Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SECTION 1. IDENTIFICATION
Product identifier: JAX Magna-Kote® 1020 ISO 220
Part number: 10220
Identified uses: Industrial lubricant
Uses advised against: Any use not specified above, or any use specified against elsewhere in this SDS.
Conditions for safe Store in a cool, dry place in tightly sealed containers. Store out of direct sunlight. Do not store near heat, sparks, open flame,
storage, including any pilot lights, static electricity, or other sources of ignition. Do not store where temperature may exceed 49°C (120°F). Store
incompatibilities: away from oxidizing agents. Rotate stock.
Not available
pH: Not available
Melting / freezing point: Not available Relative density: 1.03 (typical)
Initial boiling point Not available
and boiling range: Solubility in water: Not available
Flash point: Partition coefficient Not available
(n-octanol/water):
Evaporation rate: Not available Autoignition temperature: Not available
Delayed and immediate effects, and chronic effects, from short and long-terms exposure
Effects: Harmful if inhaled. The following percentage of the mixture consists of components(s) with unknown hazards regarding the
acute toxicity: 100 % dermal; 100 % oral; 100 % Inhalation - vapor.
Carcinogenicity: No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated
carcinogen by NTP.
Numerical measures of Not determined
toxicity:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity: Not available
Component Components L(E)C50
information: Component(s) not classified as hazardous and/or not Not available
present at reportable levels
SARA Section 304 Release of the following chemical(s) at quantities equal to or greater than the reportable quantities (RQ), is subject to
CERCLA Hazardous reporting to the National Response Center under CERCLA:
Substances: Propylene oxide, CAS # 75-56-9, RQ = 100 lbs.
1,4-dioxane, CAS # 123-91-1, RQ = 100 lbs.
Ethylene oxide, CAS # 75-21-8, RQ = 10 lbs.
SARA Section 313 Toxic This product contains the following chemical(s) listed in Section 313 at or above the de minimis concentrations:
Chemicals: None
TSCA Inventory: All components are either listed or exempted from listing on the TSCA Inventory.
U.S. State Regulations
California Proposition
This product contains chemical(s) known to the State of California to cancer, birth defects, or other reproductive harm.
65 Status:
California Ethylene oxide (CAS #75-21-8); 1,4-Dioxane (CAS # 123-91-1).
Proposition 65
Listed Components:
International Regulations
Canada: This product has been classified in accordance with the hazard criteria of WHMIS 2015 and the SDS contains all of the
information required by those regulations.
Japan MITI: Not available
Australia: Not available
Switzerland: Not available
The information and recommendations contained herein are, to the best of JAX INC's knowledge and belief, accurate and reliable as of the date issued.
JAX INC makes no warranty or guarantee, expressed or implied, of their accuracy or reliability, and JAX INC shall not be liable for any loss or damage based
upon the criteria supplied by the developers of these rating systems, together with JAX INC's interpretation of the available data.