C 104Z-T-A 031 1590001000 Transistor RN2427 (TE85R)
C65 4030008680 Ceramic C2012 JF 1C 105Z-T-A 032 1590001000 Transistor RN2427 (TE85R)
C66 4030008680 Ceramic C2012 JF 1C 105Z-T-A 033 1590000460 Transistor RN1402 (TE85R)
C67 4030008680 Ceramic C2012 JF 1C 105Z-T-A 034 1580000350 FET 3SK140-Y (TE85R)
C68 4030008680 Ceramic C2012 JF 1C 105Z-T-A 035 1590000420 Transistor RN1404 (TE85R)
C69 4550002950 Tantalum TESVA OJ 335M1-8L 036 1530000160 Transistor 2SC2712-Y (TE85RTEM)
037 1520000200 Transistor 2SB796- T2 DK
5-4
[MAIN-A UNIT] [MAIN-A UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
5-5
[MAIN-A UNIT] [MAIN-A UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
R122 7030003580 Resistor ERJ3GEYJ 103 V (10 kQ) C58 4510001350 Electrolytic 18 MS5 10 µF
R124 7030003280 Resistor ERJ3GEYJ 470 V (47 Q) C57 4030008880 Ceramic C1808 JB 1H 102K-T-A
R125 7030003230 Resistor ERJ3GEYJ 180 V (18 Q) C58 4030008880 Ceramic C1808 JB 1H 102K-T-A
R128 7030003880 Resistor ERJ3GEYJ 104 V (100 kQ) C59 4010004120 Ceramic 0007 B 102K 500V
R127 7030003800 Resistor ERJ3GEYJ 223 V (22 k Q ) C8o 4010003890 Ceramic 0008 SL 180K 500V
R128 7030003580 Resistor ERJ3GEYJ 103 V (10 kQ) C81 4030008880 Ceramic C1808 JB 1H 102K-T-A
R130 4810001230 Trimmer EVMLGGA00814 (103) C82 4030008880 Ceramic C1808 JB 1H 102K-T-A
R131 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C83 4030008880 Ceramic C1808 JB 1H 102K-T-A
R132 7030003480 Resistor ERJ3GEYJ 222 V (2.2 kQ) C84 4010003930 Ceramic 0008 SL 270K 500V
R133 7030003370 Resistor ERJ3GEYJ 271 V (270 Q) C85 4010003930 Ceramic 0008 SL 270K 500V
R134 7030003880 Resistor ERJ3GEYJ 104 V (100 kQ) C88 4030008880 Ceramic C1808 JB 1H 102K-T-A
R135 7030000220 Resistor MCR10EZHJ 47 Q (470) C87 4030008830 Ceramic C1808 JF 1C 1042-T-A
R138 7030003320 Rtisistor ERJ3GEYJ 101 V (100 Q) Cea 4030008830 Ceramic C1808 JF 1C 1042-T-A
R137 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C89 4030008780 Ceramic C1808 SL 1H 121J-T-A
R138 7030003790 Resistor ERJ3GEYJ 824 V (820 k Q ) C70 4030008710 Ceramic C1808 SL 1H 470J-T-A
R139 7030003570 Resistor ERJ3GEYJ 123 V (12 k Q) C71 4030008880 Ceramic C1808 SL 1H 220J-T-A
R140 7030000100 Resistor MCR10EZHJ 4.7 Q (4R7) C72 4030008830 Ceramic C1808 JF 1C 1042-T-A
R141 7030003880 Resistor ERJ3GEYJ 104 V (100 kQ) C73 4030008880 Ceramic C1808 JB 1H 102K-T-A
R142 7030003440 Resistor ERJ3GEYJ 102 V (1 kQ) C74 4030008880 Ceramic C1808 JB 1H 102K-T-A
R143 7030000100 Resistor MCR10EZHJ 4.7 Q (4R7) C75 4030008880 Ceramic C1808 JB 1H 102K-T-A
R144 7030003280 Resistor ERJ3GEYJ 470 V (47 Q ) C76 4030008830 Ceramic C1808 JF 1C 1042-T-A
R145 7030003480 Resistor ERJ3GEYJ 222 V (2.2 kQ) C77 4030008880 Ceramic C1808 JB 1H 102K-T-A
R148 7030000220 Resistor MCR10EZHJ 47 Q (470) C78 4510002840 Electrolytic 25SS4711F
R147 7510000450 Thermistor DTN-T203C471 LS (T) C79 4030008880 Ceramic C1808 JB 1H 102K-T-A
cao 4030008890 Ceramic C1808 JF 1H 1032-T-A
C81 4030008890 Ceramic C1808 SL 1H 330J-T-A
C1 4550002950 Tantalum TESVA OJ 335M1-8L C82 4030008880 Ceramic C1808 JB 1H 102K-T-A
C3 4030008880 Ceramic C1808 JB 1H 102K-T-A C83 4030008880 Ceramic C1808 JB 1H 102K-T-A
C5 4030008880 Ceramic C2012 JF 1C 1052-T-A C84 4030008900 Ceramic C1808 JB 1E 103K-T-A
Ce 4510003150 Electrolytic 35SS33µF C85 4030008900 Ceramic C1808 JB 1E 103K-T-A
C7 4030008880 Ceramic C1808 JB 1H 102K-T-A C88 4510002930 Electrolytic 50 SS R47 µF
ca 4030008880 Ceramic C1808 JB 1H 102K-T-A C87 4030008880 Ceramic C1808 SL 1H 220J-T-A
C9 4030008880 Ceramic C1808 JB 1H 102K-T-A C88 4030008730 Ceramic C1808 SL 1H 880J-T-A
C11 4510002840 Electrolytic 25 SS 47 11F C89 4030008830 Ceramic C1808 JF 1C 1042-T-A
C12 4030008880 Ceramic C1808 JB 1H 102K-T-A C90 4030008540 Ceramic C1808 SL 1H 030C-T-A
C13 4030008880 Ceramic C1808 JB 1H 102K-T-A C91 4030008880 Ceramic C1808 JB 1H 102K-T-A
C14 4030008880 Ceramic C1808 JB 1H 102K-T-A C92 4030008900 Ceramic C1808 JB 1E 103K-T-A
C15 4030008880 Ceramic C1808 JB 1H 102K-T-A C93 4030008730 Ceramic C1808 SL 1H 880J-T-A
C18 4030008850 Ceramic C1808 JB 1H 471K-T-A C94 4030008740 Ceramic C1808 SL 1H 820J-T-A
C17 4030008880 Ceramic C1808 SL 1H 220J-T-A C95 4030008900 Ceramic C1808 JB 1E 103K-T-A
C18 4030008850 Ceramic C1808 JB 1H 471K-T-A C98 4030008880 Ceramic C1808 JB 1H 102K-T-A
C19 4030008880 Ceramic C1808 JB 1H 102K-T-A C97 4030008570 Ceramic C1808 SL 1H 0800-T-A
C20 4030008880 Ceramic C1808 JB 1H 102K-T-A C98 4030008830 Ceramic C1808 SL 1H 150J-T-A
C21 4030008570 Ceramic C1808 SL 1H 0800-T-A C100 4030008510 Ceramic C1808 SL 1H OR5C-T-A
C22 4030008810 Ceramic C1808 SL 1H 1000-T-A C101 4030008810 Ceramic C1808 SL 1H 1000-T-A
C23 4030008440 Ceramic C1808 SL 1H 1R5C-T-A C102 4030008520 Ceramic C1808 SL 1H 010C-T-A
C24 4030008540 Ceramic C1808 SL 1H 030C-T-A C103 4030008510 Ceramic C1808 SL 1H OR5C-T-A
C25 4030008880 Ceramic C1808 SL 1H 220J-T-A C104 4030008800 Ceramic C1808 SL 1H 0900-T-A
C28 4030008880 Ceramic C1808 JB 1H 102K-T~A C105 4030008510 Ceramic C1808 SL 1H OR5C-T-A
C27 4030008510 Ceramic C1808 SL 1H OR5C-T-A C108 4030008880 Ceramic C1808 JB 1H 102K-T-A
C28 4030008810 Ceramic C1808 SL 1H 1000-T-A C107 4030008880 Ceramic C1808 JB 1H 102K-T-A
C29 4030008580 Ceramic C1808 SL 1H 0700-T-A C108 4030008880 Ceramic C1808 JB 1H 102K-T-A
C30 4030008880 Ceramic C1808 JB 1H 102K-T-A C109 4030008750 Ceramic C1808 SL 1H 101J-T-A
C31 4030008880 Ceramic C1808 SL 1H 220J-T-A C110 4030008870 Ceramic C1808 SL 1H 270J-T-A
C32 4030008880 Ceramic C1808 JB 1H 102K-T-A C112 4030008590 Ceramic C1808 SL 1H 0800-T-A
C33 4030008880 Ceramic C1808 JB 1H 102K-T-A C113 4030008880 Ceramic C1808 JB 1H 102K-T-A
C34 4030008880 Ceramic C1808 JB 1H 102K-T-A C114 4030008880 Ceramic C1808 JB 1H 102K-T-A
C35 4030008880 Ceramic C1808 JB 1H 102K-T-A C115 4030008880 Ceramic C1808 JB 1H 102K-T-A
C38 4030008880 Ceramic C1808 SL 1H 220J-T-A C118 4030008880 Ceramic C1808 JB 1H 102K-T-A
C37 4030008880 Ceramic C1808 SL 1H 220J-T-A C117 4030008880 Ceramic C1808 SL 1H 220J-T-A
(EUR,ITA,USA,AUS,SEA) C118 4030008700 Ceramic C1808 SL 1H 390J-T-A
C38 4030008810 Ceramic C1808 SL 1H 1000-T-A C119 4030008880 Ceramic C1808 JB 1H 102K-T-A
C39 4030008880 Ceramic C1808 JB 1H 102K-T-A C120 4010003890 Ceramic 0008 SL 180K 500V
C40 4030008880 Ceramic C1808 SL 1H 220J-T-A C121 4030008850 Ceramic C1808 JB 1H 471K-T-A
C41 4030008880 Ceramic C1808 JB 1H 102K-T-A C122 4030008820 Ceramic C1808 SL 1H 120J-T-A
C42 4550000280 Tantalum ON 1V 100M C123 4030008880 Ceramic C1808 JB 1H 102K-T-A
C43 4030008880 Ceramic C1808 JB 1H 102K-T-A C124 4030008880 Ceramic C1808 JB 1H 102K-T-A
C45 4030008880 Ceramic C1808 JB 1H 102K-T-A C125 4030008820 Ceramic C1808 SL 1H 120J-T-A
C48 4030008880 Ceramic C1808 JB 1H 102K-T-A C128 4030008880 Ceramic C1808 JB 1H 102K-T-A
C47 4030008880 Ceramic C1808 JB 1H 102K-T-A C127 4030008890 Ceramic C1808 SL 1H 330J-T-A
C48 4030008880 Ceramic C1808 JB 1H 102K-T-A C128 4030008840 Ceramic C1808 SL 1H 180J-T-A
C49 4010003880 Ceramic 0008 SL 150K 500V C129 4030008880 Ceramic C1808 JB 1H 102K-T-A
C50 4030008880 Ceramic C1808 JB 1H 102K-T-A C130 4030008880 Ceramic C1808 JB 1H 102K-T-A
C51 4030008880 Ceramic C1808 JB 1H 102K-T-A C131 4030008820 Ceramic C1808 SL 1H 120J-T-A
C52 4030008880 Ceramic C1808 JB 1H 102K-T-A C132 4030008880 Ceramic C1808 JB 1H 102K-T-A
C53 4010003880 Ceramic 0008 SL 150K 500V C133 4030008880 Ceramic C1808 JB 1H 102K-T-A
C54 4030008880 Ceramic C1808 JB 1H 102K-T-A C134 4030008880 Ceramic C1808 JB 1H 102K-T-A
C55 4010004110 Ceramic D005 B 471K 500V C135 4030008880 Ceramic C1808 JB 1H 102K-T-A
5-6
[MAIN-A UNIT] [PLL-A UNIT)
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
5-7
[VCO-A UNIT] [MAIN-B UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
Ql 1580000850 FET 2SK1577-2-T7 IC1 1130004200 IC TC4S88F (TE85R)
02 1590001280 Transistor RN1408 (TE85R) IC2 1150000180 IC SC1027
03 1530002240 Transistor 2SC3775-3-TA (EUR.ITA,
04 1580000840 FET 2SK1740-TA USA.AUS.SEA)
05 1590001280 Transistor RN1408 (TE85R) 1150000750 IC SC1054
(EUR·H.ITA·H.
