Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
These are pulled from the top of my head, and I've tried to keep them platform independent. Obviously an
interviewer will also add specific platform-dependent and database-dependent questions. They'd also be interested in
knowing correct answers to architecture questions that they use or are interested in. A good CNC interviewer would
probably also throw in a couple of development questions and functional questions as well, depending on the level of
expertise they were looking for.
Also, the above questions could have multiple good answers - it would be important to the interviewer to see HOW
the candidate answers - not necessarily whether their answer matches the interviewers answer. A very confident CNC
specialist should be able to identify what alternative answers are available to the above questions.
I've been known to run CNC Training Workshops from time to time (!) - and in that workshop I usually have a "final
exam" - something that JDE doesn't do in their training agendas. In that final exam, I expect my passing students to
receive a certain passing average - and I've never seen below 70% after a two week course. Believe me, my exam
questions ain't easy !
When I was at JDE - I was asked to create a "certification" procedure for OneWorld CNC consultants and to oversee
the JDE Certification for CNC. This was a relatively shortlived process at JDE (it pretty much died just after I left), but
while it lasted, it really identified the wheat from the chaff ! Its a pity that Oracle don't have a similar procedure.
Anyway - others might certainly have different questions - but you should be able to gauge your experience based on
answering the above set of questions !