Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
¬ PC Webcams ¬ Telepresence
Product Features
¬ programmable controls: gain, exposure, ¬ support for one lane MIPI interface
frame rate, image size, horizontal (up to 800 Mbps) Product Specifications
mirror, vertical flip, cropping,
windowing, and panning ¬ support for 8-/10-bit RAW RGB output ¬ active array size: 1920 x 1080 ¬ scan mode: progressive
format
¬ automatic image control functions: ¬ power supply: ¬ maximum image transfer rate:
- automatic exposure (AEC) ¬ support for image sizes: - analog: 3.0 ~ 3.6V (3.3V typical) - 1080p: 30 fps
- automatic gain control (AGC) - 1080p at 30 fps - core: 1.425 ~ 1.575V (1.5V typical) - cropped 720p: 60 fps
- automatic white balance (AWB) - cropped 720p at 60 fps - I/O: 1.7 ~ 3.6V (1.8V typical) - VGA: 120 fps
- automatic black level - VGA at 120 fps - QVGA: 240 fps
calibration (ABLC) ¬ power requirements:
¬ support for black sun cancellation - active: 350 mW ¬ sensitivity: 3700 mV/lux-sec
¬ serial camera control bus (SCCB) - power down: 70 µA
¬ embedded one-time programmable ¬ shutter: rolling
¬ lens correction (LENC) (OTP) memory ¬ temperature range:
- operating: -30°C to +85°C junction ¬ max S/N ratio: 40 dB
¬ defect pixel correction (DPC) ¬ on-chip phase lock loop (PLL) temperature
- stable image: 0°C to +65°C junction ¬ dynamic range: 69 dB @ 8x gain
¬ support for digital video port (DVP) ¬ built-in 1.5V regulator for core temperature
parallel output interface ¬ maximum exposure interval: 1096 tline
¬ output interfaces: 10-bit parallel/
¬ integrated auto focus filter one lane MIPI ¬ pixel size: 3 µm x 3 µm
OV2710
image sensor core image sensor image output
processor interface
column
sample/hold
DVP
D[9:0]
row select
format
image 10-bit
LENC
DPC
array AMP
ADC MCP/N (VSYNC/HREF)
FIFO
MIPI
MDP/N (D9/D7)
gain control
timing generator and system control logic PLL SCCB slave interface
PWDN
RESETB
TM
VSYNC
HREF
PCLK
XVCLK
SIOC
SIOD
4275 Burton Drive Tel: + 1 408 567 3000 OmniVision reserves the right to make changes to their products or to discontinue any product or
service without further notice. OmniVision, the OmniVision logo and OmniPixel are registered
Santa Clara, CA 95054 Fax: + 1 408 567 3001 trademarks of OmniVision Technologies, Inc. OmniPixel3-HS is a trademark of OmniVision
USA www.ovt.com Technologies, Inc. All other trademarks are the property of their respective owners.