USA-H,AUS-H,SEA-H)
D1 1720000220 Varicap 1SV188-T2B IC3 1110001240 IC 11 PC358G2- T1
D2 1720000220 Varicap 1SV188-T2B IC4 1110002200 IC MC3372MR
03 1720000220 Varicap 1SV188-T2B IC5 1110001971 IC 11 PC1676G-T1
04 1720000220 Varicap 1SV188-T2B IC6 1130005810 IC BU4094BF-T1
IC7 1110002020 IC TA7805S
IC8 1110001700 IC Tl499ACPS
ll 8200001580 Coil LER 015T R88M IC9 1110000490 IC AN6541
l2 8200001580 Coil LER 015T R88M
l3 8130002430 Coil LB-271
l4 8200001570 Coil LER 015T 1ROM Ql 1510000580 Transistor 2SA1362-GR (TE85R)
l5 8200001570 Coil LER 015T 1ROM 02 1530000160 Transistor 2SC2712-Y (TE85RTEM)
l8 8200001580 Coil LER 015T 1R8M 03 1530000160 Transistor 2SC2712-Y (TE85RTEM)
l7 8200001580 Coil LER 015T 1R8M 04 1530002360 Transistor 2SC2714 - Y (TE85R)
LB 8200001580 Coil LER 015T 1R8M 05 1530002050 Transistor 2SC3661-TA
l9 8130002420 Coil LB-270 as 1580000360 FET 2SK209-Y (TE85R)
l10 8200001230 Coil MLF2012A 1ROM-T 07 1510000110 Transistor 2SA 1162- Y (TE85R)
as 1530002240 Transistor 2SC3775-3-TA
09 1530002030 Transistor 2SC3772-3-TA
R1 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) 010 1530002240 Transistor 2SC3775-3-TA
R3 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) 011 1590000390 Transistor MRF559
R5 7030003280 Resistor ERJ3GEYJ 470 V (47 Q) 012 1590000420 Transistor RN1404 (TE85R)
R7 7030003310 Resistor ERJ3GEYJ 820 V (82 Q) 013 1590000420 Transistor RN1404 (TE85R)
R9 7030003400 Resistor ERJ3GEYJ 471 V (470 Q) 014 1520000380 Transistor 2$81143 S
R10 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q ) 015 1530000160 Transistor 2SC2712 - Y (TE85RTEM)
R11 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) 016 1530002020 Transistor 2SC3770-3-TA
R12 7030003400 Resistor ERJ3GEYJ 471 V (470 Q) 017 1530000160 Transistor 2SC2712 - Y (TE85RTEM)
R13 7030003400 Resistor ERJ3GEYJ 471 V (470 Q) 018 1590000420 Transistor RN1404 (TE85R)
R14 7030003870 Resistor ERJ3GEYJ 823 V (82 k Q ) 019 1580000350 FET 3SK140- Y (TE85R)
R15 7030003280 Resistor ERJ3GEYJ 470 V (47 Q) 020 1530002240 Transistor 2SC3775-3-TA
R16 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) 021 1580000360 FET 3SK177-T2B U73
R17 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q ) 022 1580000360 FET 3SK177-T2B U73
R18 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) 023 1590000690 Transistor IMD6 T108
R19 7030003400 Resistor ERJ3GEYJ 471 V (470 Q) 024 1590000460 Transistor RN1402 (TE85R)
025 1590000460 Transistor RN1402 (TE85R)
026 1590000460 Transistor RN1402 (TE85R)
C2 4030006860 Ceramic C1608 JB 1H 102K-T-A 027 1590000460 Transistor RN1402 (TE85R)
C3 4030007110 Ceramic C1608 CH 1H 680J-T-A 028 1590000980 Transistor DTB123EK T147
C6 4030006660 Ceramic C1608 JB 1H 102K-T-A 029 1590000980 Transistor DTB123EK T147
C7 4030006950 Ceramic C1608 CH 1H 040C-T-A Q30 1590000980 Transistor DTB123EK T147
C10 4030008910 Ceramic C1608 CH 1H OR5C-T-A 031 1590000980 Transistor DTB123EK T147
C11 4030006860 Ceramic C1608 JB 1H 102K-T-A 032 1590000460 Transistor RN1402 (TE85R)
C12 4030006900 Ceramic C1608 JB 1E 103K-T-A 033 1590000980 Transistor DTB123EK T147
C13 4030006610 Ceramic C1608 SL 1H 1000-T-A 034 1590000460 Transistor RN1402 (TE85R)
C14 4030006860 Ceramic C1608 JB 1H 102K-T-A Q35 1590000420 Transistor RN1404 (TE85R)
C15 4030006900 Ceramic C1608 JB 1E 103K-T-A 036 1580000350 FET 3SK140-Y (TE85R)
C17 4030006860 Ceramic C1608 JB 1H 102K-T-A Q37 1530002030 Transistor 2SC3772-3-TA
C18 4030006860 Ceramic C1608 JB 1H 102K-T-A Q38 1520000080 Transistor 2SB909M R
C20 4030008880 Ceramic C1808 JB 1H 102K-T-A 039 1530000180 Transistor 2SC2712-Y (TE85RTEM)
C21 4030006880 Ceramic C1808 JB 1H 102K-T-A 040 1530001940 Transistor 2SC2712- Bl (TE85R)
C22 4030008920 Ceramic C1808 CH 1H 010C-T-A 041 1540000150 Transistor 2SD1225M R
C23 4030006860 Ceramic C1608 JB 1H 102K-T-A 042 1590001000 Transistor RN2427 (TE85R)
C24 4030008860 Ceramic C1608 JB 1H 102K-T-A 043 1510000700 Transistor 2SA 1736 (TE12R)
C25 4030006850 Ceramic C1608 JB 1H 471K-T-A
5-8
[MAIN-B UNIT) [MAIN-B UNIT}
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
013 1790000450 Diode MA882 (TX) R14 7030003200 Resistor ERJ3GEYJ 100 V (10 Q)
014 1790000450 Diode MA882 (TX) R15 7030003380 Resistor ERJ3GEYJ 331 V {330 Q)
015 1790000450 Diode MA882 (TX) R18 7030003380 Resistor ERJ3GEYJ 331 V (330 Q)
016 1790000450 Diode MA882 (TX) R17 7030003440 Resistor ERJ3GEYJ 102 V (1 kQ)
017 1750000070 Diode 1SS228 (TE85R) R18 7030003400 Resistor ERJ3GEYJ 471 V (470 Q )
018 1710000290 Diode Ml308 R19 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q)
D19 1710000290 Diode Ml308 R20 7030003800 Resistor ERJ3GEYJ 105 V (1 M Q)
020 1730000410 Zener R05.1M-T282 R21 7030003720 Resistor ERJ3GEYJ 224 V (220 k Q )
D21 1750000020 Diode 1SS184 (TE85R) R22 7030003200 Resistor ERJ3GEYJ 100 V (10 Q)
D22 1750000020 Diode 1SS 184 (TE85R) R23 7030003730 Resistor ERJ3GEYJ 274 V (270 k Q)
D23 1750000020 Diode 1SS184 (TE85R} R24 7030003880 Resistor ERJ3GEYJ 104 V (100 k Q)
D24 1750000020 Diode 1SS184 (TE85R} R25 7030003280 Resistor ERJ3GEYJ 470 V {47 Q)
025 1750000020 Diode 1$$184 (TE85R} R28 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q)
D28 1720000270 Varicap 1SV217 (TPH2) R27 7030003380 Resistor ERJ3GEYJ 221 V (220 Q)
D27 1720000270 Varicap 1SV217 (TPH2) R28 7030003280 Resistor ERJ3GEYJ 470 V (47 Q)
D28 1750000050 Diode 1SS 193 (TE85R) R29 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q)
D29 1750000050 Diode 1SS193 (TE85R} R30 7030003420 Resistor ERJ3GEYJ 881 V (880 Q)
D31 1790000700 Diode DSA3A1 R31 7030000280 Resistor MCR10EZHJ 100 Q (101)
R32 7030003320 Resistor ERJ3GEYJ 101 V (100 Q)
R33 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q)
X1 8050006950 Crystal CR-323 R34 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q)
X2 8070000080 Discriminator C0BM455C18 R35 7030003370 Resistor ERJ3GEYJ 271 V (270 Q)
X3 8050007470 Crystal CR-342 R36 7030003400 Resistor ERJ3GEYJ 471 V (470 Q)
R37 7030003230 Resistor ERJ3GEYJ 180 V {18 Q)
R38 7030003370 Resistor ERJ3GEYJ 271 V (270 Q)
Fil 2020000550 Ceramic Filter CFUM455E R39 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q)
Fl2 2010001140 Filter 30M1585 (FL-138) R40 7030003450 Resistor ERJ3GEYJ 122 V (1.2 kQ)
R41 7030003320 Resistor ERJ3GEYJ 101 V (100 Q)
R42 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q)
L1 8200000110 Coil LON 2A 33NM R43 7030003340 Resistor ERJ3GEYJ 151 V (150 Q)
L2 6200000090 Coil LQN 2A 18NM R44 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q)
L3 8200000830 Coil LOH 3N 3R3M R46 7030003320 Resistor ERJ3GEYJ 101 V {100 Q)
L4 8200000770 Coil LQN 2A 88NM (EUR,ITA,USA,AUS,SEA)
LS 8200000130 Coil LON 2A 47NM 7030003540 Resistor ERJ3GEYJ 882 V (8.8 k Q}
L6 8200000110 Coil LON 2A 33NM (EUR-H,ITA-H,
L7 6200000720 Coil LON 2A 10NM USA·H,AUS-H,SEA-H)
L8 8200000110 Coil LQN 2A 33NM R47 4810001100 Trimmer EVMLGGAOOB34 (303)
L9 8200000090 Coil LON 2A 18NM R48 7030003480 Resistor ERJ3GEYJ 152 V (1.SkQ)
L10 8110001150 Coil LA-153 (EUR,ITA,USA,AUS,SEA)
L11 8170000180 Coil LW-19 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q}
L12 8110002110 Coil LA-382 (EUR·H,ITA-H,
L13 6110001520 Coil LA-232 USA·H,AUS-H,SEA-H)
L14 8110001590 Coil LA-242 R49 7030003570 Resistor ERJ3GEYJ 123 V {12 kQ)
L15 8110001520 Coil LA-232 (EUR,ITA,USA,AUS,SEA)
L18 8180001210 Coil LAL 03NA 8R2K 7030003550 Resistor ERJ3GEYJ 822 V (8.2 k Q)
L17 8150003220 Coil LS-320 (EUR·H,ITA·H,
l18 8150002000 Coil LS-284 USA·H,AUS-H,SEA-H)
L19 8200000090 Coil LQN 2A 18NM RSO 7030001050 Resistor MCRSOJZHJ 22 Q (220)
L20 8200000100 Coil LON 2A 22NM R51 7030001180 Resistor MCRSOJZHJ 270 Q (271)
L21 8150003240 Coil LS-338 (HR5W} (EUR,ITA,USA,AUS,SEA)
L22 8150003230 Coil LS-337 (HR5W} R52 7010004130 Resistor R20J 330 Q
L23 8200000720 Coil LON 2A 10NM R53 7030003480 Resistor ERJ3GEYJ 152 V (1.5 kQ)
L24 8200000720 Coil LON 2A 10NM (EUR,ITA,USA,AUS,SEA)
L25 8110002110 Coil LA-382 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q}
L26 6110001520 Coil LA-232 (EUR-H,ITA-H,
L27 8200000090 Coil LQN 2A 18NM USA-H,AUS-H,SEA-H)
L28 8200000090 Coil LON 2A 18NM R54 7030003330 Resistor ERJ3GEYJ 121 V (120 Q)
l29 8200000720 Coil LON 2A 10NM R57 7030003580 Resistor ERJ3GEYJ 103 V (10 k Q)
