Sei sulla pagina 1di 1

(MICROPROCESSOR AND INTERFACING)

Paper No.PHY612 C Credits: 04


04 Hrs /week Max. Marks: 75+25
Duration of Exam: 03 Hrs.
Course Objectives: To expose the students about Advances in Microprocessors, Microcontrollers
and Digital signal processing and some basics of instrumentation and interfacing techniques.
Note: The Examiners will set nine questions for semester end examination with one question
compulsory. Question Number one (1) will have short answer/conceptual/ numerical problem
questions covering the entire syllabus and will be compulsory. The rest eight question will be
set, two from each unit. The students will attempt five questions in all including the compulsory
question and select at least one question from each unit. All questions will carry equal marks.
UNIT – I
MICROPROCESSOR 8085
Introduction to microcomputer, Microprocessor (μP) 8085 Architecture, addressing modes, memory
interfacing, interfacing I/O device. Instruction set and classification, op code and operand, fetch and
execute cycle, timing diagram for memory read and memory write, machine cycle, instruction cycle and T
states, Assembly language Programming examples.
UNIT - II
MICROPROCESSOR 8086
Architecture, Pin description for minimum and maximum modes, internal operation, Instruction Execution
timing diagram, Addressing modes, Instruction format for constructing machine language codes.
Instruction set and directives, Stacks, Procedures, Macros and interrupts. I/O interfacing and data transfer
scheme. Programming example.
UNIT – III
PROGRAMMABLE AND NON PROGRAMMABLE ICS
Introduction to microcontroller 8051. Block diagram and PSW for: - 8253(timer and counters controllers),
8259 (interrupt controller), 8279 (keyboard and display controller). Brief idea of Architecture and memory
management of 80286.
UNIT - IV
MICROPROCESSOR BASED MEASUREMENT/CONTROL CIRCUITS
D/A and A/D Converters, PPI 8255 Data Acquisition and storage, Microprocessor based traffic light
controller, Temperature and water level indicator/controller. DC and stepper motor speed measurements,
Waveform generation and frequency measurement.
Text and Reference Books:
1. Fundamentals of Microprocessor and Microcomputer : B. Ram.
2. Microprocessor System the 8086/8088 Family : Liu and Gibson.
3. Microprocessor Architecture Programming and Application : R.S. Goanker.
4. Introduction to microprocessor : A.P. Mathur.
5. Microprocessor and Interfacing : D.V. Hal

1st Year Syllabus was approved in 13th Meeting of Academic Council held on 18.06.2018 and 2nd Year
Syllabus was approved in 14th Meeting of Academic Council held on 11.06.2019. Applicable to all
students admitted in 2018 and onwards.

Potrebbero piacerti anche