Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Maintenance Aspects
Confidential
Typical Mill Layout
Mill platform
Material feed
Rotor Spacer
Shaft Guide Cone
Protection
Note:
The grinding beads
are round and
slippery on the
floor. Great care
needs to be taken
to prevent spillage
which would create
a slip and fall
hazard.
Carefully remove the mill feed Line from the block off valve. Always leave one bolt in
both flanges to ensure the pipe that is being removed is well supported before removal.
7/9 12/18/2017
© Outotec – All rights reserved
Confidential
Splitting Grinding Chamber
• Mill bottom cover lowered to floor
Connection of hydraulic
cylinder to mill shell
Hydraulic cylinders
push mill apart
Shaft Bottom
Cap
PU wear protection
glued to carrier &
clamped by stator rings
Complete 180°
liner segment
bolted to mill shell
Flexibility
• Modular design where PU wear protection
and/or hard-casted stator rings can be replaced
Quick
installation
Pre-assembled in workshop
Shipped pre-assembled
in standard container
© Outotec – All rights reserved
Confidential
Large HIGmills™ 2.3 to 8 MW – Hydraulically Moved Mill Shell Halves
Mill Frame:
ü Walkways on discharge level
Largest Stirred
Mills in World
HIG2300/15000 and larger:
Up to 5 MW
• Installed either on concrete or steel (optional) structure Operational