Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
LOCATION : LRT BACLARAN DEPOT EXTENSION (F2060) DATE PREPARED: January 03, 2020
ITEM DESCRIPTION : Corrosion Inhibitor
BRAND : Bonderite – Turco Rust Bloc
Only trained personnel with PPE are allowed to perform the preparation
Authorized Handler/s
and application.
This product is intended for use by the skilled individuals at their own risk.
Remarks The information contained herein is based on the data considered
accurate based on current state of knowledge and experience.
Prepared by: Noted by:
LOCATION : LRT BACLARAN DEPOT EXTENSION (F2060) DATE PREPARED: September 21, 2019
ITEM DESCRIPTION : Unleaded Gasoline
BRAND :
Keep away from fire, sparks and heated surfaces. No smoking near areas where material is stored
or handled. The product should only be stored and handled in areas with intrinsically safe
electrical classification.
(1) Ground and bond containers during product transfers. Grounding and bonding may
not be adequate protection to prevent ignition or explosion of hydrocarbon liquids and vapors
that are static accumulators.
(2) Special slow load procedures for "switch loading" must be followed to avoid the static ignition
Handling Precautions
hazard that can exist when higher flash point material (such as fuel oil or diesel) is loaded into
tanks previously containing low flash point products (such gasoline or naphtha).
(3) Storage tank level floats must be effectively bonded.
LOCATION : LRT BACLARAN DEPOT EXTENSION (F2060) DATE PREPARED: December21, 2019
ITEM DESCRIPTION : Epoxy Primer
BRAND : Pioneer
Epichlorohydrin has been reported to produce cancer in laboratory animals and to produce mutagenic
changes in bacteria and cultured human cells. An analysis of all the evidence to date (through 1979) in
Health & Safety Hazard/s
an ongoing epidemiology study of each workers has been reported to show “weak” evidence that
exposure.
Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers.
Environmental Hazard/s Inform the relevant authorities if the product has caused
environmental pollution (sewers, waterways, soil or air)
Eye: Immediately flush eyes with plenty of water, occasionally lifting the upper and lower eyelids. Check
for and remove any contact lenses. Continue to rinse for at least 10 minutes. In case of irritation form
airborne exposure, move to fresh air. Get medical attention promptly.
Inhalation: Remove to fresh air and keep at rest in a position comfortable for breathing. If it is suspected
that gas or vapor is still present, the rescuer should wear an appropriate mask of self –contained
breathing apparatus. If not breathing, if breathing is irregular or if respiratory arrest occurs, provide
First – aid treatment artificial respiration or oxygen by trained personnel. It may be dangerous to the person providing aid to
give mouth-to-mouth resuscitation. Get
medical attention. If necessary, call a poison center immediately. Maintain an open airway. Loosen tight
clothing such as a collar, tie, belt or waistband
Skin: Flush contaminated skin with plenty of water. Remove contaminated clothing and shoes.
Continue to rinse for at least 10 minutes. Get medical attention. Wash clothing before
reuse. Clean shoes thoroughly before reuse.
Do not handle until all safety precautions have been read and understood. Do not get in eyes or on
skin or clothing. Persons with a history of skin sensitization should not be employed in any process in
which this product is used. Do not swallow. Avoid breathing vapor or mist. Use only with adequate
ventilation. Wear appropriate respirator when ventilation is inadequate. Do not
enter storage areas and confined spaces unless adequately ventilated. Keep in the original container or
an approved alternative made from a compatible material, kept tightly closed when not in use. Store
Handling Precautions and use away from heat, sparks, open flame or any other ignition source. Use explosion proof electrical
equipment. Empty containers retain product residue and can be hazardous. Do not reuse container.
Ground and bond containers when transferring material. Eating, drinking and smoking should be
prohibited in areas where this material is handled, stored and processed. Workers should wash hands
and face before eating, drinking and smoking. Remove contaminated clothing and protective
equipment before entering eating areas. See also Section 8 for additional information on hygiene
measures.
Application/s For adhesive purposes only.
Only trained personnel with PPE are allowed to perform the preparation of chemical mixture and
Authorized Handler/s application.
Supervisor Arsenio Agudera
Stocks / Qty. on Hand 17 galoons
Remarks Stock
Prepared by: Noted by:
LOCATION : LRT BACLARAN DEPOT EXTENSION (F2060) DATE PREPARED: September 21, 2019
ITEM DESCRIPTION : B690 Boysen Quick Drying Enamel White
BRAND : Boysen