Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
| 35 pin L - Jetronic |
+----------------------------------------------------------------------------+
Seen into the female connectors.
+----------------------------------------------------+
| o o o o o o o o o o o o o o o o o |
+-----+ 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 +----+
| o o o o o o o o o o o o o o o o o o |
| 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 |
+---------------------------------------------------------------+
1. Ignition coil 19. No connection
2. Throttle switch, idle ? 20. Main relay + engine runing
3. Throttle switch, WOT ? 21. No connection
4. Pin 50 via main relay 22. No connection
5. Earth connection 23. No connection
6. Air flow sensor + ? 24. No connection
7. Air flow sensor signal 25. No connection
8. Air flow sensor - ? 26: No connection
9. Air flow sensor air temp. 27. Air flow sensor
10. Main relay, pin 15 28. No connection
11. No connection 29. No connection
12. No connection 30. Injectors
13. Coolant temperature sensor 31. Injectors
14. Injectors 32. Injectors
15. Injectors 33. Injectors
16. Earth connection 34. Auxiliary air valve, bimetal
17. Earth connection 35. Earth connection
18. Throttle switch +
+----------------------------------------------------------------------------+
| 25 pin BOSCH MONOMOTRONIC |
+----------------------------------------------------------------------------+
+-------------------------------------+
| o o o o o o o o o o o o |
+-+ 25 24 23 22 21 20 19 18 17 16 15 14 +-+
| o o o o o o o o o o o o o |
| 13 12 11 10 9 8 7 6 5 4 3 2 1 |
+-----------------------------------------+
1. TD / Kl 1 14. Air Temperature sensor
2. Water Temperature sensor 15. Air condition code -
3. Idle switch - 16. Air condition pump switch
4. Battery Kl 30 17. - Signal to pump relay
5. Earth connection 18. Throttle sensor fullload +
6. Earth or Gear switch 19. No connection
7. Throttle sensor, Idle + 20. Lambda signal
8. Throttle sensor + 5 volt 21. No connection
9. 12 volt after Ignition 22. Diagnose warning lamp / code
10. Lambda sensor code timing - 23. Idle motor
11. Fuel pump code - 24. Idle motor
12. Vapour fuel valve - 25. Earth connection
13. Fuel Injector
+----------------------------------------------------------------------------+
| 25 pin VAG MPI - AUDI 90 (CODE NM, 7A) |
+----------------------------------------------------------------------------+
+-------------------------------------+
| o o o o o o o o o o o o |
+-+ 25 24 23 22 21 20 19 18 17 16 15 14 +-+
| o o o o o o o o o o o o o |
| 13 12 11 10 9 8 7 6 5 4 3 2 1 |
+-----------------------------------------+
1. No connection 14. No connection
2. No connection 15. Temperature sensor
3. Injector 16. Injector
4. Injector 17. Injector
5. Injector 18. Battery
6. No connection 19. Idle speed control valve
7. Fuel pump relay 20. No connection
8. No connection 21. No connection
9. Ignition control unit 22. DEE warning lamp
10. Tachometer 23. No connection
11. Temperature sensor 24. No connection
12. No connection 25. Fuse box
13. No connection
+----------------------------------------------------------------------------+
| 35 pin BOSCH/HITACHI AUDI 200 turbo, with ignition |
+----------------------------------------------------------------------------+
+----------------------------------------------------+
| o o o o o o o o o o o o o o o o o |
+-----+ 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 +----+
| o o o o o o o o o o o o o o o o o o |
| 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 |
+---------------------------------------------------------------+
1. No connection 19. No connection
2. Ign. Coil transistor, earth 20. Throttle switch, idle
3. No connection 21. Fuel pump relay, neg. pulse
4. Hall element, earth 22. Coil transistor, neg. pulse
5. No connection 23. Inlet air temp. sensor
6. Earth connection if automat gear 24. Inlet air temp. sensor
7. R.P.M instrument 25. Hall element, positiv
8. Valve full load, neg. pulse 26. Throttle switch, full load
9. Earth connection 27. Hall element, signal
10. Coolant temperature sensor 28. R.P.M. sensor, switch
11. R.P.M sensor, 135 pulses/revolution 29. R.P.M. sensor, 135 pulses/rev
