Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
· Nominal kV
· %V and Angle (when Initial Condition is set to use Use Bus Voltages)
· Load Diversity Factor (when the Loading option is set to use Diversity Factor)
Branch data is entered into the Branch Editors, i.e., Transformer, Transmission Line,
Cable, Reactor, and Impedance Editors. Required data for load flow calculations for
branches includes:
Required data for load flow calculations for power grids includes:
· Nominal kV
· %V, MW loading, and Mvar limits (Qmax & Qmin) for voltage control mode of
operation
Required data for load flow calculations for synchronous generators includes:
· Rated kV
· %V, MW loading, and Mvar limits (Qmax & Qmin) for Voltage Control mode of
operation
1 OF 3
LOAD FLOW STUDY RUN AND INPUT DATA REQUIREMENTS
· Inverter ID
Required data for load flow calculations for synchronous motors includes:
Required data for load flow calculations for induction motors includes:
Required data for load flow calculations for static loads includes:
· Static Load ID
· Power factor
2 OF 3
LOAD FLOW STUDY RUN AND INPUT DATA REQUIREMENTS
Required data for load flow calculations for static loads includes:
· Capacitor ID
Required data for load flow calculations for static loads includes:
· Load ID
Required data for load flow calculations for chargers and UPSs includes:
· Element ID
There are some study case related data, which must also be provided. This includes:
· Max Iteration
· Precision
· Loading Category
· Initial Condition
· Update (for bus voltages and transformer LTCs using load flow result)
3 OF 3