Sei sulla pagina 1di 14

Brake Pedal and Brake Pedal Position Switch Adjustment

1. Steering Joint Cover

1. Remove the steering joint cover (A).

2. Footrest

1. For some models: Remove the lower clip (A) from the stud
bolt (B) with a 6 mm hex socket wrench.

2. For some models: Remove the upper clip (C) from the stud
bolt (D) with a flat­tip screwdriver, then remove the footrest
(E).

3. Front Seat Belt Lower Anchor Bolt ­ 2­Door

1. Remove the lower anchor cap (A).

2. Remove the lower anchor bolt (B).
4. Front Door Sill Trim ­ 2­Door

1. Remove the cap (A).

2. Remove the opener lock cylinder (B).

3. Remove the screw (A).
4. Remove the front door sill trim (A).

5. Front Door Sill Trim ­ 4­Door

1. Remove the cap (A).

2. Remove the opener lock cylinder (B).
3. Remove the screw (A).

4. Remove the front door sill trim (A).
6. Kick Panel

1. Pull out the front door opening seal (A) as needed.

2. Remove the kick panel (B).

1. Brake Pedal Height ­ Inspection

M/T 1. Pull back the carpet, and find the cutout (A) in the
insulation. Measure the pedal height (B) from the left side
middle of the pedal pad (C) to the floor (D) without the
insulation.

Standard pedal height:
  M/T:  
    Except Si: 149­159 mm (5.87­6.26 in)
    Si: 151­161 mm (5.94­6.34 in)
  A/T: 147­157 mm (5.79­6.18 in)

2. If the pedal height is not as specified, adjust the pedal
height.

A/T
1. Brake Pedal ­ Adjustment

1. Turn the brake pedal position switch (A) 45 °
counterclockwise, and pull it back until it is no longer
touching the brake pedal.

2. Loosen the pushrod locknut (A), and screw the pushrod
(B) in or out with pliers until the standard pedal height from
the floor is reached. After adjustment, tighten the locknut
firmly. Do not adjust the pedal height with the pushrod
pressed.

2. Brake Pedal Position Switch ­ Adjustment

1. Lift up on the brake pedal by hand. Push in the brake
pedal position switch until its plunger is fully pressed
(threaded end (A) touching the pad (B) on the pedal arm).
Turn the switch 45 ° clockwise to lock it. The gap between
the brake pedal position switch and the pad is
automatically adjusted to 0.7 mm (0.028 in) by locking the
switch. Make sure the brake lights go off when the pedal is
released.
3. Brake Pedal Free Play ­ Check

1. Turn the ignition switch to LOCK (0).

2. Inspect the free play (A) at the brake pedal pad (B) by
pushing the brake pedal by hand. If the brake pedal free
play is out of specification, adjust the brake pedal position
switch (C). If the brake pedal free play is insufficient, it may
result in brake drag.

Free play: 1-5 mm (0.04-0.20 in)

1. Kick Panel

1. Install the kick panel (A).

2. Install the front door opening seal (B).
2. Front Door Sill Trim ­ 4­Door

1. Install the front door sill trim (A).

2. Install the screw (A).
3. Install the opener lock cylinder (A).

4. Install the cap (B).

3. Front Door Sill Trim ­ 2­Door

1. Install the front door sill trim (A).
2. Install the screw (A).

3. Install the opener lock cylinder (A).

4. Install the cap (B).
4. Front Seat Belt Lower Anchor Bolt ­ 2­Door

1. Assemble the washer, the collar, and the bushing on the
lower anchor bolt as shown.

NOTE: Apply medium strength liquid thread lock to the
lower anchor bolt before reinstallation.

2. Install the lower anchor bolt (A).

3. Install the lower anchor cap (B).
5. Footrest

1. For some models: Install the upper clip (A) to the stud bolt
(B).

2. For some models: Install the lower clip (C) to the stud bolt
(D), then install the footrest (E).

6. Steering Joint Cover

1. Install the steering joint cover (A) in the sequence shown.

Potrebbero piacerti anche