Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
b. Locker system.
c. Electrical Control Rooms.
d. Heat Treating Furnaces.
e. Historical places- Antique Statues & monuments.
f. Unauthorized access to Military bases
ammunition resource notification alarm.
g. It can be used simple burglar alarm for
security, the plate can be place in any metal
such our doors or in metal knobs.
OBSERVATIONS
We have seen that initially there was no buzzer sound
as no one is touching the wire
When we touch the end points of the wire with a
time lag of 1-2 seconds the buzzer starts giving sound
as the touch is detected and the circuit is completed
When we press the button connected in parallel to the
capacitor the charge in capacitor flaws out and the
buzzer stops producing sound and the circuit is reset
CIRCUIT WORKING
In the circuit when touchpoint is touched by
human body are very load electric charge from
human body is transferred to Tl base of the
transistor as this point is sensitive to low voltage it
starts functioning its base becomes positive with
respect to negative voltage. the positive voltage
from This energise T2 transistor and it further
switch on the audio oscillator circuit connected
with it
HELP FROM
INTERNET
INFORMATION
FROM LIBRARY
CONTENTS
1. CERTIFICATE OF EXCELLENCE
2. ACKNOWLEDGEMENT
3.1NTRODUCTlON
4. THEORY
5.APPARATUS REQUIRED
6. WORKING
7.0BSERVATION
8.CONCLUSION
9.PRECAUTlONS
10. BIBLIOGRAPHY
INTRODUCTION
Touch alarm is a device which creates harsh
sound when anyone touches it The given project
is a very useful device to detect any intruder in
no entry places or to protect valuable items
placed in glass shelves it is ideally suited for
home protection making touch operated bills or
small toys are finger touch at such point will
activate the circuit for few seconds and reset it
automatically
THEORY
Here is a simple alarm device it generates a loud
alarm when there is an attempt of unauthorized
access. When the intruder opens the door, the
circuit senses the attempt of theft & the alarm
will be activated. Circuit of the simple touch
sensor alarm is built around a couple of readily
available cheap components.
PRECAUTIONS
1. Components of the circuit should be handled carefully.
2. Care should be taken while soldering as it may burn the
skin.
3. Connecting wires should be insulated to prevent
disturbance.
4. Connections should be tight as it may break easily.
5. Soldering must be done carefully as it may burn the PCB
board.
CIRCUIT DIAGRAM
CERTIFICATE
This is to certify that SHYAMBHAVI GARG,
a Student of class XII-A1 successfully
completed the research on the below mentioned
under the guidance Of MR RAJEEV
AGARWAL( Subject Teacher ) during the year
2018-19 in partial fulfilment of physics practical
examination conducted by CBSE, New Delhi.
Made by:
SHYAMBHAVI GARG XII-A1
ACKNOWLEDGEMENT
In the accomplishment of this project successfully, many
people have bestowed upon me their blessings and the heart
pledged support, this time I am utilizing to thank all the
people who have been concerned with project.
Primarily I would thank god for being able to complete
this project with success. Then I would like to thank my
principal Mrs. Jyoti Gupta and physics teacher Mr. Rajeev
Agarwal, whose valuable guidance has been the ones that
helped me patch this project and make it full proof success
his suggestions and his instructions has served as the major
contributor towards the completion of the project.
Then I would like to thank my parents and friends who
have helped me with their valuable suggestions and
guidance has been helpful in various phases of the
completion of the project.
Last but not the least I would like to thank my
classmates who have helped me a lot.
-SHYAMBHAVI
GARG
XII-A1