Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1 Solution of USMS
1.1 Diagram
IP/E1 Network
IP/E1 IP/E1
Indoor Site Outdoor Site
AC meter
AC meter
Air-Condition
Controller
3. Site installation - include EISU , all kinds of sensors and intelligent devices installation work.
2 Site layout
3 Equipments of site:
3.1 EISU
ZNV EISU100 V2 intelligent supervision unit is based on advanced embedded hardware
platform to analysis and storage the collected analog signal, digital signal, image and other data from
intelligent device and transmission to the supervision center.
Front-Panel
Back-Panel
PIN Description
Tamper 1 To prevent to be dismantled
Tamper 2
Alarm 1 Alarm signal(Relay, 2 Status: opened and closed )
Alarm 2
+12v Power +
GND Power -
X4
X3
X1
X2
3.5 TH sensor
3.6 DTH
Attention: In sensor side , just connect the Red color and green color cable, and in EISU
side , find the label, connect the the male an female head together according to the label.
Attention: In sensor side , just connect the Red color and green color cable, and in EISU
side , find the label, connect the the male an female head together according to the label.
Attention: If the site has Li-battery rack , please connect the door magnetic switch
according to the following diagram.
3.9 Rectfier
In EISU side ,find the label “Rec Com” , and join the connectors together .
In Rectifier side , Find the Rs232 port , and connect the 9‐Pins port to Rectifier RS232 port.
There are two different modules for battery management , BM31 and BM30.
Attention: