Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
When you travel by airplane, roughly speaking, baggage which you carry is divided into two types. One is carry-on baggage and the other is checked baggage.
'Carry-on baggage' is the baggage that you have or carry on the cabin of an aircraft. 'Checked baggage' is the baggage like a suitcase that you would check at the airline's
counter before your boarding.
Under the Civil Aeronautics Act in Japan, Dangerous goods are defined as explosive materials, flammable items and any other goods that are liable to injure persons or to
damage objects. The Act prohibits the transport of those dangerous goods by air and the carriage of such goods on board as carry-on baggage. However, among such goods, there
are certain goods which you may be allowed to carry as carry-on baggage and/or checked baggage in case they meet certain quantitative limitations. Besides, some sharp objects
such as knives may not be allowed to take on board as carry-on baggage for the reason that it may be used as weapons for hijacking and terrorist activities.
The list below picks up items that passengers often inquire of airlines whether they should carry them on the cabin or check them in at the counter. Please check this list when
you pack up your belongings on your travel.
At airports, airlines perform security check before your boarding for your safe travel. Please inform airline staff at the counter or the security checkpoint in case you carry
dangerous goods.
Please pay attention to the following:
1.In general
○ The list below is based on the Civil Aeronautics Act, security-related rules provided by the International Civil Aviation Organization (ICAO), and some other related regulations
.
○ In spite of the item listed, there are cases of additional rules by airlines, so it is recommended to ask airlines whether your concerned item is categorized as a dangerous good
and about other details.
○ Please note that other countries may have additional rules and restrictions on dangerous goods in international flights. You should check with your airline for more information.
○ The item permitted as carry-on or checked baggage are for personal use only.
2.The items that can be used as weapons for hijacking and terrorist activities
○ This restriction is also applied to the tools, sporting goods and self defense items that can be used as weapons for hijacking and terrorist activities.
○ The imitations and similarities of each dangerous good are included.
○ It may be determined that even the carriage of an item which is permitted on the list would be prohibited because the item is categorized as a weapon due to its
characteristics, such as materials, strength and shape.
○ It may be determined that the carriage of an item which is not on the list would be prohibited because the item is categorized as a weapon due to its characteristics, such as
the materials, strength and shape.
○ Please note that the Act for Controlling the Possession of Firearms or Swords and Other Such Weapons and other laws may prohibit you from possessing certain items.
3.Dangerous goods except for the above items
○ Even an item listed below, it may be determined that you would be allowed to bring it in case the Safety Data Sheets (SDS) or other documents issued by manufacturers
characterize it as non dangerous good.
○ Even if Liquids, Aerosols and Gels (LAGs) are permitted to carry as carry-on baggage on the list, an additional restriction is applied to international flights.
※ Please check the following website for more information on Security Control for Screening Liquids, Aerosols and Gels carried on international passenger flights departing
from airports in Japan.
http://www.mlit.go.jp/koku/15_bf_000006.html
○ Even if they are categorized as permitted items on the list, it may be determined that you would not be allowed to carry them due to safety/security issues.
○ It may be determined that you would not be allowed to carry items which are not on the list due to safety/security issues.
4.Others
○ The list will be updated as necessary depending on operational circumstances.
Toiletry Articles <Non-radioactive material articles including flammable liquid and compressed gas (spray can)>
Quantity LAGs (Liquids,
Item(s) Carry-on Checked Notes Aerosols and Gels)
Quantity Per Quantity Per Restriction
Container Person
The toiletry articles are the ones used for the body
At or less or the personal appearance. With regard to the
than 2L or gas-filled sprayer, it is required to have a cap or to
Hair-care goods : Hair sprays, Hair tonic, Hair restorer (Liquids, Sprays), Hair Color, Hair dye, Bleach 2Kg prevent the accidental leakage by other
Skin-care goods : Skin lotion, Cleansing foam, Sunscreen appropriate measures such as a measure to
Shaving foam Note: The prevent someone from mistakenly pushing the
Nail-care goods : Manicure, Nail-polish remover, Nail art articles At or less above injection valve.
Bath salts, Bath Oil ○ ○ than 0.5L or quantity per Links
Mouth care goods : Mouthwash 0.5Kg person is the Note : With regards to the bleach and the ant mold,
Perfumes, Cologne total amount if it is labeled 'This product contains chlorine' or
Aroma oil of toiletry 'Do not mix, Hazardous.' etc., it is not allowed to
Antiperspirant sprays, Deodorant body sprays, Refrigerant sprays (They include the sprays for the clothes) articles, carry in a carry-on baggage or a checked baggage.
Air freshener, Disinfectant sprays, Anti-wrinkle sprays (for a body, clothes, a room) medicines,
Household detergent (other than a bleach, an antimolde) and sprays Note : "Spray" in the toiletry articles means a gas-
Cleaning solution (for contact lenses, false teeth, a wig, a jewel, eyeglasses, a shave) filled aerosol sprayer or a liquid-filled mist sprayer.
