Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. IDENTIFY DRIVE — Give complete data shown on Rexnord can normally furnish a total rotating assembly
drive nameplate. Also, give reference numbers, Falk® more economically than if the customer purchases
part numbers, and name of parts required. Drawings individual parts, disassembles the old parts, and
and reference numbers are representative of all sizes reassembles using some new and old parts. Falk
and the actual parts may not agree in exact detail for replacement assemblies also reduce down time and
each drive size. Complete nameplate data and parts always consist of all new parts.
reference number will assure receipt of correct parts. FASTENERS — Fasteners are sold in sets for a specific
The numerical designation stamped on the nameplate item, i.e. four for an end cover, eight for a low speed
completely identifies all parts used in the drive. All seal cage, etc. Fasteners describe cap screws, bolts,
drives with exactly the same nameplate markings have studs, nuts and lock washers as required.
interchangeable rotating elements. RATIO CHANGE — Refer complete information to
Rexnord.
Sample Nameplate SHAFT COUPLINGS — Refer to coupling parts guide
and price list.
HOW TO USE THIS GUIDE — Use the Part
4.
Reference Number (step 2) and the drive Model
Number (step 1) to determine the part description
and use this information to order the required parts.
ORDER PLACEMENT — Place your order with your
5.
local Rexnord Account Executive or Distributor. If
you need assistance, call the number below.
54
9
13 2
44 5V6
42 19
41
4
9
13
34
32
31
5
6
1V1 5V1 1
5V4
5V
ASSEMBLY
5V3
5V4
1V ASSEMBLY
See note 1, page 3
5V7
5V2
1V7 13
1V ASSEMBLY
See note 2, page 3 9
1V8 41
1V5 42
44
1V3 1V2
IV6
1V7 6
9
1V2
1V8 6 60
5
1V5
31
32
34
1V ASSEMBLY
See note 1, page 3
19
2
Notes:
1..Applies to units with nominal ratios of 1.25 – 1.60 for sizes 130 - 150, and to units with nominal ratios of 1.25 – 1.80 for sizes 160 - 180.
2..Applies to units with nominal ratios of 1.80 – 5.00 for sizes 130 - 150, and to units with nominal ratios of 2.00 – 5.00 for sizes 160 - 180.