Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
TARGET CODES:
WELL HISTORY / CHECKLIST
PERMIT TO DRILL / INTENT TO DRILL
WELL INSPECTION / SCOUT REPORTS
OPERATOR’S TECHNICAL REPORTS / MAPS
ADMINISTRATIVE / SUNDRY REPORTS
CORRESPONDENCE
MISCELLANEOUS
WELL HISTORY /
CHECKLIST
WELL FISTORY
Well Name North Central #1 State-Garv .Percit NO, 629
Confidential From To
Logs Received
Cuttings Received Cores Received
Drill Stem Records
6-26-73 HEW Site not approved. Marker post still not solid.
Fall River
NAME AND ADDRESS OF SURFACE OWNER ELEVATION To NO. OF WELLS ETC.
'b131
I,,-, rn Lc", 57
!..
INSTRUCTIONS
(-47,,
ci.neral: This form is designed for submitting proposals to perform certain well operations, Onditietr:, 7o'ki":::-7
11: %
ty.
22 es 21
-J4 ds and leases for
appropriate action by either a Federal or a State artency, or both, pursuant to applicable Fecldral and/Cal 3,tate-lai an gulations. Consult
applicable Federal or State regulations, or appropriate officials, concerning approval of the pro:Pcsal bettre-..-opeeltIons r6 tarted.
If ; he proposal Is to redrill to the same re!,ervoir at a different subsurface location or to a neVk "rjayservoir, tre Sqls fat.. ith appropriate no-
tations. (..),/,
\-: 0- , \\.:v
If the well Is to be, or has been, directionally drilled, so state and show by attached sheets, if neces 4,,/
Mif rtk location of the hole In
any' present or objective productive zones.
File 3 copies of this form with Secretary, Oil & Gas Board, Pierre.
(•Sample location: 660" South and 660" Ea.,,t of the Northwest Corner of Section IC.)
STATE — GARY NO. 1
LOCATED IN THE NE 1/4 OF ..HE SE 1/4 OF SECTIO11 16, TOWNSHI / SOUTH, RANGE 7 EABT OF
THE BHM IN FALL RIVER. COUNTY, SOUTH DAKOTA .
NE CORNER \
NW CORNER
NOT FOUND
0
cr■
cv WELL SITE
\
NE 1/4 OF SE 1/4
SECTION 16
HUB ELEV. 3350,7
cv
C11
r•••
SURVEYOR'S CERTIFICATE
I, VINAL C. FRANCIS, A REGISTERED PROFESSIONAL ENGINEER AND LAND SURVEYOR DO HEREBY
CERTIFY THAT AT THE DIRECTION OF JACK YOUNG I HAVE SURVEYED AND PLATTED THE STATE —
akRy NO. 1 WELL, LOCATED IN THE NE-174 OF THE SE 1/4 OF SECTION 16, T9S, R7E, BHM,
FALL RIVEh COUNTY, SOUTH DAKOTA, AS SHOWN HEREON. I FURTHER CERTIFY THAT ALL DIMENSIONS
SHOIN ARE TRUE AND COhRECT TO THE BEST OF MY KNOWLEDGE AND BELIEF.
\) 1-4444.c.4
REGISTERED PROFESSIONAL ENGINEER VINAL C. FRANCIS
AND LAND SURVEYOR NO. 625 SEAL
SUBSCRIBED AND SWOhN TO BEFORE ME AT RAPID CITY, SOUTH DAKOTA ON THIS 21ST DAY OF
APRIL, 1971
FORMATION TOPS:
From To Approved X
REMARKS:
FORMATION TOPS:
REMARKS:
Site restored -to original condition but marker pole not solid.
FORMATION TOPS:
REMARKS:
Post is not so1ialy in place. It probably won't fall over now but it is noticeably
loose and easily moved back and forth by hand.
)
SCOUTED BY kichg.
