Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Distributor:
Exhibitor:
Update:
Date:
For Concepts:
AT2-A-Edge
AT2-B-Edge
AT3-A-Edge
AT3-B-Edge
AT3-C-Edge
SERIAL Connection:
To connect to the switch with putty over a serial cable, the following settings are therefore necessary:
Speed (baud) => 9600
Data Bits => 8
Stop Bits => 1
Parity => None
Flow Control => XON/XOFF
Important!!!
So that Backspace works, you also need:
Putty configuration -> Terminal -> Keyboard -> change sequences sent by -> the backspace key => control-
H
And to input several lines:
Connection => Seconds between keep lives (o turn off)
Preparation:
- Assemble mounting elements
- Put GBIC's in Switch (just HP X120 and X130 models are allowed)
- Fix the IP sticker at the front side
- if spare device put sticker "spare" on the Switch
- Keep location IP list up to date
- Put Power suppley's (JG544) in the slots (AT2 just 1 power suppley needed).
Firmwa10re:
Document1
1
Internal: All rights reserved. Distribution within DRÄXLMAIER Group, customer and partners.
display Version
5510 => HPE Comware Software, Version 7.1.045, Release 1121P05
Info: to edit the files on the switch you can also use the following command:
delete
rename
If it's not already on the Switch, you have to transmit the correct file over TFTP.
To do this, allocate an IP address at the management port (DHCP or Static).
Over DHCP (Long Delay over MPLS)
system-view
interface M-GigabitEthernet 0/0/0
ip address dhcp (patch Switch Mgmt Port to any copper port to the network)
quit
quit
Transmit data:
tftp 10.254.1.5 get 5510HI-CMW710-R1121P05.ipe (with connection to Vilsbiburg of course 10.254.1.5)
Over static IP
system-view
interface M-GigabitEthernet 0/0/0
ip address 10.10.10.10 24 (patch the Switch MGMT Port directly to the notebook with TFTP)
If no TFTP server is available, allocate the address: 10.10.10.11 / 24 on your local computer and start
the TFTP Server, be sure that the firewall has been switched off.
quit
quit
Transmit data:
tftp 10.10.10.11 get 5510HI-CMW710-R1121P05.ipe (with connection to local notebook)
Important:
Current: The currently started firmware
Main: Has to be selected already as mentioned above
Backup: Hast to be the default installed firmware (or rather the last older)
backup bootloader should be filled, if possible with the firmware which was already available before!
boot-loader file boot flash:/5510hi-cmw710-boot-r1121.bin system flash:/5510hi-cmw710-system-r1121.bin
all backup
y
Configurat Porturile
Document1
2
Internal: All rights reserved. Distribution within DRÄXLMAIER Group, customer and partners.
system-view
undo interface Vlan-interface1008
interface Vlan-interface1063
ip address 10.63.8.xxx 255.255.0.0
quit
save force
Document1
3
Internal: All rights reserved. Distribution within DRÄXLMAIER Group, customer and partners.