Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Unit-1
(b) Discuss the importance of back and side rake angle. (7)
UNIT-2
3. What is taylor’s equation of tool life ? Discribe the mechanism of tool wear. (15)
4. A HSS tool required regrinding after 3 hours and 20 minutes when machining steel at a cutting speed of 40
m/min. Calculate the tool life if the speed is increased to 70 m/min. (15)
UNIT-3
5. What is milling machine? Explain various types of milling operations with neat sketches. (15)
6. A 10 mm dai. hole is to be drilled in a block of magnesium alloy. The feed is 0.2 mm/rev. And the spindle
speed is 800 rev./min. Calculate : MRR, cutting power amd torque on the drill. (15)
UNIT-4
8. Explain the principle of sine bar for the measurement of taper plug gauge and explain it and draw a neat
sketch to illustrate the use of sine bar for briefly. (15)