Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Index
Introduction ......................................................................................................................................... 1
Sizing 1-phase .................................................................................................................................... 2
Duty Design .................................................................................................................................... 2
Mechanical configuration .................................................................................................................... 5
Frame Plate configuration .................................................................................................................. 8
Connection Plate configuration ........................................................................................................ 10
Section configuration ........................................................................................................................ 12
Introduction
This document describes the multi plate heat exchanger (MHPE) in CAS2000. It contains an instruction of how
to make a simple design and how to get a green light in mechanical configuration. This document builds on an
example, which is included in CAS2000. It can e.g. be used when testing that MPHE is correctly installed on a
computer. It does not describe the MPHE product as such.
Sizing 1-phase
Duty Design
Enter the following data to make the MPHE 1-phase design below:
NOTE! Normally [Platetype] and [Plate Material] have to be chosen by the configurator.
CAS2000 ver 5.0 Page 3 / 15
CAS Products MPHE
Mechanical configuration
7. Click [Mech conf] to execute the mechanical configuration and the configuration window will appear.
8. Change [Frame type] to RH.
9. Click [PED Cat] to select [Fluid Danger Group] for all fluids.
CAS2000 ver 5.0 Page 6 / 15
CAS Products MPHE
PED categorization.
For additional design changes click [More] in the main configuration window.
.
CAS2000 ver 5.0 Page 12 / 15
CAS Products MPHE
Section configuration
18. To configure the [Connection Plate] make a right-click with the mouse on it.
For additional configurations click [Grouping] and then click [OK] (Image to the left).
For additional configurations click [Settings] and then click [OK] (Image to the right).
CAS2000 ver 5.0 Page 14 / 15
CAS Products MPHE
Finally the MPHE unit is configured and should look like the window below.
Document history
Version: Changed: By: Summery of changes
1 2003-06-11 Leif Larsson
2 2004-03-08 Leif Larsson Update to 4.2
3 2007-05-15 Leif Larsson Update to CAS 5.0
4 2012-10-30 Carin Schöld Update to CAS 5.46
5 2013-08-26 Carin Schöld Updated menu for Mechanical configuration.
6 2013-09-17 Carin Schöld Updated menu for PED Cat.