L30 8200000720 Coil LON 2A 10NM R58 7030003840 Resistor ERJ3GEYJ 473 V (47 k Q)
L31 8200000891 Coil NL 322522T-R15M-3 R59 7030003580 Resistor ERJ3GEYJ 103 V (10 k Q)
L32 8150003120 Coil LS-321 R60 7030003480 Resistor ERJ3GEYJ 152 V (1.5 k Q l
L33 8150003120 Coil LS-321 (EUR,ITA,USA,AUS,SEA)
L34 8180002820 Coil RCR884D-101 K 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q )
L35 8180001120 Coil FL SH 101K (EUR·H,ITA-H,
USA·H,AUS-H,SEA-H)
R61 7030003330 Resistor ERJ3GEYJ 121 V (120 Q)
R1 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q } R82 7010004720 Resistor R50XJ 100 Q
R2 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q) R83 7030003790 Resistor ERJ3GEYJ 824 V (820 k Q )
R3 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q} R84 7030003580 Resistor ERJ3GEYJ 153 V (15 kQ l
R5 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) R85 7030003320 Resistor ERJ3GEYJ 101 V (100 Q)
R6 7030003880 Resistor ERJ3GEYJ 104 V {100 k Q) R68 7030003800 Resistor ERJ3GEYJ 223 V (22 k Q )
R7 4810001110 Trimmer EVMLGGAOOB15 (104) R67 7030003840 Resistor ERJ3GEYJ 473 V (47 kQ)
R8 7030003800 Resistor ERJ3GEYJ 223 V {22 k Q ) R88 7030003570 Resistor ERJ3GEYJ 123 V (12 kQ)
R9 7030003880 Resistor ERJ3GEYJ 104 V {100 k Q) R89 7030003720 Resistor ERJ3GEYJ 224 V {220 k Q )
R10 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) R70 7030003840 Resistor ERJ3GEYJ 473 V {47 kQ)
R11 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q) R71 7030003840 Resistor ERJ3GEYJ 473 V (47 kQ)
R12 7030003740 Resistor ERJ3GEYJ 334 V (330 k Q ) R72 7030000250 Resistor MCR10EZHJ 82 Q (820)
R13 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q) R73 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ)
5-9
[MAIN-B UNIT] [MAIN-B UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
R74 7030003470 Resistor ERJ3GEYJ 182 V (1.8 kQ) R155 7030003360 Resistor ERJ3GEYJ 221 V (220 Q)
R75 7030003640 Resistor ERJ3GEYJ 473 V (47 kQ) R156 7010004780 Resistor R50XJ 470 Q
R76 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ) R157 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q)
R77 7030003450 Resistor ERJ3GEYJ 122 V (1.2 kQ) R158 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q)
R78 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q) R159 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q)
R79 7030003400 Resistor ERJ3GEYJ 471 V (470 Q) R181 7030003260 Resistor ERJ3GEYJ 330 V (33 Q )
R80 7030003480 Resistor ERJ3GEYJ 222 V (2.2 kQ) R162 7030003220 Resistor ERJ3GEYJ 150 V (15 Q)
R82 7030003760 Resistor ERJ3GEYJ 474 V (470 k Q) R163 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q)
R83 7030003340 Resistor ERJ3GEYJ 151 V (150 Q) R184 7510000450 Thermistor DTN-T203C471 LS (T)
R84 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ)
R85 7030003680 Resistor ERJ3GEYJ 104 V (100 kQ)
R86 7030003680 Resistor ERJ3GEYJ 104 V (100 kQ) Cl 4030008630 Ceramic C1608 JF lC 1042-T-A
R87 4810001110 Trimmer EVMLGGAOOB15 (104) C2 4030006890 Ceramic C1608 JF 1H 103Z-T-A
R88 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C3 4510002930 Electrolytic 50 SS R47 µF
R89 7030003400 Resistor ERJ3GEYJ 471 V (470 Q) C4 4030008630 Ceramic C1608 JF lC 1042-T-A
R90 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) cs 4030008680 Ceramic C2012 JF lC 105Z-T-A
R91 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q ) C6 4610000380 Trimmer ECRGA020E30
R92 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C7 4030008560 Ceramic C1608 CH 1H 300J-T-A
R93 7030003200 Resistor ERJ3GEYJ 100 V (10 Q) ca 4030006860 Ceramic C1608 JB 1H 102K-T-A
R94 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C9 4030004980 Ceramic C2012 CH 1H 820J-T-A
R95 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q ) ClO 4030007090 Ceramic C1608 CH 1H 470J-T-A
R96 7030003350 · Resistor ERJ3GEYJ 181 V (180 Q) Cll 4030008430 Ceramic C1608 JF 1H 223Z-T-A
R97 7030003350 Resistor ERJ3GEYJ 181 V (180 Q) C12 4030006940 Ceramic C1608 CH 1H 030C-T-A
R98 7030003260 Resistor ERJ3GEYJ 330 V (33 Q ) C13 4030008430 Ceramic C1608 JF 1H 223Z-T-A
R99 7030003300 Resistor ERJ3GEYJ 680 V (88 Q ) C14 4030006860 Ceramic C1608 JB 1H 102K-T-A
RlOO 7030003480 Resistor ERJ3GEYJ 222 V (2.2 kQ) C15 4030006860 Ceramic C1608 JB 1H 102K-T-A
R101 7030003560 Resistor ERJ3GEYJ 103 V (10 kQ) C16 4030008430 Ceramic C1608 JF 1H 2232-T-A
R102 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q) Ct7 4030006850 Ceramic C1608 JB 1H 471K-T-A
R103 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ) C18 4030008680 Ceramic C2012 JF lC 105Z-T-A
R104 7030003380 Resistor ERJ3GEYJ 331 V (330 Q) C23 4030008850 Ceramic C1808 JB 1H 471K-T-A
R105 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C24 4510002840 Electrolytic 25 SS 47 µF
R106 7030003580 Resistor ERJ3GEYJ 153 V (15 k Q) C26 4510002730 Electrolytic 10 SS 100 µF
R107 7030003280 Resistor ERJ3GEYJ 470 V (47 Q) C27 4030006860 Ceramic C1608 JB 1H 102K-T-A
R108 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) C28 4030006850 Ceramic C1608 JB 1H 471K-T-A
R109 7030003340 Resistor ERJ3GEYJ 151 V (150 Q) C29 4030006850 Ceramic C1608 JB 1H 471K-T-A
R110 7030003250 Resistor ERJ3GEYJ 270 V (27 Q) C30 4510003150 Electrolytic 35 SS 33 µF
R111 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C31 4030006880 Ceramic C1608 JB 1H 102K-T-A
Rl 12 7030003600 Resistor ERJ3GEYJ 223 V (22 k Q ) C32 4030008880 Ceramic C1808 JB 1H 102K-T-A
R113 7030003560 Resistor ERJ3GEYJ 103 V (10 kQ) C33 4030006880 Ceramic C1808 JB 1H 102K-T-A
R114 7030003560 Resistor ERJ3GEYJ 103 V (10 k Q) C34 4030008590 Ceramic C1808 SL 1H 080D-T-A
R115 7030003560 Resistor ERJ3GEYJ 103 V (10 kQ) C35 4030008860 Ceramic C1808 JB 1H 102K-T-A
R116 7030003560 Resistor ERJ3GEYJ 103 V (10 kQ) C37 4030008570 Ceramic C1808 SL 1H 060D-T-A
R117 7030003560 Resistor ERJ3GEYJ 103 V (10 kQ) C38 4030008580 Ceramic C1608 SL 1H 070D-T-A
R118 7030003480 Resistor ERJ3GEYJ 222 V (2.2 kQ) C39 4030006580 Ceramic C1608 SL 1H 070D-T-A
R119 7030003290 Resistor ERJ3GEYJ 560 V (56 Q ) C40 4030006860 Ceramic C1806 JB 1H 102K-T-A
R120 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) C41 4030006880 Ceramic C1808 JB 1H 102K-T-A
R121 7030000240 Resistor MCR10EZHJ 68 Q (680) C42 4030008570 Ceramic C1608 SL 1H 080D-T-A
R122 7030003520 Resistor ERJ3GEYJ 472 V (4.7 k Q) C43 4030006810 Ceramic C1608 SL 1H 100D-T-A
R123 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C44 4030006860 Ceramic C1608 SL 1H 220J-T-A
R124 7030003220 Resistor ERJ3GEYJ 150 V (15 Q) C45 4030008810 Ceramic C1808 SL 1H 100D-T-A
R125 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ) C48 4030006860 Ceramic C1608 JB 1H 102K-T-A
R126 7030003250 Resistor ERJ3GEYJ 270 V (27 Q ) C47 4030006860 Ceramic C1608 JB 1H 102K-T-A
R127 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C48 4030006860 Ceramic C1808 JB 1H 102K-T-A
R128 7030003680 Resistor ERJ3GEYJ 104 V (100 kQ) C49 4030008880 Ceramic C1608 JB 1H 102K-T-A
R129 7030003620 Resistor ERJ3GEYJ 333 V (33 k Q ) C50 4030008880 Ceramic C1608 JB 1H 102K-T-A
R130 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ) C51 4030006860 Ceramic C1608 SL 1H 220J-T-A
R131 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C52 4030006860 Ceramic C1608 JB 1H 102K-T-A
R132 4610001140 Trimmer EVMLGGAOOB33 (302) C53 4030006550 Ceramic C1608 SL 1H 040C-T-A
R133 7030003480 Resistor ERJ3GEYJ 222 V (2.2 k Q) C54 4030006810 Ceramic C1608 SL 1H 1000-T-A
R134 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q) C55 4030006860 Ceramic C1608 JB 1H 102K-T-A
R135 7030003370 Resistor ERJ3GEYJ 271 V (270 Q) C56 4030006880 Ceramic C1608 JB 1H 102K-T-A
R136 7030003440 Resistor ERJ3GEYJ 102 V (1 kQ) C57 4030008880 Ceramic C1808 JB 1H 102K-T-A
R137 7030003230 Resistor ERJ3GEYJ 180 V (18 Q) C58 4030008860 Ceramic C1608 JB 1H 102K-T-A
R138 7030003370 Resistor ERJ3GEYJ 271 V (270 Q) C59 4030006680 Ceramic C1608 SL 1H 220J-T-A
R139 7030003370 Resistor ERJ3GEYJ 271 V (270 Q ) C60 4030008570 Ceramic C1608 SL 1H 060D-T-A
R140 7030003320 Resistor ERJ3GEYJ 101 V (100 Q) C61 4030008570 Ceramic C1808 SL 1H OBOD-T-A
R141 7030003680 Resistor ERJ3GEYJ 104 V (100 kQ) C82 4030006860 Ceramic C1608 JB 1H 102K-T-A
