Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
EDITION: 02
TECHNOLOGY
LABORATORY: CIVIL
REVISION NO: 01
ENGINEERING TECHNOLOGY
EXPERIMENT: AGGREGATE EFFECTIVE DATE: SEPT. 2016
IMPACT VALUE AMENDMENT DATE: AUG. 2016
DATE
GROUP NO.
(1)
LECTURER/ INSTRUCTOR
(2)
COMMENTS:
Level of A
Very
No Students
mistakes mistakes while
Display with
ls, but
A Most of
Procedures
procedures
procedures procedures
handling are
of
Respond
Able
Limited respond Able Unable
Respond ability to respond respond
answer to respond answer answer to
answer sometimes most of
to not match at all
Show the
discipline
Major Minor flaws Minor flaws Conform Conform to
follows
rules to criteria, criteria, dress code dress
minutes minutes minor flaw
-Dress
Regulations
Total
Mark:
2
FACULTY : ENGINEERING
EDITION: 02
TECHNOLOGY
LABORATORY: CIVIL
REVISION NO: 01
ENGINEERING TECHNOLOGY
EXPERIMENT: AGGREGATE EFFECTIVE DATE: SEPT. 2016
IMPACT VALUE AMENDMENT DATE: AUG. 2016
I hereby declare that I have prepared this report with my own efforts. I also admit to not accept or
provide any assistance in preparing this report and anything that is in it is true.
3
FACULTY : ENGINEERING
EDITION: 02
TECHNOLOGY
LABORATORY: CIVIL
REVISION NO: 01
ENGINEERING TECHNOLOGY
EXPERIMENT: AGGREGATE EFFECTIVE DATE: SEPT. 2016
IMPACT VALUE AMENDMENT DATE: AUG. 2016
1.0 OBJECTIVES
To determine the aggregate impact value in the laboratory.
3.0 INTRODUCTION
Impact value of an aggregate is the percentage loss pf weight of particles passing 2.36mm
sieve by the application on load by mean of 15 blows of standard hammer and drop under
specified test condition. The aggregate impact value gives a relation measure of the resistance
of an aggregate to sudden shock or impact, which in some aggregates differs from their
resistance to a slowly applied compressive load.
General: Normally the aggregate impact value of base course is 30, bituminous bound
macadam is about 35 and the cement concrete base course is 30.
Significance: The test gives an idea of toughness of the aggregate to resist facture under the
impact of moving loads.
2. Measure: A cylinder of internal diameter 7.5cm and 5cm deep for measure aggregate.
3. Tamping rod of I cm diameter and 23cm long rounded at one end and pointed at the other
end.
4. Sieves: 12.5mm, 10mm and 2.36mm opening.
5. Balance: 5000g capacity.
6. Laboratory oven capable of maintaining a constant temperature up to 1100C .
1
FACULTY : ENGINEERING
EDITION: 02
TECHNOLOGY
LABORATORY: CIVIL
REVISION NO: 01
ENGINEERING TECHNOLOGY
EXPERIMENT: AGGREGATE EFFECTIVE DATE: SEPT. 2016
IMPACT VALUE AMENDMENT DATE: AUG. 2016
5.0 PROCEDURE
1. Sieve the aggregate and obtain the portion passing 12.5mm and retained on 10mm sieve.
2. Wash and dry this aggregate at a constant temperature of 1050C to 1100C and then cool the
sample.
3. Fill this aggregate in the cylindrical measure in 3 layers, tapping each layers 25 times with
the tamping rod. Level the surface tamping road as a using the straight edge.
4. Weight the aggregate in the measure. This weight of the aggregate is used for the duplicate
test on the same material.
5. Transfer the aggregate from the cylindrical measure to the cup in 3 layers and compact each
layer by tamping in 25 strokes with the tamping rod.
6. Release the hammer for fall freely on the aggregate. The test sample is subjected to a total
of 15 blows.
7. Remove the aggregate sample from the cup and sieve through 2.36 mm sieve .
8. Weight the fraction passing the sieve.
2
FACULTY : ENGINEERING
EDITION: 02
TECHNOLOGY
LABORATORY: CIVIL
REVISION NO: 01
ENGINEERING TECHNOLOGY
EXPERIMENT: AGGREGATE EFFECTIVE DATE: SEPT. 2016
IMPACT VALUE AMENDMENT DATE: AUG. 2016
7.0 DISCUSSIONS
.............................................................................................................................
.............................................................................................................................
.............................................................................................................................
.............................................................................................................................
.............................................................................................................................
.............................................................................................................................
Signature/Tandatangan : Signature/Tandatangan :
Name/Nama : PN. NOOR KHAZANAH ABD Name/Nama : ASSOC. PROF DR.
RAHMAN SURAYA HANI ADNAN