Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
power supply
IEC 61000–6–2, EN 61000–6–2
3 x 10/100/1000 BaseT
GbE IEC 61000–6–4, EN 61000-6–4
power supply
GbE
2 x GbE / 10 GbE SFP
12 x alarm input IEC TS 61000–6–5
8 x 2 Mbps
1 x LCT Port IEEE 1613
CESM1 2 x alarm output
8 x 2 Mbps
U-16.2 x
8 x 2 Mbps LEDE1
Data access G.703 / G.704 1000 BASE-SX x x
1000 BASE-LX x x
8 x 2 Mbps 8 x 2 Mbps
1000 BASE-TX x x
GbE *CEPI1
GbE Circuit emulation G.703 / G.704 1000 BASE-EX x x
1000 BASE-ZX x x
3 2 x 2 Mbps
10 GBASE-LR x
GbE *COSI1
GbE Voice over IP Main FOXMAN-UN network management system features
© ABB Switzerland Ltd, October 2013. The right to modifications or deviations due to technical progress is reserved.
DSL
Chassis switch modules modules
www.abb.com/communicationnetworks
Technical data of FOX612 & FOX615
Most used SFPs also available: CWDM, DWDM; single-fiber, electrical signal
Core modules Traffic protection 1+1 path protection Transmission range Up to 25 km GbE Gigabit Ethernet
Features Member of chassis switch GFP Generic Framing Procedure
Ethernet switching and routing modules PPPoE HDLC High-Level Data Link Control
CESM1 control unit ELET1 L1/L2 Ethernet
Remote desktop modules IF InterFace
Management interfaces 10/100/1000 BaseT (IEEE 802.3) Number of physical ports 24 x 10/100/1000 BaseT, RJ45 connector
DTM-M SHDSL desktop IP Internet Protocol
DCC-interfaces Features Member of chassis switch
Number of transmission ports 1 x 1-pair or 2-pair LAG Link Aggregation
Synch I/O 2048 kHz: 2 synch inputs, 2 synch outputs Two-slot unit
Number of access ports fixed G.703/G.704 120 Ω or 1 modular inter- LCAS Link Capacity Adjustment Scheme
Alarm I/O 12 alarm inputs, 2 alarm relay outputs Traffic protection Chassis switch features
face (G.703/G.704 75 Ω, V.24, X.21/V.11, V.35, LT Line Termination
Main features Central processing unit, DCN IP routing, Ethernet ETOP1 L1/L2 Ethernet V.36, Ethernet) LTP Linear Trail Protection
crossbar, Ethernet aggregation Number of physical ports 12 x GbE, SFP based Line code 16 Trellis coded-PAM according G.991.2 MCAS Mercury-CAS
1+1 equipment protection, (warm standby)
Line rate n x 64 kbit/s duplex via 1 or 2 copper pair,
Number of Ethernet ports 3 x 10/100/1000 BaseT MCMI Modified Code Mark Inversion
Features Member of chassis switch n = 3 ... 32
2 x GbE/10 GbE, SFP + based MIB Management Information Base
Traffic protection Chassis switch features Service rate n x 64 kbit/s duplex via 1 or 2 copper pair,
1 x LCT Port
EPOI1 L2 Ethernet with PoE n = 1 ... 32 MLPPP Multi Link Point to Point Protocol
Ethernet features Ethernet aggregation unit
GbE/10 GbE uplink Number of physical ports 12 x 10/100/1000 BaseT, RJ45 connector with Transmission range Up to 25 km MM Multi Mode
ERPS acc. ITU-T G.8032 (future release) Power over Ethernet (PoE) Options Remote powering MSP Multiplex Section Protection
LAG acc. IEEE 802.1AX (future release) Power over Ethernet According to ITU-T 802.3af and 802.3at MSTP Multiple Spanning Tree Control
Local power supply 115/230 VAC: 88 VAC … 264 VAC, 50/60 Hz
Chassis switch features Control of chassis switch Max. 84 W per module
48 VDC: - 38 VDC … - 60 VDC NE Network Element
Distributed switching architecture with centralised Max. 30 W per port (PoE+)
64 Gbps Ethernet crossbar for intermodule switching SHDSL REG SHDSL regenerator NT Network Termination
Features Member of chassis switch
RSTP, MSTP acc. IEEE 802.1W/8021Q Line code 16 Trellis coded-PAM according G.991.2 OHC Overhead Channel
Traffic protection Chassis switch features
VLAN Q-in-Q Types Indoor (IP21), outdoor (IP54), underground (IP68) OSPF Open Shortest Path First
ERPS acc. ITU-T G.8032 (future release) EPSI1 L2/L3 Ethernet
acc. IEEE 802.1ad Power options Local 48 VDC power or remote power feeding PAM Pulse Amplitude Modulation
Number of physical ports 4 x 10/100 BaseT, RJ45 connector
FAMO1 fan unit For FOX615 PDH Plesiochronous Digital Hierarchy
Number of PDH ports 64 x TDM bus access
Number of fans 10 Max. 8 x P12 (n x 64 kbit/s granularity) or Configuration and management (software packages) PoE Power over Ethernet
Operation Temperature controlled max. 16 x P12 (n x 128 kbits/s granularity) FOXCST configuration tool PPP Point to Point Protocol