R142 7030003280 Resistor ERJ3GEYJ 470 V (47 Q) C84 4550000280 Tantalum DN 1V 100M
R143 7030003590 Resistor ERJ3GEYJ 183 V (18 kQ) CBS 4030006860 Ceramic C1808 JB 1H 102K-T-A
R144 7030003500 Resistor ERJ3GEYJ 332 V (3.3 k Q) C66 4030008880 Ceramic C1808 JB 1H 102K-T-A
R145 7030003680 Resistor ERJ3GEYJ 104 V (100 k Q) C67 4030006860 Ceramic C1808 JB 1H 102K-T-A
R148 7030000380 Resistor MCR10EZHJ 1 k Q (102) C68 4030006880 Ceramic C1808 JB 1H 102K-T-A
R149 7030003440 Resistor ERJ3GEYJ 102 V (1 k Q) C89 4030006860 Ceramic C1808 JB 1H 102K-T-A
R150 7030003490 Resistor ERJ3GEYJ 272 V (2.7 k Q) C70 4550000280 Tantalum DN 1V 100M
R151 7030003690 Resistor ERJ3GEYJ 124 V (120 k Q ) C71 4030006880 Ceramic C1808 JB 1H 102K-T-A
R152 7030003520 Resistor ERJ3GEYJ 472 V (4.7 kQ) C72 4010003820 Ceramic DD08 SL 050C 500V
R153 7030003400 Resistor ERJ3GEYJ 471 V (470 Q) C73 4030008860 Ceramic C1808 JB 1H 102K-T-A
R154 7010004830 Resistor R50XJ 4.7 Q C74 4030006880 Ceramic C1608 JB 1H 102K-T-A
5-10
[MAIN-8 UNIT] [MAIN-8 UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
C75 4010003820 Ceramic 0006 SL 050C 500V C155 4030008810 Ceramic C1808 SL 1H 1000-T-A
C76 4510002980 Electrolytic 50 SS 10 µF C158 4030008850 Ceramic C1808 JB 1H 471K-T-A
C77 4030006860 Ceramic C1608 JB 1H 102K-T-A C157 4030008880 Ceramic C1608 JB 1H 102K-T-A
C78 4010004110 Ceramic 0005 B 471K 500V C158 4030008880 Ceramic C1608 JB 1H 102K-T-A
C79 4030006860 Ceramic C1608 JB 1H 102K-T-A C159 4030008850 Ceramic C1608 JB 1H 471K-T-A
cao 4030006860 Ceramic C1608 JB 1H 102K-T-A C162 4030008880 Ceramic C1608 JB 1H 102K-T-A
C81 4030006860 Ceramic C1608 JB 1H 102K-T-A C163 4810001340 Trimmer ECR-LA010A12
C82 4010004110 Ceramic 0005 B 471K 500V C184 4030008880 Ceramic C1808 JB 1H 102K-T-A
C83 4010003820 Ceramic 0006 SL 050C 500V C185 4030008850 Ceramic C1608 JB 1H 471K-T-A
C84 4010003850 Ceramic 0006 SL 0800 500V C188 4030008880 Ceramic C1808 JB 1H 102K-T-A
C85 4010003830 Ceramic 0006 SL 0600 500V C167 4030008850 Ceramic C1608 JB 1H 471K-T-A
C86 4010003870 Ceramic 0006 SL 120K 500V C188 4030008850 Ceramic C1608 JB 1H 471K-T-A
C87 4010003820 Ceramic 0006 SL 050C 500V C189 4610001340 Trimmer ECR- LA010A12
C88 4010003860 Ceramic 0006 SL 1000 500V C170 4030006880 Ceramic C1608 JB 1H 102K-T-A
C89 4030006860 Ceramic C1608 JB 1H 102K-T-A C171 4030008580 Ceramic C1608 SL 1H 050C-T-A
C90 4030006860 Ceramic C1608 JB 1H 102K-T-A C172 4030008630 Ceramic C1808 JF 1C 1042-T-A
C91 4030006860 Ceramic C1608 JB 1H 102K-T-A C173 4030008830 Ceramic C1808 JF 1C 1042-T-A
C92 4030006860 Ceramic C1608 JB 1H 102K-T-A C174 4510002940 Electrolytic 50SS1µF
C93 4030008630 Ceramic C1608 JF 1C 1042-T-A C177 4030008880 Ceramic C1808 JB 1H 102K-T-A
C94 4030006630 Ceramic C1608 JF 1C 1042-T-A C178 4030008880 Ceramic C1608 JB 1H 102K-T-A
C95 4510002980 Electrolytic 50 SS 10 µF C179 4030006880 Ceramic C1808 JB 1H 102K-T-A
C96 4030008630 Ceramic C1608 JF 1C 104Z-T-A C180 4030006580 Ceramic C1608 SL 1H 0700-T-A
C97 4030006640 Ceramic C1608 SL 1H 180J-T-A C181 4030006860 Ceramic C1808 JB 1H 102K-T-A
C98 4030006720 Ceramic C1608 SL 1H 560J-T-A C182 4030008840 Ceramic C1608 SL 1H 180J-T-A
C99 4030006890 Ceramic C1808 SL 1H 330J-T-A C183 4030006550 Ceramic C1608 SL 1H 040C-T-A
C100 4030008830 Ceramic C1808 JF 1C 1042-T-A C184 4030006860 Ceramic C1808 JB 1H 102K-T-A
C101 4030008860 Ceramic C1808 JB 1H 102K-T-A C185 4030006550 Ceramic C1608 SL 1H 040C-T-A
C102 4030006880 Ceramic C1808 JB 1H 102K-T-A C188 4030008550 Ceramic C1808 SL 1H 040C-T-A
C103 4030008880 Ceramic C1808 JB 1H 102K-T-A C187 4030008550 Ceramic C1808 SL 1H 040C-T-A
C104 4030008860 Ceramic C1808 JB 1H 102K-T-A C188 4030006840 Ceramic C1808 SL 1H 180J-T-A
C105 4030006860 Ceramic C1808 JB 1H 102K-T-A C189 4030006750 Ceramic C1608 SL 1H 101J-T-A
C108 4030008890 Ceramic C1808 JF 1H 103Z-T-A C190 4030008750 Ceramic C1808 SL 1H 101J-T-A
C107 4030006690 Ceramic C1808 SL 1H 330J-T-A C191 4030006750 Ceramic C1608 SL 1H 101J-T-A
C108 4510002930 Electrolytic 50 SS R47 µF C192 4030008750 Ceramic C1608 SL 1H 101J- T-A
C109 4030008860 Ceramic C1808 JB 1H 102K-T-A C193 4030008750 Ceramic C1608 SL 1H 101J-T-A
C110 4030008880 Ceramic C1608 JB 1H 102K-T-A C194 4030008750 Ceramic C1608 SL 1H 101J-T-A
C111 4030008880 Ceramic C1808 JB 1H 102K-T-A C195 4030008750 Ceramic C1808 SL 1H 101J-T-A
C112 4030008860 Ceramic C1808 JB 1H 102K-T-A C198 4030008750 Ceramic C1808 SL 1H 101J-T-A
C113 4030008880 Ceramic C1808 JB 1H 102K-T-A C197 4030008750 Ceramic C1808 SL 1H 101J-T-A
C114 4030006890 Ceramic C1808 JF 1H 1032-T-A C198 4030008750 Ceramic C1808 SL 1H 101J-T-A
C115 4030008890 Ceramic C1808 JF 1H 1032-T-A C199 4030008750 Ceramic C1808 SL 1H 101J-T-A
C116 4030008890 Ceramic C1608 JF 1H 103Z-T-A C200 4030006750 Ceramic C1608 SL 1H 101J-T-A
C117 4030006880 Ceramic C1608 JB 1H 102K-T-A C201 4030008750 Ceramic C1608 SL 1H 101J-T-A
C118 4510002980 Electrolytic 50SS10µF C202 4030008750 Ceramic C1808 SL 1H 101J-T-A
C119 4030006880 Ceramic C1808 JB 1H 102K-T-A C203 4030006750 Ceramic C1808 SL 1H 101J-T-A
C120 4030008710 Ceramic C1608 SL 1H 470J-T-A C204 4030008750 Ceramic C1808 SL 1H 101J-T-A
C121 4030008810 Ceramic C1808 SL 1H 1000-T-A C205 4030008750 Ceramic C1608 SL 1H 101J-T-A
C122 4030006890 Ceramic C1808 JF 1H 1032-T-A C208 4510002840 Electrolytic 25 SS 47 µF
C124 4030008660 Ceramic C1808 SL 1H 220J-T-A C207 4030008630 Ceramic C1608 JF 1C 1042-T-A
C125 4030008890 Ceramic C1808 JF 1H 103Z-T-A C208 4030008830 Ceramic C1808 JF 1C 1042-T-A
C126 4030006550 Ceramic C1608 SL 1H 040C-T-A C209 4510003150 Electrolytic 35SS33µF
C127 4020000880 Cylinder UP125 SL 120J C211 4510003150 Electrolytic 35SS33µF
C128 4030006850 Ceramic C1808 JB 1H 471K-T-A C213 4510003150 Electrolytic 35SS33µF
C129 4030006850 Ceramic C1608 JB 1H 471K-T-A C214 4550000320 Tantalum ON 1V OR1M
C130 4030008550 Ceramic C1608 SL 1H 040C-T-A C215 4030008860 Ceramic C1808 JB 1H 102K-T-A
C131 4030006860 Ceramic C1808 JB 1H 102K-T-A C218 4510002870 Electrolytic 25 SS 100µF
C132 4030008850 Ceramic C1808 JB 1H 471K-T-A C217 4510002870 Electrolytic 25 SS 100 µF
C133 4030006850 Ceramic C1808 JB 1H 471K-T-A C218 4030008830 Ceramic C1808 JF 1C 104Z-T-A
C134 4810001340 Trimmer ECR- LA010A12 C219 4510002840 Electrolytic 25SS47µF
C135 4030008180 Ceramic C2012 UJ 1H 040C-T-A C220 4510002840 Electrolytic 25 SS 47 µF
C136 4030008880 Ceramic C1608 JB 1H 102K-T-A C221 4030008830 Ceramic C1808 JF 1C 1042-T-A
C137 4030008880 Ceramic C1808 JB 1H 102K-T-A C222 4510002730 Electrolytic 10 SS 100 µF
C138 4030006880 Ceramic C1808 JB 1H 102K-T-A C223 4030008830 Ceramic C1808 JF 1C 1042-T-A
C139 4610001340 Trimmer ECR- LA010A12 C224 4030008830 Ceramic C1808 JF 1C 1042-T-A
C140 4030008560 Ceramic C1608 SL 1H 050C-T-A C225 4510002840 Electrolytic 25 SS 47 µF
C141 4030008860 Ceramic C1608 JB 1H 102K-T-A C228 4510002380 Electrolytic 18 SS 470 µF (10X12.5)
C142 4030006880 Ceramic C1608 JB 1H 102K-T-A C229 4030008830 Ceramic C1808 JF 1C 104Z-T-A
C144 4030008880 Ceramic C1808 JB 1H 102K-T-A C230 4030008630 Ceramic C1808 JF 1C 104Z-T-A
C145 4030006880 Ceramic C1608 JB 1H 102K-T-A C231 4030008630 Ceramic C1808 JF 1C 104Z-T-A
C146 4030006860 Ceramic C1608 JB 1H 102K-T-A C232 4030008830 Ceramic C1608 JF 1C 104Z-T-A
C147 4030006550 Ceramic C1608 SL 1H 040C-T-A C233 4030008830 Ceramic C1608 JF 1C 1042-T-A
C148 4030008550 Ceramic C1608 SL 1H 040C-T-A C234 4030008860 Ceramic C1808 JB 1H 102K-T-A
C149 4030006860 Ceramic C1608 JB 1H 102K-T-A C235 4030006880 Ceramic C1608 JB 1H 102K-T-A
C150 4010003830 Ceramic 0006 SL 0800 500V C236 4030008880 Ceramic C1808 JB 1H 102K-T-A
C151 4030008850 Ceramic C1808 JB 1H 471K-T-A C237 4030008880 Ceramic C1808 JB 1H 102K-T-A
C152 4030006610 Ceramic C1608 SL 1H 1000-T-A C238 4030008850 Ceramic C1608 JB 1H 471K-T-A
C153 4030006880 Ceramic C1608 JB 1H 102K-T-A C239 4030008830 Ceramic C1808 JF 1C 104Z-T-A
C154 4030006560 Ceramic C1608 SL 1H 050C-T-A C240 4030008680 Ceramic C2012 JF 1C 105Z-T-A
5-11
[MAIN-B UNIT] [VCO-B UNIT]
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
C242 4030006880 Ceramic C1608 JB 1H 102K-T-A Q1 1560000650 FET 2SK1577-2-TI
C243 4030006880 Ceramic C1608 JB 1H 102K-T-A a2 1590001280 Transistor RN1408 (TE85R)