Asst. Geol. Fred V. Steece, Asst. State Geologist
Number 2
SCOUT REPORT
South Dakota Geological Survey
Date Scouted 5-19-71
Operator :;orti i Central
Permit Number
Farm/Lease Name ill State-Gary API Number 40 047 20049
Sec. , T. , R. 71 r 71 7 ; ver
'County
Elev. , Est. T.D. 4500 , Actual T.D. 433! 5-1-71
, Spudded
Contractor Geologist
WORK IN PROGRESS:
to plug. PfzT: 3840-38t
30 cm-very weak blow, dead 5 min.
60 MT -Rec 27 CI. w/oil '
FORMATION TOPS:
Clreerilx)rxi---1110 `.i.ruielusa-33 9 0
i..7.ec 'arker--38 06
Creek,— 1716 1)al laE.;aila--4200
Fall River------1970 T.D.------------4335
!orrison------ 2218
Sunciance 2692
Pint lehants 3270
Opec 3324
CASING RECORD:
SCOUTED BY
Fred V. Steece, Principal Ceologist
MAY 13 1971
Number 1
SCOUT REPORT
South Dakota Geological Survey
Date Scouted 5-7-71
Operator North Central Pertnit Number 629
Farm/Lease Name #1 ctate—rary API Number un n47 2011411
NESE See. 16 , T. 9S , R. 7E F.:11 River County
Elev. , Est. T.D. 4500 , Actual T.D. , Spudded 5-1-71
Contractor A_ T._ Rohl i iker Geologist ;Pim Adams
WORK IN PROGRESS:
Drilling at 3190
First visit
FORMATION TOPS:
PLUGGING RECORD:
Date Plugged
CASING RECORD:
10 3/4 From 0 To 165(110 ntreg. 3% Ca C12)
From To Feet
From To Feet From To Feet
REMARKS:
Kirk Perry — Orig. Tky.k Lester — N.C. Veep.
SCOUTED BY
\
SPUD: .5- -- 7 / s--
EST T.D.: 4-S-T° ( 1
bo F- S D
‘)ij
CASING: 70 —C t,o/ ci-c-e .24-) e
CORES: zunt,c. -2-c, '3 S_i 2 4, c.
DST'S: 3ge-to " >b Ft; tipa9i,i
LOGS: I, To.,
T.D.: 4 r
-- L C. D
ss
) IA
PLUG: - -4/ - 71
( dLtc
A ?zk ) —
*tick, i ,p—e_e_if ‘
P--/
7- c; -7a
ho.0 b€Qen d Lio-02(261
22, I (7/ _
- r
dotra'")
er ¢cd'e./7 icrec--"it,teo e_
04:- A6
1 niter-
)
(
1
OPERATOR'S
TECHNICAL
REPORTS / MAPS
M. J. ADAMS
Consulting Geologist
61) 18th Street West
Billings, Montana 59102
Phone 406-656-7583
OPERATIONS
WELL CHRONOLOGY
CASING RECORD
Ran 5 joint5 of new 1027," 8 rd 32# surface casing. Set @ 172 D.F. with
110 sacks bulk regular, 3% CC12.
LOGS
CORES
None
DRILL STEM TESTS
D.S.T. #1
3840-3865
H.P. 2018-2035
1st Flow Pressure 32-64
2nd Flow Pressure 64-96
Shut in Pressure 1291-1180 Bottom hole temperature - 128°
SAMPLER RECOVERY
SAMPLE PROGRAM
MUD PROGRAM
Gel Chemical
SHOWS
Depth RT Rw 0 Sw
RECOMMENDATION
Plug & Abandon
PLUGGING DATA
FORMATION TOPS
Formation Sample E Log Datum
2506 3865
2764 3962
2971 4084
3398
DEVIATION RECORD
@ 127 = IC @ 26 71 = 1°
@ 149 - @ 3150 = e°
@ 1023 . 1° @ 3287 11°
@ 2006 = c @ 3417 . 2o
@ 2226 . IC @ 3846 2e°
@ 2426 - 1° @ 4098 = 2e°
@ 4175 = 2i°
BIT RECORD
SAMPLE DESCRIPTIONS
180- 240 Shale, dark gray9 lumpy, bentonitic, medium firm,@ 210 few loose
frosted medium gray sand grains,@ 220 trace hard tight argillaceous,
very slightly calcareous siltstone.
