Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
(Choose Two)
A. It uses TLVs to share device information
B. It is used to initiate a VTP server and client relationship
C. It runs on the datalink layer only
D. It uses SNMP to share device information to an external server
E. It runs on the network layer and the data link layer
Answer: A and B
14. If you change the weight and distance parameters on a device with an estabilished BGP neighbor
which additional
task must you perform to allow the two devices to continue exchanging routes ?
A. Reset the gateway interface
B. Reset the BGP connection on the device
C. Change the weight and distance settings on the other device to match D. Clear the IP routes on the
Device
Answer: C
You have configured a router with an OSPF router ID,but its IP address still
reflects the physical interface.Which action can you take to correct the
problem in the least disruptive way?
A. Reload the OSPF process
B. Reload the router
C. Save the router configuration
D. Specify a loopback address
Answer: D
Question: 159
Which two facts must you take into account you deploy pppoe?(Choose two)
A. An individual pvc can support one pppoe client? B. DDR is not supported C. DDR idle times must be
configured to support VPDN logging D. You must manually configure ip addresses on the pppoe
interface E. Pppoe supports a maximum of 10 clients per customer premises equipment
Answer: CD
Question:165
Which two statement about an Ethernet frame source address are true?
A. The leftmost bit is always 1. B. The address is 6 bytes long C. The address is 4 bits long D. The
address is 4 bytes long E. The leftmost bit is always 0
Answer: BD
Question: 167
Which two statement correctly describe the ping utility?
A. It can identify the source of an icmp time exceeded message B. B. It uses UDP C. It can verify
connectivity to a remote device without identifying the path D. It can identify the path that a packet
takes to a remote device E. It uses icmp
Answer: AE
Question: 172
Which features or method can you use to isolate physical layer problems on a serial link?
Answer: A
Question:
|CCNARoutingandSwitching(200-125)byGLITDhaka
173
After an ftp session to ftp.cisco.com fails, you attempt to ping the server A ping to ftp.cisco.com also
fails, but a ping to the ip address of the server successful. What is reason for the failed FTP session?
A. A firewell is blocking traffic from the FTP site B. An ACL is blocking the FTP request C. The assigned
DNS server is down D. The internet connection is down
Answer: A
Question: 180
Which two pieces of information can you determine from the output of the show ntp status
command?(Choose two.) A. whether the clock is synchronized B. the NTP version number of the peer
C. the IP address of the peer to which the clock is synchronized D. whether the NTP peer is statically
configured ntp servers E. the configured NTP servers Answer: BD