Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
21819
3 Hours / 70 Marks Seat No.
Marks
P.T.O.
22306 [2]
Marks
2. Attempt any THREE of the following: 12
a) A hollow square has inner dimensions a × a and outer
dimensions 2a × 2a. Find moment of inertia about the outer
side.
b) In a bi-axial stress system the stresses along the two
directions are 6x = 60 N/mm2 (tensile) and 6y = 40 N/mm2
(compressive). Find the maximum strain.
Take E = 200 kN/mm2 and m = 4.
c) A simply supported beam of Span 5 m carries two point
loads of 5 kN and 7 kN at 1.5 m and 3.5 m from the left
hand support respectively. Draw S.F.D and B.M.D showing
important values
d) Explain the theory of pure torsion.
Fig. No. 1
P.T.O.
22306 [4]
Marks
Fig. No. 2
d) Calculate safe axial load in tension for a steel bar of
cross-section 75 mm × 12 mm, if allowable maximum stress
is 155 MPa.
e) A bar of 30 mm diameter is subjected to a pull of 60 kN.
The measured extension on guage length of 200 mm is
0.09 mm and the change in diameter is 0.0039 mm.
Calculate the Poisson’s ratio and modulus of elasticity.