12. Crankshaft sensor, 60 deg. BTDC 30. No connection
13. Crankshaft sensor, 60 deg. BTDC 31. Fault lamp
14. No connection 32. Brake switz
15. Knock sensor, signal 33. No connection
16. Knock sensor, earth 34. No connection
17. No connection
18. Earth connection 35. Ign. 15
+----------------------------------------------------------------------------+
| 60 pin FORD EEC IV 60 pin |
+----------------------------------------------------------------------------+
+--+ +--+
+-----+ +-------------------------------------------------+ +-------+
| 60 59 58 57 56 55 54 53 52 51 +-+ 50 49 48 47 46 45 44 43 42 41 |
| o o o o o o o o o o | | o o o o o o o o o o |
| +-------------------------------+ +-------------------------------+ |
| | 39 37 35 33 31 |-| 29 27 25 23 21 | |
| | o o o o o o o o o o | | o o o o o o o o o o | |
| | 40 38 36 34 32 |-|30 28 26 24 22 | |
| +-------------------------------+ +-------------------------------+ |
| o o o o o o o o o o | | o o o o o o o o o o |
| 20 19 18 17 16 15 14 13 12 11 +-+ 10 9 8 7 6 5 4 3 2 1 |
+---------------------------------------------------------------------+
1. No connection 31. No connection
2. No connection 32. No connection
3. No connection 33. No connection
4. No connection 34. No connection
5. No connection 35. No connection
6. No connection 36. Ignition ECU/module
7. Coolant temperature sensor 37. Main relay
8. No connection 38. No connection
9. No connection 39. No connection
10. Ignition ECU/module 40. Test socket/self-diagnosis
11. No connection output
12. No connection 41. No connection
13. No connection 42. No connection
14. No connection 43. Air flow sensor
15. No connection 44. No connection
16. Ignition ECU/module 45. No connection
17. Test socket/self-diagnosis output 46. Air flow sensor
18. No connection 47. Throttle potentiometer/switch
19. No connection 48. Test socket/self-diagnosis
20. Main relay output
21. Idle speed adjuster/idle position switch 49. No connection
22. Fuel pump relay 50. No connection
23. No connection 51. No connection
24. No connection 52. EGR solenoid/sensor
25. Air flow sensor 53. No connection
26. Air flow sensor 54. No connection
Throttle potentiometer/switch 55. No connection
27. Air flow sensor 56. Ignition ECU/module
28. No connection 57. Main relay
29. No connection 58. Injectors
30. Inhibitor switch/idle control valve 59. Injectors
60. Test socket/self-diagnosis
output
+----------------------------------------------------------------------------+
| 104 pin FORD EEC V 104 pin |
| Without passive thieft system (PATS) |
+--+ Look from wire side +--+
+----------+ +-------------------------------------------------+ +-----------+
|78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 00 01 02 03 |
| o o o o o o o o o o o o o o o o o o o o o o o o o o |
| |
| o o o o o o o o o o o o o o o o o o o o o o o o o o |
|52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 |
| |
| o o o o o o o o o o o o o o o o o o o o o o o o o |
|27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 |
| |
| o o o o o o o o o o o o o o o o o o o o o o o o o o |
| 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 |
+------------------------------------------------------------------------------+
Connector diagram is not exact, i would like corrections !
+----------------------------------------------------------------------------+
| 104 pin FORD EEC V 104 pin |
| With passive thieft system (PATS) |
+--+ Look from wire side +--+
+----------+ +-------------------------------------------------+ +-----------+
|78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 00 01 02 03 |
| o o o o o o o o o o o o o o o o o o o o o o o o o o |
| |
| o o o o o o o o o o o o o o o o o o o o o o o o o o |
|52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 |
| |
| o o o o o o o o o o o o o o o o o o o o o o o o o |
|27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 |
| |
| o o o o o o o o o o o o o o o o o o o o o o o o o o |
| 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 |
+------------------------------------------------------------------------------+
1. Aut. gear valve (-) 53. Aut. gear valve (-)
2. 54. - to relay to activate f.pump
3. 55. Battery +12v
4. 56. Valve fuel vap.rec. (-)
5. 57.
