Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
LTD
List of projects:
5. Performance evaluation of the single point cutting tool using cryogenic treatment
evaluation methods
9. Design analysis and manufacture of draw die for light commercial vehicle and
10. Design analysis and manufacture of crash form die for arm control component
11. Design analysis and manufacturing of press tool for door slider
15. Static and dynamic analysis of undamped beams and rotors using FEA
19. Design analysis and optimization of segment joint for aerospace applications
21. Design and analysis of hydraulics fixture for cylinder head n series
24. Design of draft die for a typical component and simulation of forming operation
26. Feasibility study of lock in thermal graffi technique for evaluation of defects in coatings
27. Auto mobile crash analysis by using square box frame rails
28. Design of work holding fixture for complete machining of camshaft bearing cap5
29. Design and experimental investigation of composite over wrapped pressure vessel for
aerospace applications
31. Design and analysis of high pressure die casting for upper helm
32. Manufacturing of hybrid composite laminate by using vacuum assisted resin infusion
method
33. Flow analysis over aero foil by low speed wind tunnel and CFD solver
34. Design and fabrication of experimental test rig for determining bypass factor in a sensible
heating process
37. Determination of effective inks modulus and coefficient of thermal expansion of carbon
nanotubes-based composites
38. Fabrication and analysis of glass epoxy laminated stiff and composite panels
39. Modelling of a robot arm and GTAW welding and if he analysis of torch
41. Design and development of conveyor fixture for assembly of rear axle
45. The effects of process para meters on welding response of corner joint in curved plates
46. Active vibration control of smart cantilever beam using piezoelectric composite’s
60. Design and fabrication of a voice controlled wheelchair for physically disabled people
63. Mechanical behavior of e-glass, epoxy reinforced with filler materials (rubber powder ) composite
64. Mechanical behavior of e-glass, epoxy reinforced with filler materials ( e waste) composite
65. Mechanical behavior coconut coir fiber rein forced with epoxy polymer
66. Development of sisal, jute and e glass composite material with varied filler material.
67. Development of e glass epoxy reinforced with rubber powder as filler material
69. Mechanical behavior of e glass jute epoxy reinforced with wollastonite as a filler material.
70. Development of composite using bidirectional e-glass and chopped e glass by varying the layers