Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Date: 08-11-19
____________
Dear Sir/ Madam,
Sub: Request for Question paper setting – Reg.
***
I am pleased to inform you that you are appointed as Paper Setter for the subject 'Fluid Mechanics-II' of 'III
B.Tech I Sem'. You are requested to frame '2' sets of the question paper in the subject mentioned as per the
instructions enclosed.
You are also requested to prepare Scheme of valuation (Scheme of step - wise marking and
accurate solutions to questions and problems)
You are eligible for remuneration at the rate of Rs.1000 per each set of question paper (750/-) and scheme
of valuation (250/-).
The Question papers are to be filled in prescribed format given in the enclosures, the soft
copy/ scanned copy of scheme of valuation, acceptance letter, undertaking letter and remuneration
bill are to be e-mailed to coe.sitams@gmail.com
3. PART-A consists of 10 short answer questions (2 marks each) by selecting one question
4. PART-B consists of 5 questions with internal choice (10 marks each) by selecting one
question from each UNIT of syllabus. In each question there may be sub questions.
5. The format of the question paper and a model question paper are enclosed.
6. Please set the question paper in such a way that the candidate is able to answer full
question paper within 40 pages of A4size. This is because the candidate is given only one
answer book containing 40 pages. No additional sheets are provided to the candidate.
8. If the question paper contains any diagrams they must be neatly drawn with clear
dimensions in order to avoid any confusion to the student. The diagram caption should
identify the question to which it belongs. For example Fig.Q1, Fig.2a (if the question has
subparts) etc. The figures must be inserted at the appropriate position in the soft copy. If this
9. The question paper and other enclosures must be sent by E-mail to coe.sitams@gmail.com
10. Delete the Question paper file after receiving confirmation from the Controller of Examinations.
12. If the Paper Setter is unable to accept the offer, the same must be intimated to the Controller of
Examinations immediately.
13. Any additional requirements such as Handbook/ IS codes/ data sheet/ graph sheet (normal or
semi- log) are to be provided to the candidate, please indicate the requirements clearly in the
question paper.
14. The soft copy of the question paper should be set using Microsoft word 2007 with password
15. Question paper key should be prepared. For theory questions mention clearly only the
salient points. Forgive the step-wise solution and the answer. The graphs in the solution
Part-B
UNIT-I
1. Describe Rayleigh’s method and Buckingham’s method for dimensional analysis.
(Or)
2. An oil of specific gravity 0.92 and viscosity 0.03 poise is to be transported at the rate of
2500 litres/sec through a 1.2 m diameter pipe. Tests were conducted on a 12cm diameter
pipe using water at 20o C is 0.01 poise, find: i) velocity of flow in the model
ii) rate of flow in the model.
UNIT-II
3. A kite weighing 0.8 N and having an area 1 m2 makes an angle of 7o to horizontal when
flying in a wind of 36 km/h. if pull on the string attached to the kite is 49 N and it is
inclined to the horizontal at 45o , calculate the lift and drag co-efficient. Take ƿ for air =
1.2 kg/m3 .
(Or)
4. Derive an expression for the lift on cylinder with the neat sketch.
UNIT-III
UNIT-IV
7. State and prove the condition under which the trapezoidal section of an open channel will
be most economical.
(Or)
8. A 8m wide channel conveys 15 m3 /s of water at a depth of 1.2 m. calculate;
i) specific energy of flowing water
ii) critical depth, critical velocity and minimum specific energy
iii) Froude number and state whether flow is subcritical or supercritical.
UNIT-V
STRICTLY CONFIDENTIAL
ACCEPTANCE LETTER
To From:
The Controller of Examinations,
Sreenivasa Institute of Technology & Management Studies,
74-Thimmasamudram,
Chittoor-517127.
Sir,
With reference to your E-Mail/Phone Contact, I accept to set the question paper for the
Subject Fluid Mechanics-II and I will send the question paper as per the instructions and guidelines
provided.
Yours faithfully,
Mobile No:
E- Mail ID:
UNDERTAKING by PAPER SETTER
Certified that I am satisfied that the questions on the following subject are covered by the
regulations, syllabi and textbooks prescribed in each case, the questions are not ambiguous in nature
and, the data given are correct and complete.
1. I hereby declare that 2 sets of question papers in the subject Fluid Mechanics-II has been set by me
only.
3. I have destroyed all the notes, rough work and other such material used by me for setting the
question papers.
Mobile No:
E- Mail ID: