Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Input
www.strongtie.com/fd Page 1 of 5
Fastener Designer: Solutions Report
Report Generated: September 12, 2019
Calculation
5.15 2.61
1.02 0.70
0.85 1.12
3.03 2.49
Penetration Check
Penetration Check Detail Standard Lag Screw Strong-Drive® SDS HEAVY-DUTY Screw
Penetration, p (in) 3.22 1.63
Minimum Penetration Requirement, Pmin (in) 4D = 2.00 6D = 1.45
Minimum Penetration Requirement Met Yes Yes
End Distance, Edge Distance, and Spacing Standard Lag Screw Strong-Drive® SDS HEAVY-DUTY
Screw
End distance, edge distance, and See figure below the fastener image
fastener spacing to meet NDS for end distance, edge distance, and
requirements spacing requirements
www.strongtie.com/fd Page 2 of 5
Fastener Designer: Solutions Report
Report Generated: September 12, 2019
Yield Mode Yield Limit Equation Standard Lag Screw Strong-Drive® SDS HEAVY-DUTY Screw
Yield Limit, Z Reduction Term, RD Yield Limit, Z Reduction Term, RD
Mode Im Z = 606 lb RD = 5.0 Z = 452 lb RD = 2.4
1. The minimum yield value is calculated based on NDS and is only applicable for lag screws with adequate end distance,
edge distance, and spacing per NDS.
2. Adjusted yield value includes the adjustment factors selected above.
www.strongtie.com/fd Page 3 of 5
Fastener Designer: Solutions Report
Report Generated: September 12, 2019
Solution
Substitute (2) 1/4" × 2 1/2" Strong-Drive® SDS HEAVY-DUTY CONNECTOR Screws SDS25212 for (1)
Standard Lag Screw
A 1/4" diameter high-strength structural wood screw ideal for various connector installations as well as wood-to-wood
applications.
Features:
Type-17 point enables easy driving with no pre-drilling and minimal splitting.
Available with a double-barrier coating and Type 316 stainless steel.
3/8" hex head with integrated washer.
Designed for installation in Simpson Strong-Tie® structural connectors as well as wood-to-wood applications.
Head is stamped with the Simpson Strong-Tie "≠" sign and fastener length for easy identification after installation.
Notes:
1. Loads are based on installation into side grain of the wood with the screw axis perpendicular to the face of the
member.
2. Adjusted yield value includes the adjustment factors selected above.
3. The tested yield value is based on testing conducted in accordance with AC233. It is the average ultimate test value
divided by 5. If no testing was done for the selected thickness then the minimum yield value is calculated based on
www.strongtie.com/fd Page 4 of 5
Fastener Designer: Solutions Report
Report Generated: September 12, 2019
Install Tips: A low-speed 1/2" drill with a 3/8" hex driver is the recommended tool for installation.
www.strongtie.com/fd Page 5 of 5