6. 58. Speedsensor (VSS)
7. 59.
8. 60. Lambda sensor signal 1
9. 61. Lambda sensor after cat 2
10. Interface to instrument 62.
11. 63.
12. 64. Gear position (resistance)
13. Diagnose 65. EGR flow signal (EPT)
14. 66. Aircondition
15. Diagnose 67.
16. Diagnose 68. To relay start cool vent. 2
17. To relay start cool vent. 1 69. Aircondition
18. 70. Injector (?1 -)
19. 71.
20. Injector (?3 -) 72. Aut. gear valve (-)
21. 73. Heating lambdasensor (-)
22. Fuel pump relay 74.
23. Signal to ign. box (cyl 2 - 6 ?) 75.
24. Earth 76. Common for camshaft/trans
25. 77. Earth
26. 78.
27. Aut. gear potentiometer 79. To instrument interface
28. 80. Aut. gear valve (-)
29. -signal to gear selector 81. Aut. gear valve (-)
30. Octan selection 82.
31. 83. Idle speed adjuster (mA)
32. 84. Transmision signal (hall?)
33. 85. Camshaft signal (hall?)
34. 86. To instrument interface
35. Lambda sensor signal after cat 1 87. Lambda sensor signal 2
36. Hot wire flowmeter (MAF) 88. Hot wire flowmeter (MAF)
37. Aut. gear potentiometer 89. Throttle potentiometer (TPS)
38. Coolant temperature sensor 90. +5v to throttle pot. and EPT
39. Intake air temp (ACT) 91. Earth
40. +12v when fuelpump ON 92. Brake light (+12v)
41. Aircondition 93. Injector (?5 -)
42. 94. Injector (?6 -)
43. To instrument 95. Injector (?4 -)
44. Valve in inlet manifold (-) 96. Injector (?2 -)
45. 97. + to relay to start fuel pump
46. 98.
47. EGR solenoid/sensor (EVR) 99 ڿڿ. Heating lambdasensor (-)
48. Crank pos. from ign. box ���� 100 Heating lambda after cat (-)
49. Signal to ign. box (cyl 3 - 4 ?) 101 Heating lambda after cat (-)
50. Signal to ign. box (cyl 1 - 5 ?) 102
51. Earth 103 Earth
52. 104
+----------------------------------------------------------------------------+
| 42 pin TOYOTA 4A-FE?, ND 175 731-0132 |
+----------------------------------------------------------------------------+
Seen into ECM male connections.
+--+ +------+ +--+ +--+ +---------------+ +--------------------+ +--+
+--+--+------+--+--+ +--+--+---------------+--+--------------------+--+--+
|B5 B4 B3 B2 B1| |A13 A12 A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 A1 |
|o o o o o | |o o o o o o o o o o o o o |
| | | |
|o o o o o | |o o o o o o o o o o o o o |
|B10 B9 B8 B7 B6| |A26 A25 A24 A23 A22 A21 A20 A19 A18 A17 A16 A15 A14|
+------------------+ +---------------------------------------------------+
+----------------------------------------------------------------------------+
| 42 pin TOYOTA 4A-FE old |
+----------------------------------------------------------------------------+
Connections ??
+--+ +-------+ +--+ +--+ +--+ +----------------------+ +--+ +--+
+--+--+-------+--+--+ ++--+--+--+----+----------------------+----+--+--+--++
|B1 B2 B3 B4 B5 | |A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 |
|o o o o o | |o o o o o o o o o o o o o |
| | | |
|o o o o o | |o o o o o o o o o o o o o |
|B7 B8 B9 B10 B11| |A14 A15 A16 A17 A18 A19 A20 A21 A22 A23 A24 A25 A26 |
+-------------------+ +----------------------------------------------------+
+----------------------------------------------------------------------------+
| 42 pin TOYOTA 4E-FE, Corolla 1.3 GLi/XLi 92-> |
+----------------------------------------------------------------------------+
+--+ +---------------+ +--+
+-+--+--+---------------+--+--+-+
|B1 B2 B3 B4 B5 B6 B7 B8 |
|o o o o o o o o |
| |
|o o o o o o o o |
|B9 B10 B11 B12 B13 B14 B15 B16|
+-----+-------------------+-----+
+----------------------------------------------------------------------------+
| 54 pin TOYOTA 4A-FE new |
+----------------------------------------------------------------------------+
+----------------------------------------------------------------------------+
| 64 pin Hella MPFI til Audi V6 2.6l 110 kW |
+----------------------------------------------------------------------------+
I am not shure that the pin numbers is aranged in the right order ?
