Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
UNIT TEST -2
CLASS: VIII Sem ( ) SUBJECT: COMPUTER INTEGRATED MANUFACTURING SYSTEM M.M:20
[UNIT-II]
Time Allowed: 1 Hr Date: ……. FEB.2016
a )Ta p pitch *s pindle s peed b)ta p pitch*tool length 11. Which code is used for “Program stop”?
c)ta p pitch/spindle s peed d)s pindle speed/tap pitch
a )M30 b)M01 c)M00 d)M02
2. M08 refers to-
12. H-code represents
a )tool change b)coolant on
c)cool ant off d)s pindle CW a ) Offs et a mount b) Cutter compensation
c) Dwel l time d) Al l of these
3. In APT language, the cutter motion in incremental coordinate
mode is addressed as 13. A ‘block’ of information in NC program means
5. Feed drives in CNC milling machines are provide by 15. Machining of complex shapes on CNC machines requires
8. GODLTA command specifies 17. which code is used for canned cycle for drilling?
a ) Incremental move for tool b) Des criptive data of tools a ) G44 b)G67 c)G89 d)G72
c) Contouri ng motions of tools d) Del ete the previous data
18. Axes drives in machining centres
9. The general form of an APT geometry statement is
a ) AC s ynchronous motor b)DC s ervo motor
a ) geometry type/descriptive data c)s tepper motor d) i nduction motor
b) des criptive data /geometry type
c) geometry type/motion command 19. The statement which control the operation of spindle of
d) geometry va lues*descriptive data machine tool is called
10. Which code is used for “Return from reference point”? a ) moti on s tatement b)postprocessor
s ta tementc)preprocessor s tatement d)a uxiliary s tatement
a ) G28 b) G29 c) G31 d) G27
20. In computer aided drafting, an arc is defined by
a ) two end points only b) centre & ra dius
c)ra di us & one end point d)two end point & centre