240- 270 Siltstone, gray tan to gray, well sorted, hard, tight, very slightly
dolomitic.
270- 340 Shale, dark gray, medium firm, lumpy, very slightly calcareous.
340- 410 Shale, black, carbonaceous, finely micaceous, partly lignitic,
@ 380 becoming very slightly pyritic locally.
410- 440 Shale, light gray, lumpy, medium firm, bentonitic, with streaks
bentonite.
780-1000 Shale, dark gray, lumpy, soft to medtum firm, bentonitic, @ 850
shale becomtng slightly silty locally, 950-960 no sample.
1000 1 050
- Shale, black, blocky, silty to slightly sandy, slightly glauconitic,
slightly calcareous, few inoceramous fragments, @ 1010 streaks
cream limestone, @ 1030-1040 no sample.
121 0-1310 Shale, dark gray, lumpy, calcareous, marly, abundant white specks.
1310-1410 Shale, dark gray, lumpy, calcareous, some soft white bentonite,
@ 1370 trace pyrite.
1410-1540 No samples.
1540-1560 Sandstone, white to clear, very fine grain, silty, with streaks
hard, tight siltstone.
1560-1610 Shale, light gray, fissile to blocky, medium firm locally, slightly
silty, @ 1590 few thin streaks siltstone.
161 0 -1640 Shale, light gray, fissile to blocky, silty, streaks very fine
grained white to clear, soft friable sandstone, no show.
1640-1720 Sandstbne, white to clear, very fine grain, soft, friable, calcareous,
probably good porosity,looks wet, abundant calcite fragments.
1720-1800 Shale, light gray, soft, fissile to blocky, locally silty with streaks
silistone.
leoo-1990 Shale, black, lumpy, locally slightly silty, @ 1840 few loose amber
sand grains, trace pyrite.
199o-2o90 Sandstone, loose, medium grain to fine grain, well rounded, pyritic,
@ 2000-2010 no sample, @ 2080 trace maroon claystone.
2o9o-213o Siltstone, light gray, well sorted, calcareous, partly soft friable,
argillaceous, some black specks, few thin sandy laminations, no
fluorescence or cut.
2130-2200 Sandstone, white to pink, medium grain, well rounded, hard, tight
to soft friable, some white to maroon soft claystone, @ 2160-2200
samples predominately light gray splintery, finely micaceous shale,
suspect mostly caving.
2230-2290 Limestone, white, light gray, cream, soft chunky. to dense, tight,
dolomitic, @ 2240 becoming slightly sandy locally.
2390 -242 0 Shale, light to dark gray, fissile to blocky) possibly streaks
dolomite and sandy anhydrite.
242 0- 2460 Sandstone, white to clear, very fine grain, well sorted, silty,
anhydritic, looks wet, mineral fluorescence, not cut.
2500-2690 Sandstone, loose, very. fine grain, very soft with white clay.
cement,@ 2610 some tan to brown, soft, blocky shale, @ 2660 some
loose pyrite, some white cyrstalline anhydrite.
2 690-2710 Shale, green to blue green, subwaxy, also siltstone, white to light
gray, hard, tight, calcareous, no shows, some white microcrystalline,
dense, 1-Aghly fossiliferous limestone.
3?
3040-3190 Shale, dark red to brick red, some green, lumpy, firm, locally
silty to sandy, very slightly dolomitic, possibly stringers
anhydrite, @ 3090 some brick red, well sorted, siliceous, siltstone,
@ 3100 some white crystalline anhydrite.
