Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
MANUFACTURER KUBOTA
INJECTION
PUMP 094500-638#
ENGINE TYPE EA300-ENB1
INJECTION TIMING
Rotation Counterclockwise viewed from drive side (Pre-stroke check)
Cockwise viewed from drive side (Delivery quantity adjustment)
TEST CONDITIONS
Nozzle : 093400-0800 (DN4SD24NK80) Test Oil : SAE J967 (ISO4113)
+0.98 + 10
Nozzle Opening Pressure : 13.7 MPa ( 140 kgf/cm2) High Pressure Pipe : Ø2 × Ø6 × 600 mm
0 0
Feed Pressure : 30.0 ± 5.0 kPa ( 0.3 ± 0.05 kgf/cm2) Fuel Temperature : 40 - 45°C (104 - 113°F)
1700 3.00 0 0 — —
NOTE :
1. Rack Position display during Injection Quantity Adjustment
At a rack position of X : Np = 1200 rpm and 25.0 ± 1.5 mm3/st (5.0 ± 0.3 cc/200st),
scratch position lines on the housing and rack.(fig.1)
2. Confirm that the injection quantity is the specified value 11.0 ± 7.5 mm3/st
(2.2 ± 1.5 cc/200st) at the prescribed speed (1500 rpm) when the rack position is
X – 2.00 mm.
3. Confirm that the injection quantity of each cylinder is 0 (no injection) when the rack
position is 3.00 mm at the prescribed speed (1700 rpm). Position Lines
Rack Pin
fig 1
2005.10.13