Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
5 INSULATING OIL
b) For transformers of capacity 50MVA & above, the supplier shall dispatch the
transformer filled with Nitrogen. The Bidder shall take care of the weight
limitation on transport and handling facility at site. Necessary arrangement shall
be ensured by the supplier to take care of pressure drop of nitrogen during transit
and storage till completion of oil filling during erection. A gas pressure-testing
valve with necessary pressure gauge and adapter valve shall be provided.
c) For transformers of capacity 25MVA & below, the Transformer shall be supplied
filled with oil.
d) The quality of the oil supplied with transformer shall conform to the oil
parameters specified in this clause.
i) Prior to filling
ii) Before and after heat run test
iii) Before energizing
h) Sufficient quantity of oil necessary for first filling of all tanks, coolers and
radiators at the proper level along with 10% extra oil by weight for topping up
shall be supplied in non-returnable containers suitable for outdoor storage.
i) The Bidder shall warranty that characteristic of oil furnished shall comply with
the requirements specified in IEC:60296 with the latest amendment /revision
and shall be suitable for EHV grade transformers.
j) The bidder shall submit valid type test report (conducted at ERDA/CPRI)
of the oil to be used in the transformer.
ELECTRICAL:
5.6 Core
a) Material to be used for the transformer core shall be made of prime grade
Imported Cold Rolled Grain Oriented M4 or higher Grade (CRGO)
laminations and not from second grade steel laminations. Only those bidders
who directly imported CRGO either from the manufacturer or through their
accredited marketing organization of repute (and not through any agent) shall
be considered. In support of this requirement the bidder shall submit an
undertaking in specified format (schedule B3) in the form of affidavit on
Rs.100/- stamp paper, duly notarized.
b)
c) The core shall be constructed from high-grade non-ageing cold rolled Super
grain oriented silicon steel laminations.
d) The design of the magnetic circuit shall be such as to avoid static discharges,
development of short circuit paths within itself or to the earthed clamping
structure and production of flux component at right angles to the plane of
laminations, which may cause local heating.