3190-3210 Anhydrite, white to clear, locally pink to red mottling, dense to
finely crystalline, trace hard, tight anhydritic sand.
3210-3230 Shale, green, gray, blue green, olive, medium soft, blocky, slightly
dolomitic, some streaks very fine grain white siltstone.
3230-3260 Shale, red, brick red, soft lumpy, silty, some white crystalline
anhydrite.
3260-3350 Limestone, white to pink, micro crystalline, dense to subchalky,
lamilar, appears to be thin bedded, @ 3320 some liver colored lumpy
shale.
3350-3390 Anhydrite, white to pink, dense, some red shale as above, @ 3360
few pieces very fine grain orange—red argillaceous, hard, tight,
sandstone with no show.
PP 3390-3440 Sandstone, white, very fine grain, soft, friable, some white clay
matrix, looks wet, @ 3410 some loose clear very well rounded medium
gray, looks like tapioca, some pink microcrystalline chalky limestone.
3440-3460 Sandstone, white to pink, very fine grain, soft friable, dolomitic,
streaks orange—pink dolomitic limestone.
3460-3480 Shale, dark red, silty to sandy, much black shale (poor sample).
3720-3730 Dolomite, gray tan to dark gray, soft argillaceous, to hard, dense,
streaks anhydrite and streaks sandstone.
3800-3810 Shale, brown-red, splint Ty, partly. subwaxy, some blue green soft
c-41
dolomitic siltstone.
384 0 3870
- Dolomite, gray brown, dense to subchalky, evenly. stained, crushed
pieces are stained throughout.appears to have very poor porosity,
poor to fair cut when crushed, poor cut without crushing.
3930-3940 Dolomite, dark brown, dense, some fossil shadows? with intercalated
white dense to finely crystalline aulvdrite.
3980-4000 Dolomite, gray, ndlar, with dark specks possibly' fos3i1 shadows.
99
4000-4070 Dolomite, pink, tan, some brown cherty, locally with red shale
partings, few calcite crystals on fractures, @ 4040 becoming
slightly pyritic.
4310-4335 Dolomite, gray tan to buff, subchalky to dense, some white to clear
calcite crystals.
Ph0.2.2 2.Co 3G3 110X 712 ST)1,1LlNIC.1., CO20.1.WD,
TD 3865
!
2 G 1180 117h I
i
; Flow #3-IF Nonp Taken
H CD
tr, t i FF I n n i \r0
CO
SIP#3 J I: II
Pressure f:dow
:Bottom Packur
1
:Wed To
0
ist Flow - Tool opened with a weak blow, decreasing to a very weak
Llow at end of period.
2nd Flow - Tool reopened with a few bubbles, dead in 5 ninutes. Dead, C
c
REMARKS:
with an occasional blloble, to end of test.
Cr,
Chart ol.ows very li, plugging action but not enough to effect results
,D
of test.
Initial Shut-in
42 1123
48 1143 "
54 1161
6o 1 1 74 "
7;2 -
• ••••asaa ,,eals a
Other Xone
Resistiv:t.y
76o - 2520
Mud P:f Sample 11.8 0 of Chloride Content PPm•
.
Where was sample drained Rig Floor
Remarks:
ADMINISTRATIVE /
SUNDRY REPORTS
S. Dak. Oil & Gas Board
TTTTT PUS C•. P1111•• FORM 7
PLUGGING RECORD
Operator Address
North Central Oil Corporation 1300 Main Street-Suite 1000; Houston, Texas 77002
Name of Lease Well No. Field & Reservoir
State-Cary 1 Wildcat
Location of Well Sec-Twp-Rge or Block & Survey County
NE3/4 SEk Sec. 16, T9S-R7E Fall River
Application to drill this well was filed Has this well ever Character of well at completion (initial production):
in name of produced oil or gas Oil (bbls/day) Gas (MCF/day) Dry?