PPP / MLPPP / HDLC traffic encapsulation Features Remote and local configuration
Installation Above equipment, PSTN Public Switched Telephone Network
1HU, no mechanical slot required L2-switching features According to IEEE 802.1D and 802.1Q Remote and local analysis & error detection
Traffic prioritization according to IEEE 802.1p Remote supervision PWE Pseudo Wire Emulation
FAMO2 fan unit for FOX612 Up to 8 independent switching instances RIP Routing Information Protocol
Operating system Windows® 2000, Windows® XP
Number of fans 4 L3-routing features OSPF v2 acc. RFC 2328, RIP v2 acc. RFC 2453 Windows® Vista, Windows® 7 RSTP Rapid Spanning Tree Protocol
Operation Temperature controlled Static routing, VRRP, Inter-VLAN routing Managed equipment FOX615, FOX612 Rx Receiver
Installation Above equipment, no mechanical slot required Traffic protection MLPPP, RSTP, VRRP, OSPF v2, RIP v2 FOXMAN-UN network management system SDH Synchronous Digital Hierarchy
Compatibility ETER1, LAWA4, OPTIF, DATAx, LEDS1, Features Graphical display of network SHDSL Single pair High-speed Digital Subscriber Line
DATI1 / STICx / DTM-M
Aggregate modules
Network element supervision SETS Synchronous Equipment Timing Source
Equipment protection 1+1 HW protection Fault & configuration management
SFP Small Form-factor Pluggable
Operating system Linux Red Hat
Analogue telephony modules SIP Session Initiation Protocol
Options Performance management, ITU-T G.826
SDH aggregate modules LEXI1 FXO Multiple working places SM Single Mode
SAMO1 optical/electrical SDH Main - standby solutions SNCP Sub-Network Connection Protection
Number of ports 12 x 2-wire FXO
Trail handling (networking package) SNMP Simple Network Management Protocol
Number of SDH ports 4 (2 x STM-1, 2 x STM-1/4 SFP-cage) according ITU-T Q.522 (Z-interface)
Synchronization map
SFPs available with optical LC/PC (STM-1/4) or Coding A-law according ITU-T G.711 STM Synchronous Transport Module
SNMP northbound/southbound
electrical DIN 1.0/2.3 75 Ω (STM-1) connector
Input (from exchange) - 5 ... + 4 dBr, programmable Managed equipment FOX515, FOX512, FOX615, FOX612, FOX660, STP Spanning Tree Protocol
Number of Ethernet ports 4 x 10/100/1000 BaseT
Output (to exchange) - 7.5 ... - 3 dBr, programmable ETL600, AFS670, AFR670, AG100 and other TCPAM Trellis-Coded Pulsamplitudemodulation
RJ-45 connector
equipment
SDH features 18 x 18 VC-4 HO cross connect Nominal impedance Complex or 600 Ω TDM Time Division Multiplex
36 x 36 VC-3 or 693 x 693 VC-12 LO cross connect Channel bandwidth 300 ... 3400 Hz TPE TeleProtection Equipment
Max. 64 x P12 termination to TDM BUS Signalling & functionality Seizure, ringing, ringing off, transmission of flash Tx Transmitter
Ethernet features L1-Ethernet over SDH functionality pulses, pulse dialling, DTMF without accompanying VC Virtual Container
Support of GFP / VCAT / LCAS signal, earth key, charging using 12/16 kHz pulses
VCAT Virtual Concatenation
Traffic protection SNCP / MSP for SDH traffic (intra module) LEDA1 voice and E&M
LCAS for Ethernet traffic VLAN Virtual LAN
Number of ports 8 x 2-/4-wire voice channels Note: All modules use one mechanical slot, except where otherwise stated.
SAMO2 optical/electrical SDH according ITU-T G.712 - G.715 VRRP Virtual Router Redundancy Protocol
Exeptions are the fanless modules CESM1-F, ETOP1-F and SAM02-F.
Number of SDH ports 4 (2 x STM-1/4, 2 x STM-4/16 SFP-cage) Coding A-law according ITU-T G.711
SFPs available with optical LC/PC (STM-1/4/16) or Input (from exchange) - 16.0 ... + 9.5 dBr, programmable (DEFM1, CEPI1, COSI1 available in 2014)
© ABB Switzerland Ltd, October 2013. The right to modifications or deviations due to technical progress is reserved.
We reserve all rights in this document and in the information contained therein. This system overview does neither claim completeness nor availability of modules or functions and ABB reserves the right to insert, postpone or remove modules and functions without further notice.
Reproduction, use or disclosure to third parties without express authority is strictly forbidden. © ABB Switzerland Ltd, Power Systems, 2013.