Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
DATA SHEET
ECRF Cold Fusion Black Cement
(CC-ECRF-001, CC-ECRF-002, CC-ECRF-010, CC-ECRF-200)
Date Prepared: Aug 10, 2016
HAZARD CLASSIFICATION ……………………… Flammable Liquids — Category 2.
Skin Irritation — Category 2.
Germ Cell Mutagenicity — Category 1B.
Carcinogenicity — Category 1A.
Reproductive Toxicity — Category 1B
Eye Irritation — Category 2A.
Specific Target Organ Toxicity — Category 2, Category 3 (narcotic effects) single exposure.
Aspiration Hazard — Category 1.
SIGNAL WORD ………………………………..…. Danger.
HAZARD STATEMENTS ……………………….. H225 Highly flammable liquid and vapour.
H304 May be fatal if swallowed or enters airways.
H315 Causes skin irritation.
H319 Causes serious eye irritation.
H336 May cause drowsiness or dizziness.
H340 May cause genetic defects.
H350 May cause cancer.
H360 May damage fertility or the unborn child.
H373 May cause damage to organs through prolonged or repeated exposure.
PRECAUTIONARY STATEMENTS …………. P210 Keep away from heat/ sparks/ open flames/ hot surfaces. No Smoking.
P233 Keep container tightly closed.
P240 Ground/ bond container and receiving equipment.
P241 Use explosion-proof equipment: electrical/ ventilating/ lighting.
P242 Use only non-sparking tools.
P243 Take precautionary measures against static discharge.
P261 A dust/ fume/ gas/ mist/ vapour spray.
P264 Wash skin thoroughly after handling.
P270 Do not eat, drink or smoke when using this product.
P271 Use only outdoors or in a well-ventilated area.
P280 Wear protective gloves/ eye protection/ face protection.
P403+P405+P235 Store locked up in a well-ventilated place. Keep cool.
Page 1 of 5
SAFETY DATA SHEET
ECRF Cold Fusion Black Cement
(CC-ECRF-001, CC-ECRF-002, CC-ECRF-010, CC-ECRF-200)
Date Prepared: Aug 10, 2016
SECTION 03: COMPOSITION/INFORMATION INGREDIENTS
HAZARDOUS INGREDIENTS CAS# WT %
Ethyl Acetate 141-78-6 10-30
Heptanes 142-82-5 10-30
Toluene 108-88-3 10-30
Acetone 67-64-1 5-10
SECTION 04: FIRST AID MEASURES
EYE CONTACT ……………………………………. Immediately flush with water for a minimum of 20 minutes. Get medical attention.
SKIN CONTACT ………………..................... Remove contaminated clothing. Wash affected area with water and soap. Seek medical attention if
irritation occurs or persists.
INGESTION …………………………………………. Rinse mouth with water. Do not induce vomiting, aspiration hazard. Get immediate medical attention.
INHALATION …………………………………….… If overexposure occurs, remove to fresh air.
SECTION 05: FIRE FIGHTING MEASURES
FLAMMABILITY …………………………………… Extremely flammable.
IF YES, UNDER WHICH CONDITIONS? …. Excessive heat, sparks and open flame.
EXTINGUISHING MEDIA ……………………... Carbon dioxide, dry chemical, foam, water fog.
HAZARDOUS COMBUSTION PRODUCTS . Combustion will result in the usual decomposition products, including oxides of carbon.
SPECIAL PROCEDURES ………………………... Firefighters should wear the usual protective gear; self-contained breathing apparatus.
Page 2 of 5
SAFETY DATA SHEET
ECRF Cold Fusion Black Cement
(CC-ECRF-001, CC-ECRF-002, CC-ECRF-010, CC-ECRF-200)
Date Prepared: Aug 10, 2016
SECTION 09: PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE ….................................... Black liquid.
ODOUR ................................................... Mild solvent odour.
ODOUR THRESHOLD (ppm) ................... Not available.
pH ………………………………………………………… Not applicable.
BOILING POINT …………………………………….. 89°C (192°F).