C244 4030008680 Ceramic C2012 JF 1C 105Z-T-A Q3 1530002240 Transistor 2SC3775-3-TA
C245 4030006530 Ceramic C1608 SL 1H 020C-T-A 04 1560000640 FET 2SK1740-TA
C246 4030008850 Ceramic C1608 JB 1H 471K-T-A as 1590001280 Transistor RN1406 (TE85R)
C248 4030006550 Ceramic C1608 SL 1H 040C-T-A
C249 4030008680 Ceramic C2012 JF 1C 105Z-T-A
C250 4550000890 Tantalum TESVC 1C 475M-12L D1 1720000220 Varicap 1SV166-T2B
C251 4030006860 Ceramic C1608 JB 1H 102K-T-A 02 1720000220 Varicap 1SV186-T2B
03 1720000220 Varicap 1SV186-T2B
D4 1720000220 Varicap 1SV166-T2B
EP1 0910030182 P.C. Board B 30308 (MAIN- B )
L1 6200001560 Coil LER 01ST R68M
L2 6200001560 Coil LER 01ST R68M
L3 8130002450 Coil LB-273
L4 8200001570 Coil LER 01ST 1ROM
[PLL-B UNIT] LS 8200001570 Coil LER 01ST 1ROM
L6 8200001590 Coil LER 01ST 2R2M
REF. ORDER L7 8200001590 Coil LER 01ST 2R2M
DESCRIPTION
NO. NO. L8 6200001590 Coil LER 01ST 2R2M
IC1 1130005700 IC M56760FP L9 6130002440 Coil LB-272
IC2 1130004200 IC TC4S66F (TE85R) l10 6200001230 Coil MLF2012A 1ROM-T
5-12
[B-BAND UNIT] [ TONE UNIT] (U.S.A. only)
REF. ORDER REF. ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
01 1530002430 Transistor 2SC4315 (TE85R) IC1 1130005100 IC FX365LG
02 1580000360 FET 3SK177- T2B U73
03 1590000420 Transistor RN1404 (TE85R)
04 1530002240 Transistor 2SC3775- 3-TA X1 8080000480 Crystal CSB1000J221T
5-13
SECTION 6 ADJUSTMENT PROCEDURES
DC power supply Output voltage 13.8 V DC Audio generator Frequency range : 300-3000 Hz
Current capacity : 15 A or more Output level : 1-500 mV
RF power meter Measuring range : 1-60W Attenuator Power attenuation : 40 or 50 dB
(terminated type) Frequency range : 120-460 MHz Capacity : 60 W or more
Impedance : 50 n Sweep generator Frequency range : 0.1-460 MHz
SWR : Less than 1.2 : 1 Sweep bandwidth : At least 10 MHz
Frequency counter Frequency range : 0.1-460 MHz Output impedance : 50 n
Frequency accuracy : ± 1 ppm or better
Detector
Sensitivity : 100 mV or better 0.001 µF 1K60
Oscilloscope
Standard signal
Frequency range
Measuring range
Frequency range
: DC-20 MHz
: 0.01-10 V
: 0.1-460 MHz
~'ff
INPUT o 1K60 - -
0.001 µF
: OUTPUT
.CONNECTION
[ANT]
Signal output
to [ANT] --------1 Sweep
generator
IC-2410A/E/H
Trigger output
y
Audio
generator
6-1
6·2 PLL ADJUSTMENT
ADJUSTMENT
MEASUREMENT POINT
ADJUSTMENT ADJUSTMENT CONDITIONS VALUE
UNIT LOCATION UNIT ADJUST
REFERENCE 1 • Displayed frequency [U DISPLAY]: Rear Loosely couple the 445.0000 MHz MAIN-8 C6
FREQUENCY 445.0000 MHz (USA version) panel frequency counter to (USA version)
435.0000 MHz (All other versions) the [ANn connector. 435.0000 MHz
• Connect the RF power meter or a (All other versions)
50 0 dummy load to the [ANn
connector.
•Simplex
• Transmitting
VHF LOCK 1 • Displayed frequency [V DISPLAY]: MAIN-A Connect the DC 7.5 V MAIN-A L9
VOLTAGE 145.0000 MHz voltmeter to CP-A 1. (VCO-A)
•Receiving
UHF LOCK 1 • Displayed frequency [U DISPLAY]: MAIN-8 Connect the DC 12V±0.5V MAIN-8 Verify
VOLTAGE 445.0000 MHz (USA version) voltmeter to CP1. (USA version)
435.0000 MHz (All other versions) 11 V±0.5V
• Receiving (All other versions)
6-2
• MAIN-A UNIT
• MAIN·B UNIT
6-3
6-3 RECEIVER ADJUSTMENT
ADJUSTMENT
MEASUREMENT
POINT
ADJUSTMENT ADJUSTMENT CONDITIONS VALUE
UNIT LOCATION UNIT ADJUST
VHF 1 • Displayed frequency [V DISPLAY]: MAIN-A Connect the DC Maximum MAIN-A Adjust in
SENSITIVITY 146.0000 MHz (USA version) voltmeter to CP-A2. sequence
145.0000 MHz (All other versions) L20, L19,
• Connect the SSG to the [ANT] L18, L17
connector and set as:
Level : 10 µV* (-87 dBm)
Modulation: 1 kHz
Deviation · ±3.5 kHz
• R81 (MAIN-A) : Max. CW
• Receiving
NOTE: Adjust the standard signal genarator output level so that the DC voltmeter needle
remains at all times in the lowest 30 % of the full range.
UHF 1 • Displayed frequency [U DISPLAY]: MAIN-B Connect the Adjust as follows: MAIN-B C139,
SENSITIVITY 445.0000 MHz (USA version) oscilloscope to J4, C134,
435.0000 MHz (All other versions) pin 1 via the detector. L22, L21
I
• Connect the sweep generator to the I Min.
.LIT'
[ANT] connector and set as: I
2 • Connect the SSG to the [ANT] Connect the DC Maximum L18, L17
connector and set as: voltmeter to CP2.
Level : 10 µV*(-87 dBm)
Modulation: 1 kHz
Deviation : ±7.0 kHz
• R87 (MAIN-B) :Max. CW
NOTE: Adjust the standard signal genarator output level so that the DC voltmeter needle
remains at all times in the lowest 30 % of the full range.
*This output level of the standard signal generator (SSG) is indicated as SSG's open circuit.
6-4
• MAIN-A UNIT
• MAIN-B UNIT
6-5
RECEIVER ADJUSTMENT (CONTINUED)
ADJUSTMENT
MEASUREMENT POINT
ADJUSTMENT ADJUSTMENT CONDITIONS VALUE
UNIT LOCATION UNIT ADJUST
NOTE: Adjust the standard signal genarator output level so that the DC voltmeter needle
remains at all times in the lowest 30 % of the full range.
S·METER 1 • Displayed frequency [V DISPLAY]: Function S indicator 4 dots (S3} MAIN-A R81
146.0000 MHz (USA version) display [V DISPLAY]
145.0000 MHz (All other versions)
• Connect the SSG to the [ANT]
connector and set as:
I•a•• I
Level : 1.0 µV*(-107 dBm)
Modulation: 1 kHz
Deviation : ±3.5 kHz
• Receiving
3 • Displayed frequency [U DISPLAY]: Function Squelch indicator 1 dot (SOL 1} Front (U SQLJ
445.0000 MHz (USA version) display [U DISPLAY] panel switch
435.0000 MHz (All other versions)
1- I
-
4 Top Speaker Squelch threshold MAIN·B R132
cover point
* This output level of the standard signal generator (SSG} is indicated as SSG's open circuit.
6-6
• MAIN-A UNIT
• MAIN-B UNIT
6-7
6-4 TRANSMITTER ADJUSTMENT
ADJUSTMENT
MEASUREMENT POINT
ADJUSTMENT ADJUSTMENT CONDITIONS VALUE
UNIT LOCATION UNIT ADJUST
OUTPUT 1 • Displayed frequency [V DISPLAY]: Rear Connect the RF 25 W (IC-2410A/E) MAIN-A R31
POWER 146.0000 MHz (USA version) panel power meter to the 45 W (IC-2410H)
145.0000 MHz (All other versions} [ANT] connector.
• [HI/LOW] switch :HI
•Simplex
• Transmitting
DEVIATION 1 • Displayed frequency [V DISPLAY]: Rear Connect the FM ±4.8 kHz MAIN-A RS
146.0000 MHz (USA version} panel deviation meter to
145.0000 MHz (All other versions) the [ANn connector
• [HI/LOW] switch :HI via the attenuator.
• [TIT. SOL] switch :OFF
• Connect the audio generator to the
microphone connector and set as:
65 mV/1.0 kHz (USA version)
20 mV/1.0 kHz (All other versions)
• Set the FM deviation meter as:
HPF : 50 Hz
LPF : 20 kHz
De-emphasis: OFF
Detector : (P·P)/2
• Transmitting
TONE 1 • Displayed frequency [U DISPLAY]: Rear Connect the FM ±0.8 kHz AF R15
DEVIATION 445.0000 MHz panel deviation meter to
(USA only} • [TIT. SOL] switch :ON the [ANT] connector
• Remove TONE UNIT. via the attenuator.
• Apply no signal to the microphone
connector.
• Set the tone frequency as: 88.5 Hz
• Set the FM deviation meter as:
HPF : OFF
LPF : 20 kHz
De-emphasis: OFF
Detector : (P·P)/2
• Transmitting
6-8
TRANSMITTER ADJUSTMENT (CONTINUED)
ADJUSTMENT
MEASUREMENT
POINT
ADJUSTMENT ADJUSTMENT CONDITIONS VALUE
UNIT LOCATION UNIT ADJUST
TONE 1 • Displayed frequency [U DISPLAY]: Rear Connect the FM ±0.8 kHz AF R15
DEVIATION 435.0000 MHz panel deviation meter to
(All other • [TIT. SOL] switch :ON the [ANT] connector
versions) • Apply no signal to the microphone via the attenuator.
connector.
• Set the tone frequency as: 88.5 Hz
• Set the FM deviation meter as:
HPF : OFF
LPF : 20 kHz
De-emphasis: OFF
Detector : (P-P)/2
• Transmitting
• MAIN-A UNIT
• MAIN-B UNIT
6-9
SECTION 7 BOARD LAYOUTS
I u VOL I
• DISPLAY UNIT
·-
I II I I I
!lill,i
• •
00
[rn
©©©
©©
©©© ,
7-1
1SS181
(Symbol : A3)
1SS187
(Symbol : D3) --
5 --
""" -
--~· --
$191'1
-· -
-·-
- fi
\
1SS190
(Symbol : E3)
1SS193
(Symbol : F3)
5
D2. D3. D20
RD9.1M 82
(Symbol : 912)
5 D1
2SA1162 Y
(Symbol : SY)
'" 'ID
( MITIEA
07
OOLLECTOA
2SA1734
(Symbol: LB)
.....
EMll lERC!::::'.J
09. 01 0
2SC2712 Y
- •l h
_,
w ---
(Symbol : LY) "' -
..,,_
·--
,_ _
·---
_, --
v 4,
...
... -
""
RN2404 - --
.,..,_
. .,l1
~
(Symbol : YD)
} «>c..LECTOA
t M H l t.K •"
01
7-2
7-2 AF AND TONE (U.S.A. only) UNITS
----·--·
-1$0.V
!!
--
- ll!W'l.'I
-
,;.8 ---,l't!I.I
'"""'
, ltl'>'
-1,1$011
- ""''
-=·
-,,w
-~,~
----
-<><
- ,o•s~
I I
~~ il :>,.
tavevvSa&~v~U
1 1 11 111 1 111111
WO
_,,v
--·-·-.
-Sl""'4
-n=
i ::; :
--=~
- ........x, '
- Nt .