Medicines <Non-radioactive material articles including flammable liquid and compressed gas (spray can)>
Quantity
LAGs
Item(s) Carry-on Checked Notes Restriction
Quantity Per Quantity Per
Container Person
Note: The
At or less above Release valves on aerosols must be protected by a
○ ○ than 0.5L or quantity per cap or other suitable means to prevent inadvertent Links
0.5Kg person is the release of the contents
total amount
of toiletry
articles,
medicines,
and sprays.
Sprays (Except for ①、②)
Quantity
LAGs
Item(s) Carry-on Checked Notes Restriction
Quantity Per Quantity Per
Container Person
Sprays without using flammable gases or toxic gases.
At or less
than 2L or
2Kg
Note: The
It is also required to have a cap or to prevent the
At or Less above
accidental leakage by other appropriate measures
○ ○ than 0.5L or quantity per
such as a measure to prevent someone from
0.5Kg person is the
mistakenly pushing the injection valve.
total amount
of toiletry
articles,
medicines,
and sprays.
Liquid Articles
Quantity
LAGs
Item(s) Carry-on Checked Notes Restriction
Quantity Per Quantity Per
Container Person
Non-dangerous goods
It shall be placed in a retailed container.
Not more than 24 % alcohol by volume. ○ ○ Links
An alcoholic beverage, which is poured into a hip
flask from a retailed container, is not allowed.
Alcoholic Beverages It shall be placed in a retailed container.
More than 24 % but not more than 70 % An alcoholic beverage, which is poured into a hip
○ ○ 5L Links
alcohol by volume. flask from a retailed container, is not allowed.
Paint × ×
Pesticide × ×
Agricultural Chemicals × ×
Hydrochloric Acid × ×
Gasoline × ×
Thinner × ×
Benzine × ×
Varnish × ×
Ethanol × ×
Formalin × ×
Chloroform × ×
Arsenic × ×
The body × ×
Installed by electric-powered bicycle and
vehicles
Spare batteries × ×
Batteries b) Batteries used for a battery-powered wheelchairs or other similar mobility aids For details, refer to here.
Oil lighters
It is required to be on the person in the cabin.
With absorbent cottons If a cigarette lighter is powered by lithium
batteries,
・each batteries, must not exceed the following
for lithium metal batteries , a lithium content of 2g
for lithium ion batteries , a Watt-hour rating of
For smoking 1(Small and
100wh
Liquefied gas lighters Disposable、Refillable type ○ × portable
・the devices and/or batteries must not be
type only)
recharged on board aircraft
・It is required to be prevented from causing short
circuits.
・measures must be taken to prevent unintentional
Safety matches activation of the heating element while on board
the aircraft.
Disposable、Refillable type × ×
Ignition device (not for smoking)
Oil × ×
Gas × ×
Lighter fuel
Oil × ×
Oxygen Cylinders and Gases
Quantity
LAGs
Item(s) Carry-on Checked Notes Restriction
Quantity Per Quantity Per
Container Person
Other than those above × × Cylinders without gases are allowed for a carriage.
Portable gas cooking stoves and Gas burners for a camp without gas cylinders (the body) ○ ○ Cylinders without gases are allowed for a carriage.
Fire extinguishers × ×
Helium Gas × ×
Explosives
Quantity
LAGs
Item(s) Carry-on Checked Notes Restriction
Quantity Per Quantity Per
Container Person
Bullet Key Rings, Necklaces (Those items must be processed as key rings or accessories. ) ○ ○ Non-dangerous goods
Fireworks × ×
Crackers × ×
Smoke Markers × ×
Other Items
Quantity
LAGs
Item(s) Carry-on Checked Notes Restriction
Quantity Per Quantity Per
Container Person
Gas type × ×
A part which produces heat and the battery must
be separated, and the batteries are also required
Lithium ion batteries
to be prevented from causing short circuits.
*A watt-hour rating of not more than ○ ○
The removed battery and spare batteries are
160Wh
permitted as carry-on baggage only. (Not permitted
Diving Lamps as checked baggage.)
Non-dangerous goods
A part which produces heat and the battery must
Other than those above ○ ○
be separated, and the batteries are also required
to be prevented from causing short circuits.
Solid ○ ○
Substances/Items in the form of liquid with an ignition
Wax, wax remover for ski or snow board Liquid, Paste × × point at or lower than 60 degrees C (60℃)
For combustion × ×
Charcoal and activated charcoal
For purification ○ ○ Processed product only.
For transplantation ○ ○
Organ, Tissue, Cell etc.
Those items except for “Infectious Substances”
For research, or testing × ×
are permitted to transport.
Pacemakers and other devices implanted in the body or fitted externally which is activated by the battery using
○ X
radioactive materials or lithium
Balls intended for use in sports ○ ○
Mercury × ×
Isotope × ×
*The item can be transported as a
checkedbaggage when it meets all the
followingrequirements,・the fuel tank of the item
has never contained anyfuel or the fuel tank has
Internal-combustion engine or fuel cell device (engine, generator, etc.) × ×
been flushed and purged ofvapours and adequate
measures taken to nullify thehazard.・the entire fuel
system of the item has no freeliquid.・all fuel lines
are sealed or capped.
carried by passengers or crew for personal
use.spare batteries must be individually protected
Battery-powered portable electronic smoking devices (e.g. e-cigarettes, e-cigs, e-cigars, e-pipes, personal
○ × so asto prevent short circuits.recharging of the
vaporizers,electronic nicotine delivery systems)
devices and/or batteries on boardthe aircraft is
not permitted.
Instant ice packs × ×
Weapons
Swords
Plastic toys. etc which are not for weapons are also permitted as carry-
Swords (Japanese Swords、Chinese Swords、Western Swords etc.) × ○ on baggage.
Dagger × ○
Switchblade Knife × ○
Knives
Round-bladed and non-dangerous knives like butter knives are
Knives × ○
permitted as carry-on baggage.
Those items are not permitted as carry-on baggage because of the
Oyster Knives × ○
appearance by which anyone may have trepidation.
Round-bladed and non-dangerous knives are permitted as carry-on
Paper Knives × ○
baggage.
Those items for any kind of medical treatment (surgery,
Scalpel × ○ ophthalmology, dentistry etc.) aren’t permitted as carry-on
baggage.
Safety razors or cosmetic small razors for eyebrows are permitted
as carry-on baggage.
Razors × ○
The electric razors (electric shavers) are permitted as carry-on
baggage.
Those items that doesn't have a sharp point and also the blade’s
length don't exceed 6cm are permitted as carry-on baggage.
Scissors × ○ Cosmetic small scissors for trimming eyebrow, nose hair and so on
and scissors in the sawing set are also permitted as carry-on
baggage.
Those items that looks like obviously toy scissors are permitted as
Scissors for infant × ○
carry-on baggage.
Even if the component does not include dangerous items all-
purpose knives are not permitted as carry-on baggage because of
All-purpose knife (e.g. Swiss Army knife) × ○
the appearance by which anyone may have trepidation.
Cutters
Box Cutters × ○ “NT cutter”, etc.
Those items which do not have sharp point and less than 6cm are
Cigar Cutters (V-cut Type) × ○
permitted as carry-on baggage.
Those items that cannot separate the blades from the bodies are
Cigar Cutters (Straight cut type) × ○
permitted as carry-on baggage.
Those items that cannot separate the blades from the bodies are
Seatbelt Cutters × ○
permitted as carry-on baggage.
Those items that cannot separate the blades from the bodies are
Food Cutters × ○
permitted as carry-on baggage.
Those items that cannot separate the blades from the bodies are
Apple Cutters × ○
permitted as carry-on baggage.
Pizza Cutters × ○
Air Guns × ○
BB Guns × ○
Starter Pistols × ○
Those items that are not dangerous obviously by considering the
Plastic Toy Guns for infant × ○ strength and/or shape of the material are permitted as carry-on
baggage.
Because the parts might be separately brought and assembled by
Parts of Guns and Firearms × ○ several people in an aircraft, those items are not permitted as
carry-on baggage.
Shooting Articles
Those items that looks like obviously toys are permitted as carry-
Slingshots × ○
on baggage.
Bow and Arrow × ○
Bow guns × ○
Those plastic items that look like toys and so on and can not be used for
Baseball Bats × ○ weapons are permitted as carry-on baggage.
Hockey Sticks × ○
Lacrosse Sticks × ○
Those items that don’t have metallic blade are permitted as carry-
Boomerangs × ○
on baggage.
Those items that is for relay or baton towering and don’t exceed
Batons × ○
60cm, are permitted as carry-on baggage.
Sectional Putters × ○
Pool Cues × ○
Short skies that don’t exceed 60cm are permitted as carry-on
Skies/Snowboards × ○
baggage.
Those items that the folding size don’t exceed 60cm but the sharp
with metallic point (drill shape), are permitted as carry-on baggage.
Ski Sticks/Poles × ○ Those items that don't have sharp with metallic point (drill shape)
and are used as sticks by physically handicapped people themselves
are permitted as carry-on baggage, and may exceed 60cm.
Those items that the folding size don’t exceed 60cm but the sharp
with metallic point (drill shape), are permitted as carry-on baggage.
Mountain-climbing Poles × ○ Those items that don't have sharp with metallic point (drill shape)
and are used as sticks by physically handicapped people themselves
are permitted as carry-on baggage, and may exceed 60cm.
