Sei sulla pagina 1di 3

1.

Nasa mock commx


2. Nasa mock commx din, di ko 7. Two 2-mm diameter wires held 6 cm
maalala tanong hahaha apart center-to-center has a
characteristic impedance of
3. The optimum value for the Standing A. 491 Ω
Wave Ratio is: B. 500 Ω
A. Zero C. 250 Ω
B. One D. 75 Ω
C. As large as possible
D. There is no optimum value

4. The characteristic impedance will


_____, if the spacing between the
wires of a balanced transmission line
is increased? 
A. Decreases
B. Increases 8. A TDR display shows a
C. Remain the same discontinuity 1.4μs from the start. If
D. None of the choices the line has a velocity factor of 0.8,
how far is the fault from the
5. A positive voltage pulse sent down a reflectometer?
transmission line terminated in a A. 16.8 m
short-circuit: B. 168 m
A. Would reflect as a positive pulse C. 32.5 m
B. Would reflect as a negative pulse D. 325 m
C. Would reflect as a positive pulse
followed by a negative pulse 
D. Would not affect at all
 if open circuit: would reflect as a 9. Find the input impedance, in ohms,
positive pulse for a 50Ω lossless transmission line,
3.5λ long, if the load is 20 + j75 Ω.
A. 7 +j8 Ω
6. What is the length in centimeters of a B. 12.5 – j6.25 Ω
quarter-wave stub, in free space at C. 20 + j75 Ω
4Ghz D. 6.25 – j12 Ω
A. 1.875 cm
B. 18.75 m 
10. A 500Ω short circuited line is 0.1λ in
C. 19 cm
length at a frequency of 500 MHz.
D. 19 m
𝑐 What is its equivalent inductive
 λ= 𝑓 ÷ 4
reactance?
𝑚 100𝑐𝑚
(3𝑥108
𝑠
𝑥
1𝑚
) A. j36.33 Ω
λ= ÷ (4) = 1.875 cm
4𝑥10 9
B. j33.66 Ω
C. j17.6 Ω B. Would reflect as a negative pulse
D. j36.53 Ω C. Would reflect as a positive pulse
followed by a negative pulse
11. A 300Ω line is terminated in a load D. Would not reflect at all
impedance of 100 + j200 Ω. What is 16. Find the characteristic impedance of
the reflection coefficient for this a coaxial cable using a polyethylene
line? dielectric with an inner conductor
A. 0.75120° 2mm in diameter and an outer
B. 0.632108° conductor of 8mm in diameter.
C. 0.3561.50° A. 5.48 Ω
D. 0.85212.20° B. 5.15 Ω
C. 550 Ω
D. 55.14 Ω

12. What is the distance between a


voltage maximum and adjacent 17. When the load impedance matches
current maximum on a transmission the line impedance, the value of
line with standing waves? standing wave ratio and reflection
A. λ/4 coefficient is ____,____ respectively.
B. λ/8 A. 1,0
C. λ/2 B. α,1
D. λ C. -1,α
D. 0,-1
13. a shorted quarter-wave line at the
operating frequency acts like a(an)
A. capacitor 18. Skin effect describes the tendency of
B. inductor A. dc conductors to carry the circuit
C. series resonant circuit current on their surface
D. parallel resonant circuit B. ac conductors to carry the circuit
 open – series current on their surface
C. both a and b
14. A balanced load can be connected to D. neither a nor b
an unbalanced cable
A. Directly
B. Using a “balun” 19. What is the effective capacitance of a
C. By using a filter shorted transmission line 3λ/7 long
D. Cannot be connected at 25 MHz if 𝑍𝑜 = 54Ω?
A. 52.1 pF
B. 245 pF
15. A positive voltage-pulse sent down a C. 0.79 pF
transmission line terminated in an D. 4.5 pF
open-circuit:
A. Would reflect as a positive pulse
20. Find the impedance of a 50Ω C. Inductive
transmission line at a distance of λ/8 D. Capacitive
from a 400Ω load.
A. 130-51°
B. 350-81°
C. 950-83°
D. 50-76°

21. What is the electrical wavelength of


500MHz signal?
A. 60cm
B. 6cm
C. 0.06cm
D. 6m

22. Quarter-wavelength line is used as


A. Lecher line
B. Harmonic suppressor
C. Impedance transformer
D. None of the choices

23. Waveguide becomes compulsory


above what frequencies?
A. Above 3GHz
B. At 300MHz
C. About 10kHz
D. None of the choices

24. Which transmission media is not


suitable to CSMA operation?
A. Balanced line
B. Unbalanced line
C. Optical Fiber
D. None of the choices

25. An open circuited line greater than


λ/4 but less than λ/2 in length will
exhibit _____ reactance.
A. Series resonant
B. Parallel resonant

Potrebbero piacerti anche