I
7- 3
1SS226
(Symbol : CJ)
01
2SC2712 GR
. . ID
(Symbol: LG)
COll(¢:T()fl
EMlffEA
Q I, 05, 06
2SC2712 y
. . ID
(Symbol : LY)
CQU.t,ClOlt
( MITI(A
2SC3326
. . ID
(Symbol: CCB)
(M m ER
couEetOA
,W -
2SJ106 y
(Symbol : VY)
souoc,ffl
.,..,.
G.t. lE
--
- C,,.IA.
• u•IO(
-"''
- - ,#---'-'
- '"" -ti,.--"
RN1404
(Symbol: XO)
·- -
04, 09, 011
7- 4
7-3 MAIN-A, PLL-A AND VCO-A UNITS
• MAIN-A UNIT
5
D4,D5,D23
~
D25,D26
§
D3,D28
5
D2,D6,D24,D27
§
D11, D20
§
D7,D8,D12
-m
(Symbol: M 11) (Symbol: 512) (Symbol: 622) (Symbol: SY) (Symbol: LB)
D
013, D18, D19
5 D29
5
D10, D30
EMITTER
05
COLLECTOR
:::-~ 02
BASE~
COLLECTOR
EMITTER
COLLECTOR
~ ~MITTER
BASE
COLLECTO~C
BASEm
EMITTER
COLLECTOR
011 (EUR, ITA, USA, AUS, SEA) 011 (EUR·H, ITA-H, 037 08 (EUR, ITA, USA, AUS, SEA) 016, 017
USA-H, AUS-H, SEA-H)
2SC2712 Y
(Symbol: LY)
BASEm
EMITTER
EMITTER
03
COLLECTOR
2SC3772 3
(Symbol: LY3)
EMll'TER
013
GATE
=«:m
2SK209 Y
(Symbol: XY)
ORA.IN
04
GATE
~_,.
(Symbol: UG) (Symbol: U73) (Symbol: G2) (Symbol: D6)
-IN~GAff:2
..... . EMITTER§f COLLECTOR
,,..,. BAS~EEMITTER • ~
EMITTER BASE 5 2 BASE
~
....... ~ ...... BASE2 C0t.LECTOR2
COLLECTOR 4 3 EMJTTEFt
EMITIER
COLLECTOR
E
BASEO
EMITTER
COLLECTOR
BASEO
EMITTER
COLLECTOR BASE~COLLECTOR
EMITTERV
025,026, 027,028,033 09, 010, 020, 035 029, 030, 031, 032
7-5
• MAIN-A UNIT (TOP VIEW)
0
Cl86 ...
-
I
I
(
"' -
< I
l\W>l $JII
-··
The combination of this page and the next page shows
the unit layout in the same configuration as the actual
P.C. Board.
~
~
t181
e...
er,
-
r:--
u
7- 6
• MAIN-A UN IT (BOTIOM VIEW)
7 -7
• PLL·A UNIT
- !IW't.V ""'°'"
..,_
. . _.
- CMA.
-0<
• _,,,,, ,,. - ·~
1 _.., ··" - it
_....., . '°"" -
"'' -
- •S'I ,,,.,,._
..,m
(Symbol: LY) (Symbol: CBG) (Symbol: LY3) (Symbol : XY)
-·m
( MITTER
cou.ECTOll -m-..
E!oi!TI(A
c,~
( M UI l it
¢0l1,_((:f()A
=•ct ~
~""
(l...t(
03 02 05 01
RN1404 RN2402
(Symbol : XO) (Symbol : YB)
""lr
( Mlfl(jl
:•
04
001.lECH)II
06
• VCO-A UNIT
....,._
---
•=-
,,. - •
-...~·-
,
-i
"'' -
-·-
""ID
o i m tA
<.:OU(CI QI\ =~·~
~""
o.-.n -~·~
~""
Ol<lt
""lr
E•u n (A ~ OOl..l f:ClOA.
03 01 04 0 2. 05
7 -8
7-4 MAIN-B, PLL-B, VCO-B AND B-BAND UNITS
• MAIN-8 UNIT
5 D4
5
D21, D22, D23
5
D2,D6, D28, D29
Q D3
§
D12, D17 D7, D8, D11
D24,D25
BASEm
0
D5, D13,D14, D15, D16
5 D1
5 D20
5 D10
EMITTER
07
COLLECTOR
BASEm COLLECTOR
BASE~
COLLECTOR COLLECTOR
BASEm COLLECTOR
BASEm COLLECTOR
BASEm COLLECTOR
BASEm COlLECTOR
BASEm COLLECTOR BASEm COLLECTOR
. . .Em
-~......
SOURCEffl -~GATEI
COLLECTOR GATE
EMITTER DRAIN
BASE:rr COLLECTOR
E M I T T E R ~ t COLLECTOR
BASE S 2 BASE
B A S E ~ EMITTER
BASE:rr COLLECTOR
BASE:rr COLLECTOR
EMITTER~~
EMITTER EMITTER EMITTER
COLLECTOR 4 3 EMITTER
COLLECTOR
028, 029, 030 023 011 024, 025, 026 012, 013, 018, 035
031, 033 027, 032, 034
RN2427
(Symbol: RG)
BASE:rr COLLECTOR
EMITTER
042
7-9
• MAIN-B UNIT (TOP VIEW)
I
.J
I
' - -- . . J . L - - - r , - - , , - - - - - - ~ - -- ~~- - -~ ~ - 1 L_ ___JI
-------'--- ----------- -- ---- - - - - - - - __ J ____ _J
•
lHl -C18
C30
; ; a ~ f ~ ~ ' i I§ a; I ! g ! §g
1 11 11 11 11 11111111 1 1
"""
The combination of this a
the un it layout in the sa~ ge a~.d the ~ext page shows
P.C. Board. e con ,gurallon as the actual
• B-BAND UNIT
'\\
I
I
---,/
"
1SS153 2SC3775 3
(Symbol : A9) (Symbol : OY3)
5
D1
'" 0 2SC4315
(Symbol : MK)
3SK177 U73
(Symbol : U73)
.,.,
'"'"'"~
OOl.1.(C 1¢'1 EM.1n(11t
,,
0 01 02
RN1404
(Symbol : XDJ
03
', ~;§~l~
~ , g
I I I I I J
.
I
7 - 10
• MAIN·B UNIT (BOTTOM VIEW)
.
I&)., lli'!if
(
D19
ii' ij i 8~I '
ti ~ ~
g' t ~ I ~ ; ~ §i I ~ • i I i ~ I•
I I I I I I· I I I I I I I I I I I I I
"'~,
7 - 11
• PLL·B UNIT
,..,.
-$tul'\IJ
- °""'"'
.....
'''''"
-<><
,... -
"i - X Cll.11
.... -
--
- rn
-.) ...
... -
""""-
~e
"'°' - •,
~i
.m .m
(SymbOI: LY) (SymbOI: CBG) (SymbOI : LY3) (Symbol : XY)
··~m
( MfH(JI
COl.l(CfOfl
~
t.,,un(R
OOlt..EC IOR
~
(M ITl(A
COU.EC10R ==~
..,. .. "'"
03 02 05 01
RN1404 RN2402
. . fr . . fr
(Symbol : XO) (SymbOI: YB)
O,unER ( MtTI(A
06
• VCO-B UNIT
""""
,,_
"""
'" -
.... -
'1
"''" - i
cw -
-·m
( MIT'T(II
001.lE.Cl O-. -=~
O""'I N
(l....l ( ==~
-··
~ Al (
=•fr
( MITI(I\
[i COuECfOfl
03 01 04 02.05
7- 12
SECTION 8 OPTIONAL UNITS
-
.LN~ .l~q TX,RX:5.5V
,ti ""
C6 I IN• 18 ,I
II
C4 ocso .!.2 voo
R MUTE OSCI
9 ....
IP 2 IN-
St/GT
11 11 - '
TX,RX:OV
-13
NC NC l!..
.. 3
GS ESI
16 , T '
Ct
I\ 14
R4 vss
7
rn
R2
IOOK
• V REF SID
15 R3 330K
14
o.,
' 15 R3
Cl
6 5
8/H 04
13 /
'' 16
17
R2
Rt
C2
Ct
5
• / 7
6 PO
7
8
OSCI
03
02
12
II
V
V
18 3
-19
NC NC
2
'D'
' "
OSC2 01
10 V
:,S .....!
J""'
XI
rn 20 TONE
co XMIT
voo I "1
I") -
CR-288
o.
(S'~
/7
VSS
ICI
TOE
r
TX,RX:5.5V
.,~I' LC7385M
IC2
LC7366M VOJ ... ..
..
Rt C5
IOOK 0.1
0 ,28i,He /
4.4V ' "-
-1 '
...2.OS
8
TX,RX:OV
O.GV M_~
..!2 O'S
vss
04
7 rn 11 ov
JI
--' -
6 )1 5V OET
,,
II
08 03 '
-=
12 5 )1 J STSCD TOE
07 02 TX,RX:5.5V V '
13 4 DATA 01
06 01 (
14 3 CK -' - 02
15
05
OE
CK
DATA 2
OPTO -' '
= 03
16 GNO
J
' 04
voo sTe
I n (
,._ OTMF' n -
'-
S10
,>
. "' "'
• er Q
17
l~.; IC3
~P04094BG
C7
17
+2·'
-
8-1
8-2 UT-66 VOICE SYNTHESIZER UNIT
••
2,2K
CII
0 .-0\
l ,,_ -
l vo C6 ~ .1 J
R5 27K
. . A ., ~I
VOJ 08.l
VO
••
47-0K
"
~
"' ~
OUT
21 " l ~K ~.·?' . . ,; 05
M LPF'2 20
....
"
R7
22K '- 2SC4l l6Y
E LPF'I
19
"""
5.~v
/ 38
39
vss IC2
vss 18
17
r: 7
/ 7
14
IC3
TC4S66F
I I
I
&.6V
JI
43
SEL2
SEL3~ a.
44 SEL4~ :, > > ~
TSN
TS
13 I
lt11 V OIC
-" - UNIT$
:1 I!? ~~t~!ti
(l)~-N..I
vT7 ~ &.&V
117 CK '
&:~ "
--
! '7
R3
~K
.. ~o· :
ia :RJ
I I
IC4
TC4S8IF
I ~1 DATA
--
-
'
'
-
BUSY
ST8SP
I '7
'' v_
.. g,
XI
- CS8
800J'201
~
~
~.. 8
V -
1
01
2SAl586Y
r.'7
02
OAN202U
r :- :, '*
I - ' I
I ~
L:. :J
I vai
..g "'g
.. " >
~
0
/v -'
t; ~ " "'
"
"' "'"' l:!
..
>
"':,
" 0
..
8- 2
8·3 UT-67 TONE SQUELCH UNIT
......, ......
, , ouv
,c, .,.
...,
,- ..
... ~ - ~I
TC4 SV6SF
~-~
dJ
06
O,OK
....•, ov----- I I
I
I ,,
I ?
2SC4 08IS
1m,.
.."'"
'"
>OOK
..
'
•
"'
•• oi•
ill l o3 •
,J, L 01
.-
fir 80
IC2
FX-365L.G
J.!.-..1
,, OTCt44EU
I
UOLV
r ---,
..
._t>Alt202U I 1
•
IC I
FX..36!iLG
OTCl 44EU r.?
'
-
ov ,__ I
T
.,,
.
l
,. ' I •
I , •I
,. '
•
,.,' "
'- - - .J
•I •
...,. O•
2SAl362GR
I 7
i2e
r.;
-e
,,
~ .sv
I ...
,OOK
••
I 7
r.-1
••
•n .,,... o•
ZSAl362GR
...,. "
Mlll$12t
r - .10.UAU
•I I $l8TV I I TSOLU,0(.1'11 STBTV ""':"
I .g I ... I
,.
I (:,CU 0 .lU.V -
0...1,.v •-
.'
