pockets, buttresses, blisters and other intermediate anchorages will be discussed in turn. Stressing pocket dimensions should be selected so that there is adequate clearance for installation of the tendon and anchorage, installation of the stressing jack, post- tensioning, and removal of the jack. A curved stressing chair can often be used to reduce the necessary dimensions. The additional friction losses in the chair must be taken into account in Figure 4.9: Local deformation in front of the the design. If the tendon deviates (curves) into anchorage produces tension behind the the pocket the resulting deviation forces as anchorage. discussed in Section 4.4 must be addressed. As a
Figure 4.8: Stressing pockets can be used
when it is undesirable or impossible to use anchorages in the end face of a member.