Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
PUDUCHERRY CAMPUS
Department of Mechanical Engineering
Course: M. Tech Energy Sub: Solar Energy
Systems
Sub. Code: 13276E32C
a. Horizontal
2. Explain name of various equipment used for measurement of solar energy with
their use
3. Determine the solar radiation Hav received on a horizontal surface on the earth
at 7hrs. 19mtsc
5. Calculate the top loss coefficient for a single glass cover with the following details:
Plate emittance 0.95
Plate to cover spacing 2.54 cm
Ambient temperature 250c
Wind speed 3.0m/s
Back insulated thickness 5cm
Insulation conductivity 0.05w/m k
Mean plate temperature 750c
Collector tilt 400c
UNIT-II
. UNIT-III
15. Compute the required system output and current of a PV array for 200watt load needed for
18hr at 12 volt. At jodhpur for its means horizontal insulation of H0=5.94 kwh/m2-day, battery
charging efficiency=0.9, battery self-discharge efficiency=0.95 and variability factor of 0.9.
16. If the dark saturation current of solar cell current of a solar cell is 1.7x10-8A/m2.the cell
temperature is 270c and the short-circuit current dencity is 250A/m2, calculate the open circuit
voltage ,Voc:voltage at maximum power, Vmax: current density of maximum power, Imax:
maximum power and maximum efficiency, ก max, what cell area required to get an out put of
20w when the available solar radiation is 820W/m2?
Unit4
Part A (2mark)
1. Define modules.
4. What is the relation between absolute air mass and relative Incident radiation?
10. Compare the cost/KW of solar power(PV cell) with other renewable energy sources
3.Explain
Design.
UNIT V
Part A (2mark)
6. What is mean by ventilation and infiltration of air space heating and cooling.
7.Write the building structural mass for thermal energy storage depends
ambient temperature is 10c and the storage tank temperature is 800c Estimate the space
load, domestic water heating load and auxiliary energy required if the following apply
(d) Environmental temperature at the space where storage tank is located =150c