I
'
I
- "" I
I
I
I Sf TU
$TITU
TOH(
-
L_ ...J'
I C<v OEfU ~
., otTV :::
.IUJ$1tl
""' -
OAl'MI
"'"
,,v
Ulilll '"\
fSOLU
1,0LV
8 -3
SECTION 9 BLOCK DIAGRAM
DISPLAY UNIT
I
I
I
I
I
I
I
I
I
I
,/ \, I
I V
I
I
I
I
i
vv
I
I
11<~:t+-----+--~--t
I ~,::1. I"
~.=
I
'
I
I
I '----f---l! IC3~~ L_
I
I
I 011 RNl404 I
----------..I
H
Jooiii,MMOMER..----,<1----0~ 13.SV
~!~~2 [ I vi SQL.CTRL I
Qj! zae%7!2 ""•"'••"'·------,
O!M! ~~ ~ IH--+-~---:;------+-,j>------+-+-----
·v
------------1
Ora
2SC2712
SCII.SV
SOLSU
PTTCTRL
Q3 2SC2712
~ STONE
D2 ISS193 VSQLI ;:;:,.
,c,
CPU
vsou::: j
-··
Hl>4°"1019 V
--" V VOL.I
••c UP/tlNCTRL ~ I
UP/OH:
O! !ffn404
02 2SC27!2 _,::: I
I
------~~-r
V
I
I
I u voe,
L--'--<J-S.-""'--------------"'''------!f\:tie.~:;.;~-
2SC2112
'-----------, " -
I
I
~ :~~ I J
,c2~sw.R JK1-+·•~v_ _4 _ i - 1 ~ v ~ = = - - - - - - - - - - - - - D ,
i .
•>v I
I
I
I
r
... SR<V uvou
V
COMPMATORl-
•'4
RA.I LA6393M
1 .... Sftf'U
KEY MATRIX
D~7f~::i:~8, I/A-~~--.._, lHlTIAL
r---------...,
OTMF 90ARD
"""'
SQLSV
A
:::
,..,.. MATR!X L . . - - - K . I• OTMF !~ ! OET :::
----.?t I
11
- SQLSU
-
0,0 - V
~f
'7
BEEP CTRl
L _________
!
_J
DTMF
-
!Cl TC4S69F
05,06 SOL CTRl. I
2SC27l2X2
DATA BUS
022,023
2SC33Ux2
f--------,
I
>
I
i--------
p-·- 1 AA/\_AAAA
I
I
I
11 I I
I BIAS SE1.
I ON,025,026,027,0'2,Q:M
I RNl402•6
I 028,029,030,031,033
DT8123EKx5
17 I 022,023,DM.!)25
I 1$$184Jt-4
I
I
I
I
I
I
1•
J
r-...l rc?"i.~~ss I .....
SHIH 'ft'.61ST
..,."'" ,
~ 0281SSl93
023 IMD6
+W REG I
UV!/L/ A::41 If-+-+-----------
UVOL2
LOGIC UNIT
LPF
IClb
~
~-------~-,.,. gi 2:~m
LOOPFIL
IC2 TC4S66F
03 2SC2712
06 ""2402
....~.
,
tSS155d
RX:l 18.IOO-t&6.800MHz
AF UNIT 422.800-4!2.IOOMHz
TX:140.000-150.000MHz
11.mA,USA-HI
RX:126.800-130.IOOMHz
DET'S MUTE
PLL-A .. 12,800-422.IOOMHz
TX; 144.000-148.000MHz
IAUS,AUS-HJ
07
2SJI06 UNIT RX:118.800-156.800MHz
41UK>0-422.800MHz
' I
I
I
TX:140,000-ISO.OOOMHt
ISEA,SEA.-HJ
126.800,.JH
!EUR,EUR-Hl
111.800-156,1
trTA,USA,SEl
I
I
'-----.i~ >----------~ 12'.800-130.
(MIS,AUS-H)
I 07
I zsc,rn
I
I
T8V REG
QI 2SC2712
02 2SAl73o4
- .'''""",....
019
020
T8 CTRL
...
S/ffF METER
ISS193
NOISE FIL
BIAS SEL
025,026,027 ,028, Q33 NOISE DET
RNl402:XS SOL SW
QIS ZSC2?12 012 HSMHAS
029,030,031,032
RN2427x 4
025,026 ISS181 • 2
D27 1SS1t3
028 ISSUM
X,
30.39SMH1
D
111160-115.ISOMHI
IEUR,EUR-H)
10&,160-143.ISOMHz
!?TA,USA,SEA,
ITA--H,USA-H,SEA-HJ
113.150-117.tSOMHt
IAUS,AUS-HJ
S/fff' METER
D21
ISS184
.
2SC3172
RX:3H.ll50-409.15CM-fl
111100-115.150MHI
TX:430.000-440.000MHI
!EUR,EUR-HI RF SO
I RX:3H.150-44&.150MH1 Dl3MIN2
- ....I 100,150-143.ISOMHz
TX:400.ooo-479.000MHi
IITA,ITA-HI
RX:409.l&0-419.l&OMHI
105,100-143.lSOMHI
TX:440.0C>0-450.000MHI
!USA.USA-HI
BIAS S8..
024,025,026,tn1',032,034
RNl.o2J.6 LPF
.,
399.lso-.ot.lSOMHI
028,029,030,031,033 IEUR,AUS,SEA,EUR-H,NJS-+t,1!.tn,t)
DT8l23EKK5 389.150-448.1SOMH1
D22,D23,D24,D20 IITA,ITA--HI
1SSl8'b4 409.150-411,ISOMHt
XI IUSA,USA-HJ
CR-323
12.800MHz
RX:399.150-409.ISOMHz
113.100-117.IIOMHI
•SV8 REG
O!I 2SC3661
02 ISS193
PLL-8 TX:430.ooo-440.000IIIHI
IAUS,AUS-HI
RX:391J50-409.150Mtfl
"""CTAI. I
I
MOO MUTE
ICI
I
TC4S&&F I T8\I REG
•W 01 2SAl362
I 02 2SC2712
I
I
I
DC "'p I T8 CTR\.
06 291(209
07 2SA1182
VC0-81
iL .,,,.,"""''
______________ J
UNIT i
.
2SC240711C-2410A/E) ,t,TT CTRL
...
MRF559IIC-2410HI
06 tSSl93
,04,05
ANT SW
Dt Ml308 LPF
ISS153d IIC-24IOA/£1
Ml407
......
CIC-2410HI
D2J,D22
126.800-121.SOOMHI
IEUR,EUR•Hl
118.800-IM.IIIOOMHz
(TTA,USA,SEA,ITA-H,USA-H,SEA-Hl
126.800-130.&00MHz
(AUS,AUS-HI
'"
11,PC:55862
POW CONT
--------jf-----+-----------------<IMETERI€---~
IC3•
...
F
144,000-146.000MHI
430.000-440.000MHz
!EUR,EUR-HI
13'.ooo-174.000MHz
~.000-479.000MHI
....,,......
(ITA,ITA--H)
RX:136.000-174.000MHJ
351(1.0 RF SW TX:140.000-JGO.OOOMHz
Dt9MM62 440.000-460.000MHJ
!USA,USA·HI
144,000-148.000MHJ
430,ooo-440.000MHJ
!AUS,AUS·HI
ltX:136.000-174.000MHz
TX:140.000-lGO.OOOMHz
430.000-440.000MHJ
1S£A,SEA.~HI
412.800-422,SOOMHi
(EUtt,AUS,SEA,EUR-H,AUS-H,SEA·HI
392~1.IOOMHz
IITA,ITA-HI FAN
422,800-432.SOOMHI
IUSA,USA-HJ cnoL
HPF
FAN
'"
~PCl61&G
13.ev 021 RD5,IMl2
1 ~~ ~--"_,t.:_'__
LA4440
<l_mt
~ ~UCOMAF:"OUTOUT
MAIN-A
UNIT
MAIN-B
UNIT
113.l&0-11&.ISOMHz
{EUR,EUR-HJ
I0&,1&0-143.150MHI
UTA,USA,SEA,
JTA-H,USA-H,SEA-Hl
113.150-117,ISOMHt
!AUS,AUS-HI
........
RF SW
Dt4,Dl5
RF SW
016 MM'l62
"IEIJR,AUS,SEA,EUR-H,AUl-+t,IUrlf)
399.l,o-«19.150MHz
3fi9,150-448.1501)1Hz
IITA,ITA-HI
409,150-419.150MH1
IUSA,USA-HI
.. ,
D9,Dl8J)l9
Ml308Jt3
LPF
ATT
CTAI.
<}---TX,RX
9-1
SECTION 10 VOLTAGE DIAGRAMS
MIC
-!:;:: 1
MlC
MICE
MICE
POWER
•BV
~
;::
;::
POWER
,w
SIIFV
.• R7 UIKlEUR,EUR-IJ,USJiEA)
4.71<tUSAI
....,
SIIFV
... -
;:: r
...
SRFU
iE~
~ "
,;
I ~
i1i
~ -1 !i
~~j
t~
UWl.2
W0'-2
UWI.I ;
+-~
v• :~~~/ ',
WOLi
;;
"""-2
;; """-' 03
WOLi
;::
UWI.I
STONE
'" "
I 2SJI06 tx,AX:1.0,
,,....
STONE
;:: ST8SP
STBVHF
STIIVHF
;;
...
STBCOM
STBCOM
ST11UHf
...
OTMF
;::
-
~
;;
STBUHF
"™" Tx,RX:2.3V
D£T
;::
D£T
13.SV \
13.IIV
.... ,""...
RI!
TX,.RX:2.«Y'
C! !
• f
TX,RXJO.W ffl
. ro .
' ,I ""'~dlsl ~1r·l ISH
1 J3
~1
~-
~1
~-
~
1817116115114113
~
~
;;,
- STSTV
DATAV
'!9 ,!.! ;;, -
,-.-E
~
ICI ~
e!-
-
;::
-
;::
STIITU
TONE
FX-36/!ILG D£TU
r;1,r1· ~
_El D£TV
24
- .- -
;:: """
I
OATAU
I;:: ;::
l.
Cl<U
- ..v
;;, ;; UNITT 09
;;
IOOH
- ...
;:: r'7
-.
TSOLU RNl404
I ;:: TSOLV
: ~~ -
1
?.vnc::;I
C4220P
TONE UNIT
,:..
~ - 1,;, ~ rx.RX:.uv
040
IOON UHf
sot.Of'Ett:
SOL CLOSE:
I
C3 220P
TX.AX:5.AV
(USA only)
S1'8SP 6L->-+O-AT_•--+--1-+-+-.....,
LOGIC UNIT ~~
BUSY 6 ::L>-+C=K~-t-+--t-;--,,-.,.-,--,-,--, :~ac.-
1'-1-+-+--r'~~=E--+---+--~ ~ I
VHF
SOL
SQL
. ,-.:!!
0 0 D£T
,,..,
DATA
0
0
0
0
0
.
TOE
Cl( 0 01
.,
UN!TO
E
0
0
0
0 .
OTMF
~
0 0 STD
=:F /
... - ... :t::'£~ L-------------+-
J2
I rflTS.X.V
TSQLV
TSQLU
UNITT
STIIPLV
-
--
TSOLU
UNlTT
STSPLV
,.
'·"'
UNITS
UNITS
SUSY
BUSY 020
;;, STBPLU VHF 2SC3326
-;::-
-
STOP\.U soi~1:o.1V
·1
ST8TU SQt.*2tO,JV
-·
STSTU
STBTV IOl.."'3:0,IV
STBTV IQL 0,£ff:0.7V IK r
"
U:.OL2
USQLI
- VSQLI " USQLI
o------t-o-t==~---J----+---t-1c-t----, "
VSQLI
VSQl..2
- VSQL2
021
2SC3326
-
;::
...
··l
OATA
. .TA
CK
Q(
v• 1K
UIIU(U
~
-
UNLKV
SOLSU
-- UHLKV
SQLSU 022
2$03326
- SQLSV
SOLSV
2J '"
"1 023
'·"'
-~f
2SC3326
v•
SQLU
J,
- STIVHF
..,.
CK
:::'.
':' .... -
-- _,,
UIRX
SQLV
':'. -
... ._ 0: ....,,
D<TV
m
::~S
Vd
,~
tt.RX:e..ov
/R30 CZ<l
::.