North Central Oil Corporatio No Yes
Date plugged: Total depth Amount well producing when plugged:
Oil (bbls/day) Gas (IVICF/day) Water (bbls./day)
5/17/71 4335
Name of each formation contain- Fluid content of each formation Depth interval of each formation Size, kind & depth of plugs used
ing oil or gas. Indicate which indicate zones squeeze cemented,
formation open to well-bore at giving amount cement.
time of plugging
25 sx 3906-3806'
No oil or gas bearing formations
_ _
25 sx 2790-2690'
25 sx 1635-1535'
25 sx 210- 156'
10 sx top of surface
dry hole marker erected
CASING RECORD
Size pipe Put in well (ft.) Fulled out (ft.) Left in well (ft.) Give depth and Packers and shoes
method of part-
ing ea,ing (shot,
ripped etc)
, Secretary
051‘.);\ 1 2
TYPE OF COMPLETION 1
Oil Well 0 Gas Well
ilr_y__hole FIELD AND POOL, OR WTLDCAT
0 New We110 Work-Over 0 Deepen 0 Plug Back 0 Same Zone 0 Diff Zone
Wildcat
OPERATOR NO. ACRES IN LEASE
North Central Oil Corporation
ADDRESS
1300 Main Street - Suite 1000; Houston, Texas 77002 640
LOCATION (In feet from nearest lines of section or legal subdivision where possible)• % '4 SEC. TWP. RGE.
At total depth
Fall River
PERMIT NO. DATE ISSUED PREVIOUS PERMIT NO. DATE ISSUED
629 4/23/71
DATE SPUDDED DATE T. D. REACHED DATE COMPL. ELEVATIONS ELEV. CASIN'GHEAD
(Rep.piy. t,o Prod.) (DF, RKB, RT, GR, etc.)* FLGE.
5/1/71 5/16/71 rP & A 5/17/71 3350' Gr; 3357' KB
TOTAL DEPTH
(MD & TVD)
PLUG. BACK
T. D. (MD & TVD.)
I IF MULTIPLE COMP L., I INTERVALS
DRILLED BYd
ROTARY TOOLS CABLE TOOLS
HOW MANY•
4335 ■ O-TD
PRODUCING INTERVAL(S), THIS COMPLETION, TOP, BOTTOM, NAME (MD & TVD)• DATE DIRECTIONAL
SURVEY SUBMITTED
None
TYPE ELECTRIC AND OTHER LOGS RUN (Circle those filed) WAS WELL CORED
IES, Compensated Formation Density No
CASING RECORD (Report all strings set in well)
CASING SIZE DEPTH SET (MD) HOLE SIZE 1 WEIGHT LBS./FT. PUFtPOSE SACKS CEMENT A NIOUNT PULLED
10-3/4" 172' DF I 15" 32# Surface 110
1
None
SIZE I
LINER RECORD
TOP (MD) BOTTOM (MD) SACKS CEMENT• SCREEN (MD) 1. SIZE
None
TUBING RECORD
DEPTH SET (MD) PACKER SET (MD)
PRODUCTION
DATE FIRST PRODUCTION 'PRODUCING METHOD (Flowing, gas lift, pumping,—size & type of pump) WELL STATUS( Prod. or shut-In)
Dry hole
DATE OF TEST HOURS TESTEDI CHOKE SIZE !PRODUCTION OIL, Bbis. GAS, Mcf. WATER, Bbls. & % OIL GRAVITY-API (Corr.)
