Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1-55
Rodamiento A
FILTRO DE MANGAS
Static
Frictional Power
Designation Bearing rating life Grease safety
moment loss
factor
Relubrication
SKF Explorer Basic SKF life Total
interval
h Nmm W
* SKF rating life ( L10mh ) for steel-steel bearings; GBLM load based life ( L10GMh ) for hybrid bearings
Warnings:
! Results are based on default operating conditions. Please, review and adjust operating conditions where needed
This report was produced with SKF Bearing Select software. Please note the limited warranty, shown at the bottom of the last page of this report
® SKF is a registered trademark of the SKF Group. © SKF Group 2019.
2. Input
2.1. Bearing data
Bearing
Designation Principal dimensions Basic load ratings Fatigue load limit
type
Popular item d D B C C0 Pu
mm kN
Deep groove
6014 70 110 20 39.7 31 1.32
ball bearing
Reference Limiting
nref nlim
r/min
This report was produced with SKF Bearing Select software. Please note the limited warranty, shown at the bottom of the last page of this report
® SKF is a registered trademark of the SKF Group. © SKF Group 2019.
2.2. Loads, Speed and Temperature
kN r/min °C
- Maximum temperature is used for calculating the actual viscosity, kappa, aSKF and SKF rating life.
- Mean temperature is used for calculating bearing friction and power loss.
2.3. Lubrication
Effective EP
Designation Lubricant Viscosity
additives
Designation Contamination
Detailed
6014 Normal cleanliness
guidelines
This report was produced with SKF Bearing Select software. Please note the limited warranty, shown at the bottom of the last page of this report
® SKF is a registered trademark of the SKF Group. © SKF Group 2019.
3. Results
SKF Explorer
kN
Popular item Fr Fa Fr m
kN
Adjusted reference
Designation Adjustment factors
speed
r/min
This report was produced with SKF Bearing Select software. Please note the limited warranty, shown at the bottom of the last page of this report
® SKF is a registered trademark of the SKF Group. © SKF Group 2019.
3.4. Lubrication conditions
Viscosity
Designation Operating viscosity
ratio
Rated @ 40
SKF Explorer Actual Rated
°C
mm²/s
Relubrication
Designation Grease quantity Speed factor
interval
h g mm/min
* SKF rating life ( L10mh ) for steel-steel bearings; GBLM load based life ( L10GMh ) for hybrid bearings
This report was produced with SKF Bearing Select software. Please note the limited warranty, shown at the bottom of the last page of this report
® SKF is a registered trademark of the SKF Group. © SKF Group 2019.
3.7. Bearing friction & power loss
Power
Designation Frictional moment Friction sources
loss
At start
SKF Explorer Total 20-30°C and Rolling Sliding Seals Drag loss
zero speed
Nmm W
Popular item fi fe fc fr
Hz
Hz
LIMITED WARRANTY : The SKF Bearing Select software tool of the SKF Company supports the calculation and selection of bearings.
This software is provided 'as is' with out any warranty of any sort, implicitly as well as explicitly.
Please note that the obtained results can be affected by many external parameters and/or the quality of the assumptions taken into account.
The results obtained using this software must be validated by the user who accepts the fact that the use of this software and the exploitation
of the obtained results are under the user's entire and sole responsibility.
® SKF is a registered trademark of the SKF Group. © SKF Group 2019.