+----------------------------------------------------------------------------+
| 68 pin ? AUDI/VW ADY 85 kW engine, 1996 SIMOS |
+----------------------------------------------------------------------------+
Connector diagram ??
+----------------------------------------------------------------------------+
| 68 pin VW VR6 128 kW AAA engine, 10.91-> |
+----------------------------------------------------------------------------+
+----------------------------------------------------------------------------+
| 45 pin VW DIGIFANT 2.0 85 kW. 2E motor 10.91-> |
+----------------------------------------------------------------------------+
???
1. Earth connection 24. No connection
2. Injectors 25. No connection
3. 26:
4. + 30 connection 27.
5. 28.
6. Coldstart injector 29. No connection
7. Ignition coil (2) 30. - pulse idle regulator (mA?)
8. Main relay, - pulse 31. Pump relay, - pulse
9. Screen cable Knock sensor 32. Starter connector 50
10. 33. - pulse valve vapour canister
11. 34. - knock sensor
12. Coolant temperature sensor 35. - air flow sensor
13. 36. + signal knock sensor
14. Air flow sensor, signal 37. Intake air temp. signal
15. 38. Ign. conn. 15
16. + 5 V. Air flow sensor 39.
17. Lambda sensor signal 40. Idle sensor signal
18. 41. Idle + 5 V.
19. No connection 42. Lambda sensor signal
20. - pulse heat lambda sensor 43. Diagnose K signal
21. Screen lambda signal 44. Hall sensor signal
22. 45. Hall sensor + signal
23. + 30, 12v from main relay
+-----------------------------------------------------------------------------+
| 45 pin VW 1.4 l ABD, 10.91-> Bosch MonoMotronic |
+-----------------------------------------------------------------------------+
01 Earth connection 24 -Ign. pulse signal to ign. box
02 �Idle speed reg. 25 -To fuel pump relay
03 -Valve vapour canister valve 26 �Idle speed reg.
04 27
05 28 -Signal to intake heat relay
06 29 K diagnose connector
07 -pulse to Injector 30
08 + 5/10V ? to Hall element 31
09 RPM signal to Instr./Autogear box 32
10 Idle throttle switch 33
11 Output to diag. LED instrument ? 34
12 35
13 Signal from Hall element 36
14 5V to throttle pot. meter 37
15 -Lambda sensor 38 Lambda signal
16 39
17 -Air/Water-temp/Throtlle pot. 40
18 +Throttle signal, low ? 41 +Throtlle signal, high ?
19 42 Water temp sensor signal
20 Earth connection 43 Air temp sensor signal
21 +12 V to box and vapour canister valve 44 Screen lambda sensor
22 45
23 +12 V with ign. to box
+-----------------------------------------------------------------------------+
| 45 connections VW 1.8l AAM, 1.8l ABS 10.91-> Bosch MonoMotronic |
+-----------------------------------------------------------------------------+
01 Earth connection 24 -Ign. pulse signal to ign. box
02 �Idle speed reg. 25 -To fuel pump relay
03 -Valve vapour canister valve 26 �Idle speed reg.
