Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Door Station
Important Information
FCC and Other Information ....................................................................................... 2
Important safety instructions ..................................................................................... 3
Additional safety information ..................................................................................... 4
For best performance ................................................................................................ 4
Help
Cleaning ................................................................................................................... 12
General Information
Technical data about this product ............................................................................ 13
2
Important Information
CAUTION
RISK OF ELECTRIC SHOCK
DO NOT OPEN
4
Introduction and Installation
Included items
5
Introduction and Installation
Location of controls
Front view
* Be sure to attach the accessory button cover to the Call Button before using it.
(The diagram shows the button cover installed.) (Page 11.)
6
Introduction and Installation
Before installation
To avoid malfunction or communication disturbance, do not install the door station
in the following locations:
– Places where vibration or any other kind of impact occurs.
– Places where echoing is frequent.
– Places where a high concentration of dust, hydrogen sulfide, phosphorus,
ammonia, sulfur, carbon, acid, or noxious fumes occur.
– Within 2 m (6′7″) of a TV, microwave, personal computer, air conditioner or any
other electrical device.
Note:
• Be sure to install the monitor station and sub monitor station more than 5 m
(16′5″) away from the door station.
7
Introduction and Installation
Screwdriver
2 Install the mounting base to a wall using the attached wood screws.
(4 mm x 20 mm, 3/16″ x 13/16″).
Mounting base
Wood
Screws
Wall
<Installation size>
Note:
• Install so that picture range will be within a height of
995 mm ~ 1795 mm from the ground surface.
Important information:
On the bottom surface of the door station, there are holes to allow water to drain.
Do not cover it up when installing.
8
Introduction and Installation
3 Remove the adjustment cover, and then adjust the angle of the camera lens.
Adjustment Screwdriver Angle adjustment lever
cover
Left direction Right direction
(maximum 16°) (maximum 16°)
Upward direction
(maximum 16°)
* Be sure to install the adjustment cover after adjusting the angle of the camera lens.
9
Introduction and Installation
Wall
Wire (Not included)
Microphone
Speaker
Connect to terminals
D11 and D12 (D21
and D22) of the
Screwdriver
monitor station.
Door station
Mounting base
Wall
10
Introduction and Installation
Push
Call button
Button cover
Slot
Slots
Screwdriver
Screwdriver
* Press against the button cover gently with a finger when removing it, to stop
it from falling down.
11
Help
Cleaning
Clean the unit with a soft, dry cloth when cleaning. For excessive dirt, wipe the unit
with a slightly damp cloth.
Important information:
• Do not use anything containing alcohol, polish powder, powder soap, benzine,
thinner, wax, petroleum, or boiling water. Also do not spray with insecticide, glass
cleaner, or hair spray. This could cause a change in color or quality.
12
General Information
Note:
• Design and specifications are subject to change without notice.
• The pictures and illustrations in these instructions may vary slightly from the
actual product.
13
14
15
For your future reference
Date of purchase
Copyright:
• This material is copyrighted by Panasonic Communications Co., Ltd., and may be
reproduced for internal use only. All other reproduction, in whole or in part, is
prohibited without the written consent of Panasonic Communications Co., Ltd.
LHQT0200-1
Printed in INDONESIA S0405-1065