Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Again, according to the SSPC, "loose" contaminants are those that can be removed by lifting off with
a dull putty knife.
Again, according to the SSPC, "loose" contaminants are those that can be removed by lifting off
with a dull putty knife.
According to the SSPC, a surface blasted to white metal should, without magnification, be free of all
visible “oil, grease, dust, dirt, mill scale, rust, coating, oxides, corrosion products, and other foreign
matter.”
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
Similar to a white metal blast cleaning, surfaces prepared to an SP6 standard should be, without
magnification, free of all visible oil, grease, dust, dirt, mill scale, rust, coating, oxides, corrosion
products, and other foreign matter.
Random staining from previous exposure to the above is acceptable, however, so long as it does not
comprise more than 33 percent of each area “unit”, as described by the standard. Such staining may
take the form of “light shadows, slight streaks, or minor discolorations caused by stains of rust, stains
of mill scale, or stains of previously applied coating,” according to the SSPC.
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
condition.
All oil, grease, dirt, dust must be cleared from the surface when viewed without magnification. Loose
mill scale, rust and coatings must also be removed according to this standard, but tightly adherent mill
scale, rust and coatings may remain. These are considered tightly adherent if they cannot be
removed by lifting with a dull putty knife.
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
Unlike with a commercial blast, only five percent of each area “unit” as defined by the standard may
exhibit staining. This five percent may consist of light shadows, slight streaks minor discolorations that
could be the result of exposure to rust, mill scale or of a previous coating.
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
This standard covers requirements for thermal, mechanical and chemical application methods.
Minimum concrete surface strength, surface profile and moisture content should be expressly stated
in the project’s specification document when necessary.
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
residue and surface stains to remain. This standard allows for tightly adhering mill scale, rust and
coatings, as well as surface stains to remain on ten percent of each “unit” area, as described by the
standard. Surface stains may consist of light shadows, slight streaks minor discolorations that could
be the result of exposure to rust, mill scale or of a previous coating.
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds
Grease Oils Dirt & Drawing & Mill Rust Paint Oxide
Dust Cutting Scale Coating
Compounds