- ""'
"-UOU<V
-
.......v
04
RNl404 !OOK
,m J ,;
--..--,i;
' '°"" '" - ....,,•OV
~:UV
TX,RX:5.&V~
'
--
' t~
!~
....
RU
1' ;~
.
-
rT)(.ftX:4..&Y
...
O_,!
C31
o.,
....
, _,__ DATA "U
STBPLU -----":
- A<
~
-., 012
C35 r'l )2SC2712
0.1
- ~- ........
13.8V -~ ..__
.__ 1---
.. '--'
TIC:OV
'I
RX:t.tv
I
...'"' 1~- X,
co
J~ 12 11 rol sl VHF i!
.,. " SOL OPEN: OV
~ / S0LCLC>SE>0.1'V /7 H
~ 14'f~--- -
R74
... I G;').- . . . . .
330!(
C4f RS!!
S
J._ ~
VHF ~; TXJtX ·4.4V T Q.J
""'
iy /r jt11 !
-SOL ONN:5,7V
SOL cl.00£,0V o., ~
Tx,RX;0.8Y
017
2SC2712
SQ<V I
1 ~ · - - ~5 r
ID) 01s
r---...-----..ll
'C 2SC3326
,---
rt,
""'
rf, rf,
[[ i'Ql6
J
020 "l +
2SC332S
i! lo, !a 2SC3326
~
..." l
_J
l!SS2.26
s~:iz· t~
I
r.
~ R13t
r ', r
021
2SC3326 '" '" AF
100
I
...
" ,J .. le.
,
,,.
RIOO
rv l 024 -
....
UNIT
022
2SC3326
.., IC4
TC4S81f
';J
,J
'
i~
.
ci •
'C 2SC3326 STIIVHF
CATA
I 023
2SC3326
""'
l I
~
r.
rf, V3RX
L -·
!n,_
-
MAIN-A UNIT
-- :::
CK
-- -
..TA
:::
:::
- "''" UIRX
::: SOLV
::: SRFV
-...
STI!f'I.V
- = - ""'
--
30V
:::
-= -
UNLI<V
- - •SV
--::: IMV
AFV
;: '
AFU
.
-
-- --
"'
:::
:::
-- -
;:
TX:OV
-u R)C:7.tV
~t ~ ~o
::: TX:0.7\1
AX:OV 01
\ 2SC21
'
-:::
_.;::
-
T
G
....,. ~.,-.--------:'.s.....-,.---,t-.-1-~--------~·.·,---J~V,~/'v-.. ~~
:d ~ -«>
2SC27!2
8f~v~o
·1 w_~'L_·:,
---- i~ +- ~712
~~ lt! ~ ~~
rt,
n .,..
;ot X i~
Rl47 - ~2 015 ~ r '1
SQlV IOK 0TH-T~71l$ ~., 2SC2112 ~
:,! Cl9:S
I
'--------+---------------------------------·+---l--1----l~~
~,
....
032
""2427
~ ...
TI<,
...
r--'1111/H=~'---------~· 21 :s 4 15 • 7 !L 028
;-·~~...-~
DATA I rn RNl402 ;.8
V!RX
TX:OV
/RX:tf.4V
- ~ •h
;h ,lRNl402
uorf, uorh
-
-----,
. ,
220
TX:6.0V
I
fflGH:UVWE/HJ
L.OW-1·4..ftW£J ...Vffft
...
IRX:1.0V
VCOQA
I RVCQA
-~·! I TVCOA
.....
LVA
r."7 """'
MOOVA "''
I
I
I
I
/J. TX,R>:>.OV
I
I
2SC3772
i___ PLL-A
!t:!!_.J
I
019
3S!!._40
RI!
47
.,,
'·"'
.,
112,
,--.-, ....
I I T
.......
L __-:__J
I
...
,r-
IK
ti-· I,},~-
rx:o.sv
·-
100
Cllll
··"'
RX:0,7V
03
~I
TX,RX:8.IV- _.-.
!
QI?
2SC2712
...•• Tx,RX:l:S.5V
11 ~I
Cll4
0.001 ,:--1 r'
.. ii I :::: I e
r,',
I
., \ .........
L.:-_J ~
>---- TX,RX:4.2V i~
ri i;
c1!;-J,
I
/17
024 .... 1ss19:s
I
tx:OY
/ffX:~ ....
IOI<
A93 IQK T e,oo
{ ,-.:-1 CtO:S Ll9
..
.l
O.OP 0,11'
, LS-291
l ~;zj
CK I I
J m.
>-- :~
0.001
.....
L_"'...J
'" l'~i s 1~~! ~I 1o
~~ J
....
r i!
~"]
n i~ (!7
r~ ~
0
] mov 7 88
RX:r.ev Juo
~ ' TX:15V
RX:7,!JY
~~1
022 Rll9
2SC3772 IOK
~I
·~
00
.. ,,..
Cl27
Ct28
"
,}, C!24
0,00, r~4~~
I
I
k--1 ~~
w,
I
J
"' t! I
~! I ANT
I HV
.-..
ii~
I -~~g:v
I
[
Q!]
I
.I I ;
.-.. "·
I
I
~:!
-
f ·1I
___ J
1 ..
...
-
......
IN
...
-··••
...
220K
-,.
MAIN-B
UNIT
....
'""
Cl09
!OOP
TX:OV
....,..T_ __.:../_._.'"'" I
CHASSIS
UNIT Pl JI
10-1
OSI FTD-1003MCH
ICI
LC7912A
~::
~ ~
Hdh~IU
"" ---+-+c=!!-t-------l-
"" =--+--+.-==1-
DISPLAY UNIT
a,
"" ---+---=c=+-=---+-
r--
!9
st
..
r-'8'1
.,
• r'!!i SIO
..
r'i ,., .,.,.,. I
,,..
9
~~
I
:1v- I V ,..-
: tm,SOLI
V , ......... ,
I ,_II
...,. I,... I
IJ,
'"' """"I
s;:.a:1~11s~,~----.--+---+-1-~
""""j
. . m-
-.-. · . ,..... 5 5 5
i f:~p,
S7 : :
/ !~~~g.~!!~!BX
1-,;;~..J I ii i
"""
47K••
.......__!IIOI
'
r7i i i ......,
~~
"'"'='=..++-t-+-+-<>-+-+---9' -
.,-==+-t-+-+-<>-+-+-~''I= ""-"
: l9llff
"'"'~·=--+->-+--+-+---''I•• """
I I Ill I I
t'""?=+-t----+--+-~'9••
~ii
I I I I
l ... L'.:'.J
t'"''c'C.-Wv-t+----+-+---'''l•• 1. 15
""
,
1142
,]!Sim
j
1YDU1"
11
I
1143.~---µ
1
D1•IS81III
4.IV
~-="'-"'>----+-+---'I' .,
=------+-+-~•....
~--------+-+--__..,,, -
---
~--------+-t---9""' ""
"""·~·-f--------.-""'vv.--..
Jlf1UIJ1 ~--------+--+-----'''!'""
~ - - - - - - - - + - + - - •.. ,..
~--------+-t---"'11:S lt.t.l
"' ~
""
""'"'~'-1-----o-+-=-vv.--..
.......~-+----+->-+-+-==---
',;;;;;"
~-------+-+----"I" - """'"~+-----.+r++-==--..
I 151131
11
1NT0 .., .."~-+--~
"°.!!...__
"'
"""'~'-f---.-+-t-+-t-+-""-'lv.--..
~,::1
...
-•= I ..... ,,,l. .......
'
h; sl :::7
'Ii~~:1',: ,ii:-111:-:·:~:~~~::::::::::::::::::~-+-I-'-
ilUilB!haiH
'·"'
IC4-b
~.-~f
IC4 L..UD3M
- ~~===~2...."'1""Q.,.,;,1;..,:;,
,.. .]If.
·-:s-1 "'""'
..
'
-~ ""
""'
I
....... '
IC4-o
... ~·"'
=•"'
R7147K
111114.71(
Rft4.7K
u
'
u i ;
e
l
! !
l l
:0
i
MAIi
.-+-t---Hf-----~=.=·--Q~
- ..-++------~-~·-o"
- """'
=
''" - ..---, ""
iJ!---!!!-
~
~
~
~
"'" = ~-
~
~
~
~
~
"
.. ;:: 1iJ 11
lNIH
t!l
""TX:OAV
J........-"!.-
~
~M~IsJ~l~l!
c!r:
~ /RX:O.SV
-'--------"'-- ... - 6
~ 03
.!____._--"L
II
2SC2fl2 6 ~ ~§ U!
/7 ~ g:v Is !
" ..,
r~----~ -
-,-,
"'""
~
..
- IMU
., -_ ,_
,_,
... ~
'"
Ci 111•
TX,RX:3.2V'\.
'"
= = ,_
= ,_,
......
-- ,_,
-= ,~
DISPLAY UNIT
-- ""
--
-= ."'"...,
0-r'-;J,
.,... I~
Hi n1
'"""'
......
'"""'
§1tfi1'
. . .
l l l
- :1
:D
~:O.OV
!
I I i
.nnm "" r. r i ......,
V VII/. .... "'"'
""-"
~~1~--~-- -.,
_.
IC>
it=-i~-----~
..,,..
iffi
M:S 42
... ...
-
... .,.,_,-f-----o-t~=---+
~
1.
"""""''"""~+------~~---+--+-+--+-'
.,.,-,"~-+----+-->-++-==----e
·1 ~1i......
-. __
15 C
1
r>
, /TX,IIX:11..W
s ~~:~
,
..,,-,"~-+----+-+->-++-==----e
... .,.,_,-f--...-+-t++-+~=---+
, TSOl..v/:F-
... I'"'--+--~ '"'"
,,, ....__ ii """
..
ll80 .!!.._,-- 471C•S
-
ST.-LV
.,,
...'·"' ~II
2SC2fl2 """
ef ·"'~
1""'
p
"'
"" ""'"
""'"
......
moN
."
-·~ e, n iii ""''
_,
'"''
....
"
.- f?
i _!
~
"'""
~ ......
~
"""
LOGIC UNIT
r
MAIN-8 UNIT
s, ,lL.~ ~.
00
..
,
r~-----,
1..--tw-..J m
~-+-!H-+-+--~---------~-------t--+-------~~~
i=t L= ~-~
r
§~ • ii>-
'--+----------------------- ~::I 1- i!
~r
-
~
~---o~
rf.
--
--
1il
-
-
T
i
Fi
10-2
lcom Inc.
6-9-16, Kamihigashi, Hirano-ku, Osaka 547, Japan
Phone: 06 793 5301
Fax : 06 793 0013
Telex : 05277822 ICOMTR J
<CustQmer Service>
Phone: {206) 454-7619 !com (Australia) Pty. Ltd.
AC.N 006 092 575
<Regional Customer Service Centers> 7 Duke Street. Windsor, Victoria, 3181, Australia
18102 Sky Park South, Suite 52-B, Irvine, CA 92714, U.S.A. Phone : 03 529 7582
Phone: (714) 852-8026 Fax : 03 529 8485
Fax : (714) 852-8716 Telex : AA 35521 ICOM AS
1777 Phoenix Parkway, Suite 201, Atlanta, GA 30349, U.S.A.
Phone: (404) 991-6166 lcom (UK) Ltd.
Fax : (404) 991-6327
Unit 9, Sea St, Herne Bay, Kent, CT6 BLD, UK
Phone: 0227 741741
Fax : 0227 360155
Telex : 965179 ICOM G
!com Canada
A Division of !com America Inc. lcom France S.a
3071 #5 Road, Unit 9, Richmond, B.C., V6X 2T4, Canada
Phone: (604) 273-7400 Zac de la Plaine, Rue Brlndejonc des Moulinais
Fax : (604) 273-1900 BP 5804, 31505 Toulouse Cedex. France
Phone: 61. 20. 31. 49 Fax: 61. 34. 05. 91
Tele< : 521515 ICOM FRA
lcom Inc. A-5153H-S
6-9-16, Kamihigashi, Hirano-ku, Osaka 547, Japan Printed In Japan
Copyright © 1991 by lcom Inc.