Pilgrim's Stick × ○
Climbing Spikes × ○
Tennis Racket ○ ○
Those items used by physically handicapped people themselves are
Canes ○ ○
permitted as carry-on baggage, and may exceed 60 cm.
Those items used by physically handicapped people themselves are
Splints, Artificial Arms and Legs ○ ○
permitted as carry-on baggage, and may exceed 60 cm.
Sticks
Iron Bars × ○
Wooden Swords × ○
Bamboo Swords × ○
Those items that the folding size don't exceed 60cm are permitted
Tripods × ○
as carry-on baggage.
Those items that the folding size don't exceed 60cm are permitted
Monopods × ○
as carry-on baggage.
Those items that the folding size don't exceed 60cm are permitted
as carry-on baggage. Those wooden or plastic items that are
Insect Collecting or Fishing Nets × ○
considered they can not be used for weapons are permitted as
carry-on baggage.
Tools
Those items that the total length don't exceed 15cm and also the
shaft’s length don't exceed 6cm are permitted as carry-on baggage.
Tools (Screwdrivers) × ○
(In case their grip and shaft can be separated, the length shall be
measured in the state the grip and shaft is connected.)
Those items that don’t exceed 15cm are permitted as carry-on
Tools (Spanners) × ○
baggage.
Those items that don’t exceed 15cm are permitted as carry-on
Tools (Wrenches) × ○
baggage.
Those items that don’t exceed 15cm are permitted as carry-on
Tools (Crowbars) × ○
baggage.
Those items that don’t include ice picks or drill-shape are
Tools (Portable Screwdrivers Set) × ○
permitted as carry-on baggage.
Tools (Power Drivers) × ○
Tools (Blowtorches) × ○
Including 100V power-operated, battery-operated, and
Tools (Drills) × ○
rechargeable.
Those items that don’t exceed 15cm are permitted as carry-on
Wooden Hammer × ○
baggage.
Those items that don’t exceed 15cm are permitted as carry-on
Stick File × ○
baggage.
Vernier Calipers ○ ○
Drafting Compasses ○ ○
Sharp Objects
Ice Picks × ○
Ice Axes × ○
Those items that don’t have the sharp and metallic point (drill
Darts × ○
shape) are permitted as carry-on baggage.
Skewers, Tongs × ○
Those wooden or plastic items that are considered they can not be used
Okinawa Ornamental Hairpin × ○ for weapons are permitted as carry-on baggage.
Those items that don’t exceed 6cm are permitted as carry-on
Nails × ○
baggage.
Those items used for medical treatment by doctor or nurse are
Hypodermic Needles × ○
permitted as carry-on baggage.
Those items used for medical purpose ((insulin , interferon,
Needles For medical purpose ○ ○ adrenaline,etc.) and prescribed by doctor are permitted as carry-
on baggage.
Blood Needles (For Measuring Blood Sugar Level) ○ ○
Sewing Needles × ○
Safety Pins × ○
Umbrellas used by passengers themselves without the sharp point
Umbrellas ○ ○
or the possibilities of weapons, are permitted as carry-on baggage.
SAMURAI Umbrella (Umbrella with the handle of a samurai sword) × ○
Others
Those items are not permitted as carry-on baggage because of the
Dangerous shaped items (e.g Swiss army knife Style and Shuriken Style USB memory stick and Lighters) × ○ appearance by which anyone may have trepidation. Lighters are not
permitted as checked baggage as well.
Axes × ○
Hatchets × ○
Chisels × ○
Wood chisels × ○
Those items that have a small cuticle knife are not permitted as
Nail clippers ○ ○
carry-on baggage.
Handcuffs × ○
Stun Guns × ○
Those items that are used for transplant and accounted non-
Shovels × ○
dangerous goods are permitted as carry-on baggage.
Those items including cork screws, without knives are permitted as
Wine openers × ○
carry-on baggage, except in case accounted dangerous goods.
The cleaner itself has "carbon cutter" and this material harder than
Smoking Pipe Cleaner × ○
cutter.
Scrapers × ○
Those items with non- pointed tips and not enough strength are
Tweezers × ○
permitted as carry-on baggage.
Those items that 10 cm or less in length (From the bottom of Bend
Fish Hook (For Blue Marlin) × ○ to the Eye) are permitted as carry-on baggage. Except in case
accounted dangerous goods.
Those items that their bar size don't exceed 65cm are permitted as
Hanging Scrolls ・ Tapestries × ○ carry-on baggage.Those items that their bar is plastic are
permitted, and may exceed 65cm.
Those items that their bar size don't exceed 70cm are permitted as
carry-on baggage.Those paper or plastic items that are considered
Storage Containers ・Boxes (for Posters, Hanging Scrolls) × ○
they can not be used for weapons are permitted as carry-on
baggage, and may exceed 70 cm.
【Reference】