FOR TEST
mow. 1
TUBING PRESSUIRE CASING PRESSURE CALCULATED
24-HOUR RATE
[ L OIL, Bbls. GAS, Mcf. I WATER, Bbls. & % ronlAS-OIL RATIO
DISPOSITION OF GAS (Sold, used for fuel, vented, etc.) TEST WITNESSED BY
LIST OF ATTACHMENTS
IES, Density log, Drilling Time - Sample log, Geological Report , OH DST Report
–Thereby certify that theregoIng and attached information is complete and correct as determined from all available records
oa - - - - - - .- ..- .- .-
CD Ul %.0 C) CO 04 C) .....t CD MD C)
ri Ul r4 0,.. r4 CN I", 04 ON 0 CD
r4 u1 0. 01 CNI %JD 04 01 01 00 04
ri r-I ri rA (..9 (NI on on en on .....t
ca t ion o f t he ce men ting too l.
a
co)
2 -
awvx
a) w P
0 (1.) .1-) 0 4.1
}-I la 0 0 .0 0 ..- 0
0 C.) 0 C.) 0 0 i.1 04
..SZ al on g a o ,-4 ..c ot
n ›...-4 4-) "-I oa a) .0 0 X co
Ov0r-10/-1,000 0 0
0 ,c) 0 .0 } I 0 0 0 0 ni .0
-
IA 0.- 0,0 0'd p. tH a) W
caZonOzco3ZoadP-1
INST RUC TI ONS
Eg
z
o g
N
VI
6 o
C ;
0 g cut'
0
4
6 e
3
-E.
vE '0 0
-5 v Y 1.8
-c 0 sz
2 s-.F. 0
- Z
t
-6 "0 n g
0
-
s
TRUEVERT.
w
DEPTH
z
`O' ° o
N
co 3
0
(11
41 11 [11
E6 E.
fil
DEPTH
g
MEA S. DEPTH
:13
0
-a' a -44
g= w
[4
to
KI NDOFFORMATION
0
B. Dak. Oil & Gas Board
FORM 8
1
0 OIL WELL GAS WELL &DRY FIELD AND POOL, OR WILDCAT
OPERATOR Wildcat
North Central Oil Corporation NO. ACRES IN LEASE
ADDRESS
Spud 5/1/71. Surface casing - 10-3/4" @ 172' DF. Total depth - 4335'
Received verbal approval to plug and abandon.
Plugged and abandoned 5/17/71.
Plug #1 25 sx 3906-3806'
Plug #2 25 sx 2790-2690'
Plug #3 25 sx 1635-1535'
Plug #4 25 sx 210- 156'
Plug #5 10 sx Top of surface dry hole marker erected.
I hereby certify that the foregoing to any work or operation performed is a true and correct report of wick work or operation.
, ,-('-'17"1 2
(-7\ '-',.) '
..:..)..,;;,...
//i90
CORRESPONDENCE
172.
Sincerely
Fred V. Steece
Assistant State Geologist
FVS/dme
cc: Dr. Duncan J. McGregor
State Geologist
Western Field Office
615 Birch Ave.
Rapid City, South Dakota 57701
(605)394-2229
October 1, 1971
Fred V. Steece
Principal Geologist
FVS/dne
cc: Dr. Duncan J. McGregor
souTH DAKerra
If you are considering making a water well out of the abandoned oil
well drill hole, special considerations are necessary to comply with the
State's oil and water laws. The abandoned oil hole must be properly
plugged and the water well properly constructed. All conversion work will
be at your expense. The cost will vary, depending upon the characteristics
of the drill hole, but such cost will be in the neighborhood of $5,000 or
more. Usually another driller and drill rig will have to be arranged for.
This other drill rig and casing and other materials will have to be on
hand to take over immediately after the special oil well plugging is
completed, because the drill hole cannot be left open for any appreciable
length of time without spoiling it. Approval of plans for construction of
the water well will be required, and a bond covering proper construction
may be required. Also, a water right may be required. All of these
arrangements take considerable time to accomplish.
Sincerely,
J. W. Grimes
Chief Engineer
JWG/sjb
cc--Secretary of State
Oil & Gas Board
',State Geologist
MISCELLANEOUS
NO MISCELLANEOUS
INFORMATION FOR THIS WELL
AS OF 5/25/2011