04 27
05 28 -Signal to intake heat relay
06 29 K diagnose connector
07 -pulse to Injector 30
08 + 5/10V ? to Hall element 31
09 RPM signal to Instr./Autogear box 32
10 Idle throttle switch 33 Signal to box, Clima control
11 Output to diag. LED instrument ? 34 Signal to box, Auto gear shift
12 Signal to box, Auto gear in drive 35 Signal to box, Clima compr.
13 Signal from Hall element 36 Hall-element speed signal
14 5V to throttle pot. meter 37
15 -Lambda sensor 38 Lambda signal
16 Signal Idle speed adjuster sensor_||_||_ 39
17 -Air/Water-temp/Throtlle pot. 40
18 +Throttle signal, low ? 41 +Throtlle signal, high ?
19 42 Water temp sensor signal
20 Earth connection 43 Air temp sensor signal
21 +12 V to box and vapour canister valve 44 Screen lambda sensor
22 45
23 +12 V with ign. to box
+-----------------------------------------------------------------------------+
| 45 connections VW 1.3 l ADX, 1.6l AEA ->8.95 Bosch MonoMotronic MA 1.3 |
+-----------------------------------------------------------------------------+
01 Earth connection 24 -Ign. pulse signal to ign. box
02 �Idle speed reg. 25 -To fuel pump relay
03 -Valve vapour canister valve 26 �Idle speed reg.
04 27
05 28 -Signal to intake heat relay
06 29 K diagnose connector
07 -pulse to Injector 30
08 + 5/10V ? to Hall element 31
09 RPM signal to Instr./Autogear box 32
10 Idle throttle switch 33 Signal to box, Clima control
11 34 Signal to box, Auto gear shift
12 Signal to box, Auto gear in drive 35 Signal to box, Clima compr.
13 Signal from Hall element 36 Hall-element speed signal
14 5V to throttle pot. meter 37
15 -Lambda sensor 38 Lambda signal
16 Signal Idle speed adjuster sensor_||_||_ 39 Knock sensor signal
17 -Air/Water-temp/Throtlle pot. 40
18 +Throttle signal, low ? 41 +Throtlle signal, high ?
19 -Knock sensor 42 Water temp sensor signal
20 Earth connection 43 Air temp sensor signal
21 +12 V to box and vapour canister valve 44 Screen lambda sensor
22 45 Screen for knocksensor
23 +12 V with ign. to box
+----------------------------------------------------------------------------+
| 45? connections VW 1.4 l AEX 1996->, Bosch Motronic MP 9.0 |
+----------------------------------------------------------------------------+
+----------------------------------------------------------------------------+
| 45? connections VW 1.6 l AEE 1996->, Magnet Marelli 1AV |
+----------------------------------------------------------------------------+
+----------------------------------------------------------------------------+
| 35 connections VW 1.0/1.3/1.6 l engine, ->8.95 Bosch MonoMotr. MA 1.2.3 |
+----------------------------------------------------------------------------+
01 Earth connection 19 +12 V with ign. to box
02 +Bat 20 Signal to box, Auto gear shift
03 Clima compressor 21 Signal to box, Auto gear in drive
04 Clima control 22 L-diagnose connector Activate
05 Signal from Hall-element 23 K-diagnose connector Bidirectionel
06 + 5/10V ? to Hall element 24 5V to throttle pot. meter
07 25 +Throtlle signal, low
08 -Air/Water temp/Throtlle pot. 26 +Throtlle signal, high
09 To change parameters 27 Air temp sensor signal
10 Water temp sensor signal 28 Lambda sensor signal
11 Earth connection 29 Hall-element speed signal
12 -To fuel pump relay 30 Idle throttle switch
13 -Ign. pulse signal to ign. box 31 Rpm signal out
14 Lambda code 32 Fuel signal to instrument
15 -Signal to intake heat air relay 33 Fail lamp (Californien)
16 �Idle speed reg. 34 �Idle speed reg.
17 Vapour canister valve 35 -Pulse to Injector
18 Earth connection ign. box
- 20 deg.C = 4.2 V
- 10 deg.C = 3.6 V
0 deg.C = 3.1 V
10 deg.C = 2.7 V
20 deg.C = 2.3 V
30 deg.C = 1.9 V
40 deg.C = 1.5 V
50 deg.C = 1.2 V
60 deg.C = 0.9 V
70 deg.C = 0.7 V
80 deg.C = 0.5 V