FLASH POINT (METHOD) ........................ <-18°C (0°F) (Acetone) (TCC).
LOWER EXPLOSIVE LIMIT ……………………. 1.1%.
UPPER EXPLOSIVE LIMIT ……………………... 12.8%.
EVAPORATION RATE …………………………….. 4.4 (BUTYL ACETATE = 1).
VAPOUR PRESSURE (mm Hg) …................ 60 @ 20°C (68°F).
VAPOUR DENSITY (AIR=1) ....................... 3.1.
SPECIFIC GRAVITY ……………………………… 0.82 @ 20°C (68°F).
SOLUBILITY IN WATER (% W/W) ….......... Insoluble.
COEFFICIENT OF WATER/OIL
DISTRIBUTION …………………………………….. Not applicable.
AUTO IGNITION TEMPERATURE …………. Not available.
DECOMPOSITION TEMPERATURE ……….. Not available.
.
VISCOSITY ………………………………………….. Approximately 2000 mPa s @ 20°C (68°F).
Page 3 of 5
SAFETY DATA SHEET
ECRF Cold Fusion Black Cement
(CC-ECRF-001, CC-ECRF-002, CC-ECRF-010, CC-ECRF-200)
Date Prepared: Aug 10, 2016
EFFECTS OF CHRONIC EXPOSURE ……….. May cause damage to the central nervous system, respiratory system, lungs, eyes, skin,
gastrointestinal tract, liver, spleen and kidneys.
IRRITANCY OF MATERIAL …………………... Refer to route of entry.
SENSITIZING CAPABILITY OF MATERIAL See effects of acute exposure.
CARCINOGENICITY OF MATERIAL. ……… Not available.
TERATOGENICITY ………………………………. Not available.
MUTAGENICITY …………………………………. Not available.
REPRODUCTIVE EFFECTS ……………………. Not available.
SYNERGISTIC MATERIALS ……………………. Not available.
OTHER ……………………………………………….. This product contains the following chemicals known to the state of California (proposition 65) to
cause cancer or reproductive toxicity - Toluene.
SECTION 12: ECOLOGICAL INFORMATION
BIODEGRADABILITY ENVIRONMENTAL .
TOXICITY TO FISH ………………………………. LC50:
Ethyl Acetate: ((pimephales promelas (fathead minnow)): >100 mg/l 96 hour flow through.
Heptanes: No data available.
Toluene: No data available.
Acetone: ((oncorhynchus mykiss (rainbow trout)): 5540 mg/l static test.
TOXICITY TO AQUATIC INVERTEBRATES .. EC50:
Ethyl Acetate: ((daphnia magna (water flea)): >100 mg/l static test.
Heptanes: No data available.
Toluene: No data available.
Acetone: No data available.
TOXICITY TO ALGAE ……………………………. EC50:
Ethyl Acetate: ((desmodesmus subspicatus (green algae)): >100 mg/l 72 hour static test.
Heptanes: No data available.
Toluene: No data available.
Acetone: ((chlorella pyrenoidosa) (algae)): 3020 mg/l 14 day.
BIOACCUMULATION …………………………... No data available.
MOBILITY IN SOIL ……………………………….. No data available.
OTHER ADVERSE EFFECTS …………………. No data available.
Page 4 of 5
SAFETY DATA SHEET
ECRF Cold Fusion Black Cement
(CC-ECRF-001, CC-ECRF-002, CC-ECRF-010, CC-ECRF-200)
Date Prepared: Aug 10, 2016
SECTION 16: OTHER INFORMATION
This information is furnished without warranty, representation, inducement or license of any kind, except that it is accurate to the best of Shaw
Almex Industries knowledge or is obtained from sources believed by Shaw Almex Industries to be accurate. Shaw Almex Industries makes no
representation and assumes no liability for any direct, incidental or consequential damages resulting from its use or reliance on same. Customers
are encouraged to conduct their own tests.
PREPARED BY: Shaw Almex Industries
Page 5 of 5